2006 Ford Freestyle TSBs
23 Technical Service Bulletins across 12 categories
Categories
Engine
4 bulletinsMotorcraft Continuously Variable Chain-Type Transmission Fluid (XT-7-QCFT in non-Canadian markets, CXT-7-LCF12 in...
Read full bulletin
Canada) is no longer manufactured and will only be available until inventory depletes. The recommended replacement fluids are Phillips 66 VersaTrans CVT Plus Fluid or Kendall VersaTrans CVT Plus Fluid. Mixing Motorcraft CVT fluid (blue-green color) with these replacement fluids (red color) in the same transmission is acceptable.
FORD: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
MOMENTARY ENGINE IDLE RPM SURGE MAY BE INTERMITTENT AND MAY OCCUR, DUE TO DEPOSITS BUILDUP IN THROTTLE BODY, AT LOW SPEEDS, WHILE PARKING OR ENTERING DRIVEWAY AND CHECK ENGINE LAMP MAY ILLUMINATE. MODELS 2005-07 FREESTYLE, 500, MONTEGO. *PE
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING.
Read full bulletin
*TT
ENGINE RPM FLUCTUATION AT HIGHWAY CRUISING SPEEDS - VEHICLES BUILT PRIOR TO 8/2/2005.
Read full bulletin
*TT
Electrical
3 bulletinsThe Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs).
Read full bulletin
The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
MIL ON WITH DTC P0191 - FUEL RAIL PRESSURE SENSOR CIRCUIT PERFORMANCE.
Read full bulletin
*KB
BATTERY LIGHT ILLUMINATED.
Read full bulletin
*KB
Other
3 bulletinsMIL WITH DTC P0106 AND/OR P0109.
Read full bulletin
*KB
SECOND ROW SEAT RECLINE CONCERN.
Read full bulletin
*TT
HEATED SEATS INOPERATIVE.
Read full bulletin
*TT
Brakes
2 bulletinsFORD\MERCURY SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
CERTAIN 2005 THROUGH 2007 FWD AND AWD FORD FIVE HUNDRED, FREESTYLE AND MERCURY MONTEGO VEHICLES - REAR BRAKE WEAR. ALSO HAVE AN OWNER'S LETTER. *NJ UPDATED 1/25/08. *NJ
REAR BRAKE DRAG, NOISE, DUST, AND/OR PREMATURE PAD WEAR.
Read full bulletin
*KB
Transmission
2 bulletinsTRANSMISSION SHIFTER BINDING / HIGH EFFORT BEZEL REPLACEMENT.
Read full bulletin
*KB
CONTINUOUSLY VARIABLE TRANSAXLE (CVT) NOISE DIAGNOSIS.
Read full bulletin
*TT
Lighting
2 bulletinsINTERMITTENT INSTRUMENT CLUSTER OPERATION - INCLUDING GAUGES SWEEP/RESET - MULTIPLE WARNING LIGHTS ILLUMINATED AND/OR REVERSE LIGHTS STAY ON.
Read full bulletin
THIS APPLIES TO VEHICLES BUILT BEFORE 02-17-06. *KB
INTERMITTENT INSTRUMENT CLUSTER GAUGE SWEEP/RESET - MULTIPLE WARNING LIGHTS ON - REVERSE LIGHTS ON - VEHICLES BUILT BEFORE 2/17/2006.
Read full bulletin
*TT
Body & Paint
2 bulletinsINTERMITTENT BOUNCE-BACK OF THE DRIVER'S WINDOW DURING ONE TOUCH UP OPERATION.
Read full bulletin
*TT
NOISE IN RIGHT FRONT OF PASSENGER COMPARTMENT - AIR INLET DOOR ACTUATOR INOPERATIVE (RECIRCULATION).
Read full bulletin
*TT
Tires & Wheels
1 bulletinPREMATURE SHOULDER (TOE) WEAR ON INSIDE EDGE OF THE FRONT TIRES.
Read full bulletin
*KB
Fuel System
1 bulletinFUEL GAUGE ERRATIC/INACCURATE AND/OR MIL ON WITH DTC P0463, B1202, B2627, B2879, AND/OR P2068.
Read full bulletin
*KB
Air Bags & Safety
1 bulletinAIR BAG LIGHT ON WITH DTC B2290 - DIFFICULT TO DUPLICATE.
Read full bulletin
*KB
Infotainment
1 bulletinTENTHS DIGIT NOT DISPLAYED ON ODOMETER AFTER 10,000 MILES/KILOMETERS.
Read full bulletin
*TT
Suspension
1 bulletinGRUNT OR SQUEAK FROM FRONT SUSPENSION DURING FULL LOCK TURNS - SERVICE TIP.
Read full bulletin
*TT