1994 Ford Mustang TSBs

BRAKE SHIFT INTERLOCK.*JB

INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS.

SOME VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION MAY EXHIBIT A POWERTRAIN NOISE DESCRIBED AS A BRIEF ROAR, HOOT OR...

SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM.

SUBJECT REGARDING A NEW TRANSMISSION CASE AND MAIN CONTROL RELEASED FOR SERVICE ON AODE / 4R70W TRANSMISSIONS.

INFORMATION REGARDING TSB 98-5A-12 (TRANSAXLE/TRANSMISSION/TRANSFER CASE-VEHICLES TOWED BEHIND RECREATIONAL...

INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP.

CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK.

EXPERIENCING VIBRATION/ NOISE FELT IN CLUTCH PEDAL WHEN LIGHTLY TOUCHING CLUTCH PEDAL.

INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART.

EXPERIENCING A TORQUE CONVERTER CLUTCH SHUDDER OR VIBRATION.

VEHICLES MAY ENCOUNTER DIFFICULTY GETTING THE SHIFT LEVER INTO GEAR WHEN THE CLUTCH DISC IS HOT.

VEHICLES BUILT PRIOR TO 3/1/97 MAY ENCOUNTER DIFFICULTY GETTING THE SHIFT LEVER INTO GEAR WHEN THE CLUTCH DISC IS HOT.

FLUID- TRANSMISSION FLUID USAGE CHARTS.

VIBRATION/NOISE FROM THE CLUTCH PEDAL.

TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP.

TRANSMISSION - AODE - 4R70W - SHUDDER OR VIBRATION UNDER LIGHT TO MODERATE ACCELERATION ABOVE 56 KM/H (35 MPH) WHILE IN 3RD OR 4TH GEAR.

TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP.

VEHICLES EQUIPPED W/ AN AODE OR 4R70W TRANS HAS A CONCERN OF SHUDDER FROM THE TRANSMISSION TORQUE CONVERTER CLUTCH IN...

INFORMATION ON AODE/4R7W TRANSMISSION MAIN CONTROL & CASE REPLACEMENT.

VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION MAY EXHIBIT A WHINE NOISE.

THERE MAY BE AN INTERMITTENT LOSS OF TORQUE DURING OR JUST AFTER THE 3-4 UPSHIFT OR IN 4TH GEAR ON SOME VEHICLES.

TORQUE CONVERTER CLUTCH SHUDDER/VIBRATION.

POSSIBLE WATER INTRUSION IN THE MLP/TR SENSOR CAUSING SHIFT CONCERN.

DELAYED OR NO FORWARD ENGAGEMENT OF TRANSMISSION.

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK.

NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP.

SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA.

INFORMATION REGARDING ENGINE REPLACEMENTS WARRANTY EXTENSION PROGRAM.

INFORMATION REGARDING ENGINE REPLACEMENTS WARRANTY EXTENSION PROGRAM.

SOME VEHICLES MAY EXHIBIT A VIBRATION THAT MAY BE HEARD OF FELT AT THE CLUTCH PEDAL BETWEEN IDLE AND 2300 RPM, AND GOES...

SOME VEHICLES MAY EXHIBIT PREMATURE FAILURE OF THE HEAD GASKET(S).

SUBJECT REGARDING OWNER NOTIFICATION PROGRAM SUPPLEMENT #1 3.8L ENGINE HEAD GASKETS.

INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART.

SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES.

FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR.

FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS.

VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS.

BLOWER MOTOR- "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS.

BLOWER MOTOR- "CHIRP" OR "SQUEAK" FROM BLOWER MOTOR AT LOW SPEEDS.

AN ENGINE OIL LEAK AT THE REAR CRANKSHAFT OIL SEAL.

ENGINE OIL LEAK AT THE REAR CRANKSHAFT OIL SEAL.

BLOWER MOTOR - INTERMITTENT OR INOPERATIVE - TEMPERATURES AT OR BELOW 0 DEGREES C (32 DEGREES F).

FORD IMPROVEMENT PROGRAM REQUEST FOR INFORMATION ON OIL LEAK AT THE REAR CRANKSHAFT OIL SEAL.

MUSTANG DOES NOT PROVIDE A SIMPLE MEANS OF CASTER ADJUSTMENT WHEN PERFORMING A FRONT END ALIGNMENT.

CHIRP OR SQUEAK NOISE FROM BLOWER MOTOR AT LOW SPEEDS.

CHIRP OR SQUEAK FROM BLOWER MOTOR.

NEW TORQUE-TO-YIELD CYLINDER HEAD BOLT KIT.

A SLIGHT ENGINE VIBRATION MAY BE FELT IN THE VEHICLE, STEERING COLUMN, FLOOR OR SEAT.

SUBJECT REGARDING PARKING BRAKE CONTROL ASSEMBLY MODIFICATION.

ABS DIAGNOSTIC TROUBLE CODES(DTCS) CAN ONLY BE RETRIEVED USING SUPER STARII TESTER OR THE FLASH OUT PROCEDURE BY...

INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT.

SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT.

AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT.

THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE.

SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS.

EXPERIENCING A SQUEAKING NOISE COMING FROM THE REAR BRAKES ON SOME VEHICLES.

SOME VEHICLES MAY HAVE A RUBBING NOISE COMING FROM UNDERNEATH THE VEHICLE-PARKING BRAKE CABLE CONDUIT CONTACTING DRIVESHAFT.

HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE.

AUTHORIZED WARRANTY PART REPLACEMENT OF BRAKE PADS TO CORRECT EXCESSIVE BRAKE NOISE.

BRAKES - REAR BRAKES SQUEAK - VEHICLES BUILT THROUGH 11/20/94.

BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP.

THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE...

BRAKES-RUBBING NOISE FROM UNDERNEATH VEHICLES-PARKING BRAKE CABLE CONDUIT CONTACTING DRIVESHAFT.

INTERIOR TRIM-CONSOLE-INTERFERENCE BETWEEN PARKING BRAKE HANDLE AND CONSOLE GAP HIDER.

REAR BRAKE SQUEAK. *TW

ROUGHNESS CONCERN DURING BRAKE APPLICATION.

FRONT DISC BRAKE NOISE WHILE BRAKING.

INFORMATION REGARDING FREE FLOOR MAT EXCHANGE.

CONCERNS WITH THE CONVERTIBLE TOP BOOT MAY FIT IMPROPERLY OR BE DIFFICULT TO INSTALL ON SOME VEHICLES DUE TO THE TOP NOT...

INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA.

INFORMATION ON POWER SEAT SWITCH REPLACEMENT.

UNKNOWN

THE COWL TOP VENT GRILLE ASSEMBLY MAY CRACK AT THE WASHER JET.

VEHICLES MAY EXHIBIT A RUMBLE/CLUNK WHEN GOING OVER BUMPS.

VEHICLES MAY EXHIBIT A WHINE NOISEWHEN DRIVING AT A STEADY SPEED AROUND 38-44 MPH.

REVISED OIL PAN GASKET.

REVISED OIL FILL PROCEDURES.

NEW RADIATOR MANUFACTURING PROCESS/MODIFICATION.

UNKNOWN

SOME VEHICLES MAY EXHIBIT THE DOOR GLASS COMING OFF OF THE WINDOW TRACK.

SOME VEHICLES EXHIBIT THE DOOR GLASS POPPING OFF TRACK.

SOME VEHICLES MAY EXHIBIT A HOOD THAT IS HARD TO CLOSE.

SOME CONVERTIBLES MAY EXHIBIT A RATTLE NOISE FROMTHE DOOR WEDGE WHEN DRIVING ON ROUGH ROADS.

CONCERNS WITH THE FRONT WINDOW MAY TRAVEL BEYOND THE UPSTOP AND EXIT THE GLASS RUN ON SOME VEHICLES.

A NEW SILICONE GASKET AND SEALANT.

WINDSHIELD AND INTERIOR GLASS - FOG/FILM.

IF MUSTANG W/ INOPERATIVE FOG LAMP, CHECK FOG LAMP FOR ANY SIGNS OF WATER INTRUSION.

VEHICLES MAY EXHIBIT A CONDITION WHERE THE CENTER CONSOLE FINISH PANEL MAY NOT SEAT PROPERLY OR MAY POP OUT.

MOULDINGS - ROCKER PANEL LOOSE.

MANFACTURER REQUEST FOR RETURN OF FRONT DOOR OUTSIDE ELECTRIC MIRROR.

INFORMATION ON CASTER ADJUSTMENT WHEN PERFORMING A FRONT END ALIGNMENT.

INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE.

ON COBRA VEHICLES ONLY, A RATTLING NOISE MAY BE HEARD FROM THE FRONT WHEELS WHEN GOING OVER BUMPS AND / OR A CLUNKING...

INSTRUCTIONS FOR ADJUSTING THE CASTER WHEN PERFORMING A FRONT END ALIGNMENT.

INSTRUCTIONS ON HOW TO ADJUST THE CASTER WHEN PERFORMING A FRONT END ALIGNMENT.

CONVERTIBLES BUILT AFTER 12/4/95 WILL INCORPORATE REVISED INSIDE VISOR MOUNTING BRACKETS.

COBRA VEHICLES ONLY - A RATTLE NOISE MAY BE HEARD FROM THE FRON WHEELS WHEN GOING OVER BUMPS AND/OR A CLUNK NOISE MAY BE...

SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES.

INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS).

MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP.

POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP.

MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP.

WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS.

VEHICLES MAY HAVE A DISCONNECT OF THE IGNITION CONTROL MODULE (ICM) CONNECTOR OR MOISTURE BUILDUP WITHIN THE CONNECTOR.

SOME VEHICLES AND CERTAIN FEDERAL EMISSION EQUIPPED VEHICLES MAY EXHIBIT A FUEL SMELL IN THE PASSENGER COMPARTMENT AT TIMES.

VEHICLES WITH FEDERAL EMISSION EQUIPPED 1998, MAY EXHIBIT A FUEL SMELL IN THE PASSENGER COMPARTMENT AT TIMES.

EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP.

EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM.

INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM.

FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE.

SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS.

INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS.

SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM.

AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL.

CLIMATE CONTROL A/C SERVICE TECH TIPS.

SUBJECT REGARDING SPEED CONTROL LAMP.

ILLUMINATION OF THE MALFUNCTION INDICATOR LAMP (MIL) AND / OR THE O/D LIGHT FLASHING.

INOPERABLE POWER SEATS, LIGHTER AND AUXILIARY POWER POINT DUE TO A SHORTED WIRE.

SUBJECT REGARDING THE SUBWOOFER ENCLOSURE ON COUPES WITH THE MACH 460 AUDIO SYSTEM.

SUBJECT REGARDING THE SUBWOOFER ENCLOSURE ON COUPES WITH THE MACH 460 AUDIO SYSTEM.

EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO.

SOME VEHICLES MAY EXHIBIT SOME NORMAL SERVICE CONCERNS WITH POWER SEAT OPERATION.

INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP.

REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS.