2002 Ford Mustang TSBs

SOME VEHICLES WITH THE TR6350 MANUAL TRANSMISSION MAY EXHIBIT A LIGHT TICKING / RATTLE NOISE WHILE DRIVING AFTER A COLD ENGINE START.

SOME VEHICLES EQUIPPED WITH A 4.6L 2V ENGINE BUILT BEFORE MAY 17, 2002, MAY EXHIBIT AN OIL LEAK COMING FROM THE CRANKCASE / VALVE COVER AREA.

ON SOME VEHICLES EQUIPPED WITH THE 4.6L ENGINE, THE FRONT END ACCESSORY DRIVE (FEAD) BELT MAY HYDROPLANE ON THE WATER...

ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE.

SOME VEHICLES MAY RUN ROUGH AT CRUISE OR MOMENTARILY AFTER STOPPING, A CHECK ENGINE LIGHT,AND P030X CODES.

SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA.

SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174.

SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY...

SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT...

WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING.

EXHAUST LEAK - CRACKED OR SEPARATED RIGHT SIDE EXHAUST PIPE - 3.8L AND 3.9L ENGINES.

ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS.

EXHAUST LEAK. RIGHT SIDE EXHAUST PIPE ON 3.8L OR 3.9L ENGINE.

ENGINE-OIL LEAK FROM POSITIVE CRANKCASE VENTILATION (PCV) VALVE AREA-VEHICLES BUILT BEFORE 5/17/2002 EQUIPPED WITH 4.6L 2V ENGINE ONLY.

SERVICE CYLINDER HEAD GASKET FOR 4.6L APPLICATIONS.

ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION.

ENGINE-ROMEO BUILT 4.6L 2V-TICK NOISE FROM ENGINE-ENGINES BUILT BEFORE 9/17/2003.

TICKING/TAPPING NOISE WITH THE ENGINE WARMED UP AND THE TRANSMISSION IN GEAR AT IDLE.

ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED...

SOME VEHICLES, EQUIPPED WITH THE 4.6L 2V ENGINE, WITH AN ENGINE BUILD DATE PRIOR TO 8/29/03 MAY EXHIBIT AN ENGINE TICK...

SOME VEHICLES EQUIPPED WITH A 3.8L ENGINE AND THE T5 TRANSMISSION MAY EXHIBIT HIGH IDLE BETWEEN SHIFTS.

SOME VEHICLES WITH MANUAL TRANSMISSION MAY EXHIBIT A HARD TO SHIFT INTO GEAR CONDITION PARITCULARLY FROM A STOP INTO FIRST OR REVERSE GEAR.

CONCERNS WITH A TR3650 MANUAL TRANSMISSION EXHIBITING CLASH/GRINDING SOUND DURING THE FIRST FEW MILES OF DRIVING.

BRAKE SHIFT INTERLOCK.*JB

INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS.

TR3650 MANUAL TRANSMISSION - JUMPS OUT OF GEAR 2ND AND/OR 3RD - CLASH NOISE AND/OR RASPY FEEL ON GEAR ENGAGEMENT.

POP/CLUNK OR SQUEALING NOISE FROM THE STEERING GEAR WHEN TURNING, DRIVING OVER BUMPS, OR BRAKING.

MANUAL TRANSMISSION HARD TO SHIFT INTO FIRST/REVERSE FROM A STOP.

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK.

NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP.

GEAR WHINE IN 1ST, 3RD AND REVERSE GEARS.

THUMP NOISE WHEN A/C CLUTCH ENGAGES.

DRIVELINE CLUNK DURING GEAR CHANGES AND/OR QUICK ACCELERATION AFTER COAST (TIP-IN) CLUNK.

THUMP NOISE WHEN AIR CONDITIONING CLUTCH ENGAGES.

SUBJECT REGARDING INACCURATE SPEEDOMETER.

SOME VEHICLES MAY EXHIBIT A WIND NOISE FROM EITHER SIDE OF THE A-PILLAR AREA.

SOME COBRAS MAY EXHIBIT A CLUNK NOISE FROM THE DRIVELINE DURING A QUICK ACCLERATION JUST AFTER COAST (TIP-IN CLUNK).

SOME CONVERTIBLES MAY EXHIBIT A CONDITION WHERE THE CONVERTIBLE TOP LIFTS UNEVENLY.

SOME VEHICLES MAY EXHIBIT A FEAD BELT JUMP-OFF TOSS.

SAFETY BELT RETRACTION SPEED.

LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS.

CONVERTIBLE TOP LIFTS UNEVENLY.

NOISE-WINDNOISE FROM THE A PILLAR AREA.

HEADLINER SAGGING IN REAR OF VEHICLE.

CONVERTIBLE TOP LIFTING UNEVENLY.

POPPING TYPE NOISE WHILE TURNING INTO OR OUT OF AN INCLINE, SUCH AS TURNING INTO A DRIVEWAY, AT LOW SPEEDS (BELOW 15 MPH (25 KM/H).

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS.

STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES...

STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK...

STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES...

MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC...

SUBJECT REGARDING P0460 DIAGNOSTIC TROUBLE CODE AND MALFUNCTION INDICATOR LAMP ILLUMINATION.

SUBJECT REGARDING SPEED CONTROL LAMP.

INOPERATIVE OR INACURRATE SPEEDOMETER, 4X4 LAMP ILLUMINATD, AND / OR DIAGNOSTIC TROUBLE CODE P1635 OR P1639.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS.

CONDENSATION AND/OR WATER ACCUMULATION IN THE HEADLAMP ASSEMBLY.

INTERMITTENT LOSS OF POWER OR CRANK NO START - POSSIBLE PATS LAMP FLASHING AND DIAGNOSTIC TROUBLE CODES (DTCS) U1147 AND/OR U1262.

INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES.

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.

CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4.

CONCERNS WITH VEHICLES EXHIBITING DOOR GLASS INOPERATIVE CONDITION.

PASSENGER SEAT RUBS AGAINST DOOR PANEL.

LOOSE DOOR TRIM PANEL OR A NOISE FROM THE DOOR TRIM PANEL AREA WHEN DRIVING OVER BUMPS.

SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS.

CLIMATE CONTROL A/C SERVICE TECH TIPS.

SAFETY BELT WEB STOP BUTTON SERVICE.

REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS.

THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT).

STEERING RACK NOISE. *TT SQUEAK/CREAK NOISE FROM STEERING RACK WHEN TURNING.