2004 Ford Focus TSBs

MTX-75 PREMATURE CLUTCH FAILURE.

DIFFICULT OR UNABLE TO SHIFT INTO 5TH GEAR.

HARSH TRANSMISSION ENGAGEMENT AND OR DTC P0705.

HARSH TRANSMISSION ENGAGEMENT AND OR DTC P0705.

DIFFICULTY CHANGING GEARS - UNABLE TO ENGAGE GEARS.

UPDATE SUPPLEMENT ANNOUNCEMENT - CUSTOMER SATISFACTION PROGRAM 04B16.

GRINDING WHEN SHIFTING INTO THIRD GEAR.

2ND OR 4TH GEAR MISSED WHEN SHIFTING AND/OR INTERMITTENT NEUTRALING WHEN SHIFTING INTO 4TH GEAR.

2ND OR 4TH GEAR MISSED WHEN SHIFTING AND/OR INTERMITTENT NEUTRALING WHEN SHIFTING INTO 4TH GEAR.

CLUNKING FOR RATTLING NOISE IN THE TRANSMISSION.

HARSH TRANSMISSION ENGAGEMENT WITH POSSIBLE MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODE (DTC) P0705 (TR CIRCUIT FAILURE).

PREMATURE CLUTCH WEAR.

POSSIBLE ENGINE DAMAGE - INSTALL SPECIAL SERVICE TOOLS PRIOR TO REMOVING CRANKSHAFT PULLEY BOLT.

POSSIBLE ENGINE DAMAGE - INSTALL SPECIAL SERVICE TOOLS PRIOR TO REMOVING CRANKSHAFT PULLEY BOLT - SERVICE TIP.

REPLACE TIMING BELT IDLER PULLEY DURING 2.0L ZETEC ENGINE CYLINDER HEAD REPLACEMENT - SERVICE TIP.

ENGINE VIBRATION AT IDLE.

TRANSAXLE NOISE AT IDLE IN NEUTRAL WITH CLUTCH PEDAL RELEASED PREMATURE CLUTCH.

ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS.

LOSS OF POWER, HESITATION AND/OR MISFIRE AFTER COLD START.

CLUNKING OR RATTLE NOISE IN THE TRANSAXLE, MAINLY AT IDLE IN NEUTRAL, WITH CLUTCH PEDAL RELEASED.

GEAR RATTLE OR GEAR ROLLOVER NOISE FROM THE TRANSAXLE AT IDLE, IN NEUTRAL, WITH THE CLUTCH PEDAL UP (ENGAGED).

MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P2195 AND/OR STALL AT IDLE AFTER A COLD START.

The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs).

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.

UNABLE TO REMOVE IGNITION KEY - SERVICE TIP.

INTERMITTENT NO CRANK CONDITION.

DIAGNOSTIC TROUBLE CODE (DTC) B1310 (POWER DOOR UNLOCK CIRCUIT FAILURE) IN THE GEM MODULE.

AN INTERMITTENT MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0462 (FUEL LEVEL SENSOR A...

RUNS ROUGH AND/OR MALFUNCTION INDICATOR LAMP (MIL) ON CONDITION WITH DIAGNOSTIC TROUBLE CODES (DTCS) P402 AND/OR P0403...

NEUTRAL TOW CAPABILITY - SERVICE KIT REQUIREMENTS.

MIRFIRE DIAGNOSTIC TROUBLE CODES P0316, P0300, P0301, P0302, P0303, OR P0304 - SERVICE TIP.

DTC P0316, P0300, P0301, P0302, P0303 AND/OR P0304 - SERVICE TIP.

NEUTRAL TOW CAPABILITY -- SERVICE KIT REQUIREMENTS.

ERRATIC INSTRUMENT CLUSTER GAUGES AND/OR WARNING INDICATORS - SERVICE TIP.

SAFETY BELT WEB STOP BUTTON SERVICE.

Safety recall 05S27 - Rear door latch corrosion - requests for recall service action - built on or before 01/26/2005

For 2000-2005 Focus vehicles built on or before 1/26/2005 Safety Recall 05S27 has been issued for vehicles that are...

FORD: REAR DOOR LATCHES ARE EXPERIENCING CORROSION IN PAWL PIVOT AREA THAT PREVENT PROPER ENGAGEMENT OF PAWL INTO...

FORD: ON SOME VEHICLES, OPERATING FOR AN EXTENDED TIME IN HIGH CORROSION AREA, A SAFETY RECALL 05S27 WAS ISSUED, WHERE...

DELAYED DISABLING OF THE REAR LIFTGATE EXTERNAL OPENING SWITCH AFTER LOCKING THE DOORS - SERVICE TIPS.

VENT LEAK. *EH

STALL AFTER COLD START IN EXTREME LOW AMBIENT TEMPERATURE.

LOSS OF INTERMITTENT WIPER OR WIPER PARK FUNCTION.

INOPERATIVE SPEED CONTROL SYSTEM.

BELT SQUEAL. *MJ

MANIFOLD OR CATALYTIC CONVERTER HEAT SHIELDS LOOSE/MISSING.

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS.

FORD: DUE TO HIGH CORROSION AREAS, WHERE VEHICLES ARE OPERATED FOR EXTENDED PERIODS, LOWER CONTROL ARM (LCA) CAN...

FRONT WHEEL BEARING REPLACEMENT PROCEDURE.

FRONT END CREAKING, CRUNCHING, GRINDING AND/OR RATTLING NOISE FROM THE FRONT SUSPENSION WHILE DRIVING AT SLOW SPEEDS AND/OR WHILE TURNING.

REAR BRAKE SQUEAL. *TT

BRAKE AND ANTI-LOCK BRAKE SYSTEM LIGHTS ON AFTER HEC (HYBRID ELECTRONIC CLUSTER) REPLACEMENT.

VEHICLES NOT EQUIPPED WITH ANTI-LOCK BRAKE SYSTEM (ABS) MAY HAVE THE RED BRAKE LIGHT AND AMBER ABS LIGHT ON AFTER HYBRID...

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS.

MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P0133, P1131 OR P2195.

NO CRANK ON START CHARGING SYSTEM WARNING INDICATOR ON DRIVEABILITY CONCERNS AND OR MALFUNCTION INDICATOR LAMP ON.

A/C CONDENASTION LEAK.

DIAGONAL WEAR OR CUPPING ON THE REAR TIRES.