2003 Ford Mustang TSBs

SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT...

ENGINE MISFIRE WITH DIAGNOSTIC TROUBLE CODE (DTC) PEWEE, P0302, P0303, P0304, P0305, P0306, P0307, P0308, AND P0316.

WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING.

EXHAUST LEAK - CRACKED OR SEPARATED RIGHT SIDE EXHAUST PIPE - 3.8L AND 3.9L ENGINES.

ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS.

EXHAUST LEAK. RIGHT SIDE EXHAUST PIPE ON 3.8L OR 3.9L ENGINE.

SERVICE CYLINDER HEAD GASKET FOR 4.6L APPLICATIONS.

FUEL PRESSURE RELIEF VALVE (SCHRADER VALVE) DISCONTINUED.

ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION.

ENGINE-ROMEO BUILT 4.6L 2V-TICK NOISE FROM ENGINE-ENGINES BUILT BEFORE 9/17/2003.

ENGINE TICKING NOISE.

SOME MACH 1 VEHICLES EQUIPPED WITH MANUAL TRANSMISSION MAY EXHIBIT AN INTERMITTENT HIGH IDLE CONDITION WITH THE THROTTLE CLOSED.

TICKING/TAPPING NOISE WITH THE ENGINE WARMED UP AND THE TRANSMISSION IN GEAR AT IDLE.

ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED...

SOME VEHICLES, EQUIPPED WITH THE 4.6L 2V ENGINE, WITH AN ENGINE BUILD DATE PRIOR TO 8/29/03 MAY EXHIBIT AN ENGINE TICK...

SOME VEHICLES EQUIPPED WITH A 3.8L ENGINE AND THE T5 TRANSMISSION MAY EXHIBIT HIGH IDLE BETWEEN SHIFTS.

SOME COBRAS MAY EXHIBIT A CLUNK NOISE FROM THE DRIVELINE DURING A QUICK ACCLERATION JUST AFTER COAST (TIP-IN CLUNK).

SAFETY BELT RETRACTION SPEED.

LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS.

CONVERTIBLE TOP LIFTS UNEVENLY.

NOISE-WINDNOISE FROM THE A PILLAR AREA.

LACK OF POWER ON DECELERATION.

HEADLINER SAGGING IN REAR OF VEHICLE.

OVERHEATING CONDITION - COOLING SYSTEM FILL/BLEED PROCEDURE.

DRIVELINE VIBRATION. COBRA MODELS.

CONVERTIBLE TOP LIFTING UNEVENLY.

POPPING TYPE NOISE WHILE TURNING INTO OR OUT OF AN INCLINE, SUCH AS TURNING INTO A DRIVEWAY, AT LOW SPEEDS (BELOW 15 MPH (25 KM/H).

DRIFT OR PULL TO RIGHT OR LEFT.

SOME VEHICLES WITH MANUAL TRANSMISSION MAY EXHIBIT A HARD TO SHIFT INTO GEAR CONDITION PARITCULARLY FROM A STOP INTO FIRST OR REVERSE GEAR.

TR3650 MANUAL TRANSMISSION - JUMPS OUT OF GEAR 2ND AND/OR 3RD - CLASH NOISE AND/OR RASPY FEEL ON GEAR ENGAGEMENT.

POP/CLUNK OR SQUEALING NOISE FROM THE STEERING GEAR WHEN TURNING, DRIVING OVER BUMPS, OR BRAKING.

MANUAL TRANSMISSION HARD TO SHIFT INTO FIRST/REVERSE FROM A STOP.

TRANSMISSION RATTLE NOISE OR DIFFICULT TO SHIFT CONDITION ON VEHICLES EQUIPPED WITH A TREMEC T56 6 SPEED MANUAL TRANSMISSION.

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK.

NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP.

AUTOMATIC TRANSMISSION GEAR SELECTOR LEVER STUCK IN PARK, UNABLE TO SHIFT INTO PARK.

GEAR WHINE IN 1ST, 3RD AND REVERSE GEARS.

THUMP NOISE WHEN A/C CLUTCH ENGAGES.

DRIVELINE CLUNK DURING GEAR CHANGES AND/OR QUICK ACCELERATION AFTER COAST (TIP-IN) CLUNK.

THUMP NOISE WHEN AIR CONDITIONING CLUTCH ENGAGES.

CONDENSATION AND / OR WATER ACCUMULATION WITHIN THE FOG LAMP ASSEMBLY.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS.

CONDENSATION AND/OR WATER ACCUMULATION IN THE HEADLAMP ASSEMBLY.

INTERMITTENT LOSS OF POWER OR CRANK NO START - POSSIBLE PATS LAMP FLASHING AND DIAGNOSTIC TROUBLE CODES (DTCS) U1147 AND/OR U1262.

CONDENSATION AND/OR WATER ACCUMULATION WITHIN THE FOG LAMP ASSEMBLY.

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK...

SAFETY BELT WEB STOP BUTTON SERVICE.

REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS.

PASSENGER SEAT RUBS AGAINST DOOR PANEL.

LOOSE DOOR TRIM PANEL OR A NOISE FROM THE DOOR TRIM PANEL AREA WHEN DRIVING OVER BUMPS.

FRONT SUSPENSION NOISE.

FRONT SUSPENSION NOISE.

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.

STEERING RACK NOISE. *TT SQUEAK/CREAK NOISE FROM STEERING RACK WHEN TURNING.

CLIMATE CONTROL A/C SERVICE TECH TIPS.

SQUEAKING OR CRUNCHING NOISE FROM THE FRONT SUSPENSION WHILE DRIVING OVER BUMPS OR BRAKING.