2005 Ford Focus TSBs

The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs).

MIL ON/ROUGH RUNNING - MUTIPLE DTCS -0201, P0202, P0203 OR P0204 PRESENT IN THE POWERTRAIN CONTROL MODULE (PCM).

WINDSHIELD WIPER RELAY - CLICKING NOISE.

SERVICE WIRING HARNESS REPLACEMENT GUIDELINES - SERVICE TIPS.

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.

NO CRANK WITH DIAGNOSTIC TROUBLE CODE DTC B16011 AND OR PATS SECURITY ACCESS ISSUES.

UNABLE TO REMOVE IGNITION KEY - SERVICE TIP.

INTERMITTENT NO CRANK CONDITION.

NEUTRAL TOW CAPABILITY - SERVICE KIT REQUIREMENTS.

MIRFIRE DIAGNOSTIC TROUBLE CODES P0316, P0300, P0301, P0302, P0303, OR P0304 - SERVICE TIP.

DTC P0316, P0300, P0301, P0302, P0303 AND/OR P0304 - SERVICE TIP.

NEUTRAL TOW CAPABILITY -- SERVICE KIT REQUIREMENTS.

ERRATIC INSTRUMENT CLUSTER GAUGES AND/OR WARNING INDICATORS - SERVICE TIP.

SAFETY BELT WEB STOP BUTTON SERVICE.

CRANK NO START OR OTHER DRIVEABILITY CONCERNS - SERVICE TIP.

MTX-75 PREMATURE CLUTCH FAILURE.

DIFFICULT OR UNABLE TO SHIFT INTO 5TH GEAR.

HARSH TRANSMISSION ENGAGEMENT AND OR DTC P0705.

HARSH TRANSMISSION ENGAGEMENT AND OR DTC P0705.

CLUTCH RETURNABILITY ISSUES - SERVICE TIP.

DIFFICULTY CHANGING GEARS - UNABLE TO ENGAGE GEARS.

DEMONSTRATION/DELIVERY/RENTAL HOLD: SERVICE ACTION 04E11 CERTAIN 2005 MODEL YEAR PZEV FORD FOCUS WITH AUTOMATIC...

FUEL FILL SLOW EARLY SHUT OFF.

SLOW FILL OR PREMATURE SHUTOFF WHEN FILLING THE FUEL TANK.

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS.

DEMONSTRATION/DELIVERY HOLD.

POSSIBLE ENGINE DAMAGE - INSTALL SPECIAL SERVICE TOOLS PRIOR TO REMOVING CRANKSHAFT PULLEY BOLT.

POSSIBLE ENGINE DAMAGE - INSTALL SPECIAL SERVICE TOOLS PRIOR TO REMOVING CRANKSHAFT PULLEY BOLT - SERVICE TIP.

LONG CRANK/HARD START - 2.0L AND 2.3L ENGINE WITH MTX-75 TRANSAXLE.

ENGINE VIBRATION AT IDLE.

MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P2004 (INTAKE MANIFOLD RUNNER CONTROL STUCK OPEN - BANK 1).

ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS.

Safety recall 05S27 - Rear door latch corrosion - requests for recall service action - built on or before 01/26/2005

For 2000-2005 Focus vehicles built on or before 1/26/2005 Safety Recall 05S27 has been issued for vehicles that are...

FORD: REAR DOOR LATCHES ARE EXPERIENCING CORROSION IN PAWL PIVOT AREA THAT PREVENT PROPER ENGAGEMENT OF PAWL INTO...

FORD: ON SOME VEHICLES, OPERATING FOR AN EXTENDED TIME IN HIGH CORROSION AREA, A SAFETY RECALL 05S27 WAS ISSUED, WHERE...

EXTERNAL LIFTGATE RELEASE SWITCH NON-FUNCTIONAL ON MANUAL DOOR LOCK EQUIPPED VEHICLES.

VENT LEAK. *EH

WELD BONDING PROCEDURE.

LUGGAGE COMPARTMENT LID WILL NOT OPEN/RE-LATCHES WHEN OPENING WITH REMOTE TRANSMITTER OR LUGGAGE COMPARTMENT LID RELEASE SWITCH.

CRANK NO START OR HARD START COLD.

LOSS OF INTERMITTENT WIPER OR WIPER PARK FUNCTION.

INCREASED BRAKE PEDAL EFFORTS REQUIRED ON INITIAL STOPPING AFTER COLD START AT HIGH ALTITUDE.

REAR BRAKE SQUEAL. *TT

INCREASED BRAKE PEDAL EFFORTS REQUIRED ON INITIAL STOPPING AFTER COLD START AT HIGH ALTITUDE.

BRAKE AND ANTI-LOCK BRAKE SYSTEM LIGHTS ON AFTER HEC (HYBRID ELECTRONIC CLUSTER) REPLACEMENT.

FORD: PREMATURE FRONT/REAR TIRE WEAR AND/OR VEHICLE DRIFT ON WET OR SNOW COVERED ROADS.

REAR TIRE WEAR - REAR TOE SPECIFICATION CORRECTION.

MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P2004.

NO CRANK ON START CHARGING SYSTEM WARNING INDICATOR ON DRIVEABILITY CONCERNS AND OR MALFUNCTION INDICATOR LAMP ON.

CLUNK OR POP NOISE FROM FRONT SUSPENSION OVER BUMPS - SERVICE TIP.

INABILITY TO PLAY HOME MADE CD ON SINGLE CD AUDIO SYSTEM WITHOUT MP3 CAPABILITY.

A/C CONDENASTION LEAK.