2002 Ford Focus TSBs

DPFE SENSOR PULSING OR TICKING NOISE FROM ENGINE COMPARTMENT.

ROUGH IDLE, LOW POWER AND / OR STALL AT IDLE, A MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES...

SOME VEHICLES BUILT 09/2001 THROUGH 11/2001 AND EQUIPPED WITH A 2.0L ZETEC ENGINE MAY EXHIBIT A FEAD BELT NOISE.

SOME VEHICLES MAY EXHIBIT A CRANK / NO START, POOR IDLE, AND / OR LACK OF POWER, WITH CAMSHAFTS OUT OF TIME.

SOME VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSAXLE AND 2.0L ZETEC ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LAMP...

SOME VEHICLES EQUIPPED WITH THE 2.0L SPI ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND...

SOME 2001 VEHICLES EQUIPPED WITH A 2.0L SPI ENGINE MAY EXHIBIT A PULSING OR TICKING NOISE ORIGINATING FROM THE ENGINE...

SOME VEHICLES MAY EXHIBIT ENGINE VIBRATION AT IDLE IN DRIVE, NEUTRAL AND REVERSE.

ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE.

SOME VEHICLES MAY EXHIBIT AN ENGINE VIBRATION AT IDLE, MOST NOTICEABLE WHEN ENGAGED IN REVERSE.

INFORMATION REGARDING NO START DUE TO A SEIZED CAMSHAFT.

SOME VEHICLES MAY EXHIBIT AN ENGINE VIBRATION AT IDLE, MOST NOTICEABLE WHEN ENGAGED IN REVERSE.

SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA.

SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174.

REPLACE TIMING BELT IDLER PULLEY DURING 2.0L ZETEC ENGINE CYLINDER HEAD REPLACEMENT - SERVICE TIP.

ENGINE VIBRATION AT IDLE.

TRANSAXLE NOISE AT IDLE IN NEUTRAL WITH CLUTCH PEDAL RELEASED PREMATURE CLUTCH.

TRIM-IGNITION LOCK CYLINDER DIFFICULT TO TURN, UNABLE TO REMOVE STICKING IGNITION KEY-IGNITION LOCK CYLINDER REMOVAL PROCEDURE.

LOSS OF POWER, HESITATION AND/OR MISFIRE AFTER COLD START.

SPI ENGINE - OIL LEAK - CONTRACT REQUEST.

CLUNKING OR RATTLE NOISE IN THE TRANSAXLE, MAINLY AT IDLE IN NEUTRAL, WITH CLUTCH PEDAL RELEASED.

GEAR RATTLE OR GEAR ROLLOVER NOISE FROM THE TRANSAXLE AT IDLE, IN NEUTRAL, WITH THE CLUTCH PEDAL UP (ENGAGED).

WATER IN CLIMATE CONTROL HEATER BLOWER MOTOR CASE, WHICH CAN BE ASSOCIATED WITH AN INOPERABLE HEATER BLOWER MOTOR...

INABILITY TO SHIFT GEARS DUE TO LOOSE SHIFT CABLES.

HIGHER THAN NORMAL IDLE SPEED, RUNS ROUGH AT IDLE AND/OR DIAGNOSTIC TROUBLE CODE (DTC) P0171.

CHECK ENGINE LIGHT ON AND DIAGNOSTIC TROUBLE CODE P0460 (FUEL LEVEL SENSOR CIRCUIT MALFUNCTION) - SERVICE TIPS.

COOLANT LEAK FROM A CRACKED COOLANT DEGAS BOTTLE.

ELECTRICAL - HORN INOPERATIVE - VEHICLES EQUIPPED WITH 2.0L ENGINE ONLY.

NOISE FROM THE RIGHT HALFSHAFT SUPPORT BEARING.

ROUGH IDLE, ROLLING IDLE, STALL, HIGH IDLE, OR BACK FIRE MAINLY AFTER A COLD START.

SOME VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODE B1213, B1342, B1601, B2431.

INFORMATION PERTAINING TO VEHICLE PULL OR DRIFT TO THE LEFT OR RIGHT WHILE TRAVELING.

SUBJECT REGARDING NORTH AMERICAN FOCUS NOT EQUIPPED WITH ACTIVE ANTI-THEFT ALARM SYSTEM.

INFORMATION REGARDING DIAGNOSTIC TROUBLE CODE B2496 (PANIC FEATURE DOES NOT OPERATE CORRECTLY).

VENT LEAK. *EH

DISCOLORATION OF THE YELLOW-COLORED, EXTENDED-LIFE, FACTORY-FILL COOLANT.

LOSS OF INTERMITTENT WIPER OR WIPER PARK FUNCTION.

INOPERATIVE SPEED CONTROL SYSTEM.

HIGH DECKLID CLOSING EFFORT.

BELT SQUEAL. *MJ

NOISE FROM RIGHT HALFSHAFT SUPPORT BEARING.

INTERMEDIATE AXLE SHAFT BEARING REPLACEMENT.

DIAGNOSTIC TROUBLE CODES (DTC) P0402 AND/OR P0403 OR RUNS ROUGH IN WET WEATHER CONDITIONS.

INTERMITTENT WIPERS INOPERATIVE.

FRONT END CREAKING, CRUNCHING NOISE AT LOW SPEEDS WHILE TURNING.

LOSS OF INTERMITTENT WIPER OR WIPER PARK FUNCTIONS.

INOPERATIVE HORN CONDITION.

INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS.

A HALFSHAFT BEARING NOISE (WHINE / MOAN, WHISTLING, HUMMING, DRUMMING OR RATTLING) FROM THE DRIVETRAIN WHICH APPEARS TO...

DIFFICULT OR UNABLE TO SHIFT INTO 5TH GEAR.

HARSH TRANSMISSION ENGAGEMENT AND OR DTC P0705.

HARSH TRANSMISSION ENGAGEMENT AND OR DTC P0705.

DIFFICULTY CHANGING GEARS - UNABLE TO ENGAGE GEARS.

GRINDING WHEN SHIFTING INTO THIRD GEAR.

NOISE (WHINE/MOAN, WHISTLING, HUMMING, DRUMMING OR RATTLING) FROM THE DRIVETRAIN WHICH APPEARS TO BE EMANATING FROM THE TRANSMISSION.

2ND OR 4TH GEAR MISSED WHEN SHIFTING AND/OR INTERMITTENT NEUTRALING WHEN SHIFTING INTO 4TH GEAR.

3-4 SHIFT FLARE/NEUTRAL - SERVICE TIP.

2ND OR 4TH GEAR MISSED WHEN SHIFTING AND/OR INTERMITTENT NEUTRALING WHEN SHIFTING INTO 4TH GEAR.

CLUNKING FOR RATTLING NOISE IN THE TRANSMISSION.

HARSH TRANSMISSION ENGAGEMENT WITH POSSIBLE MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODE (DTC) P0705 (TR CIRCUIT FAILURE).

PREMATURE CLUTCH WEAR.

HARSH TRANSMISSION ENGAGEMENT WITH POSSIBLE MALFUNCTION INDICATOR LAMP (MIL) AND DIAGNOSTIC TROUBLE CODE (DTC) P0705 (TR CIRCUIT FAILURE).

NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS.

SOME VEHICLES MAY EXHIBIT DOOR LOCKS THAT MAY INADVERTENTLY LOCK ON THEIR OWN.

SUBJECT REGARDING INTERIOR DOOR LOCK STRATEGY.

SOME VEHICLES MAY EXHIBIT AN INTERMITTENT SELF-ACTIVATION OF THE POWER DOOR LOCKS.

SOME VEHICLES MAY EXHIBIT A VERTICAL CRACK IN THE OUTSIDE MIRROR GLASS WITH NO VISIBLE SIGNS OF IMPACT, ESPECIALLY DURING COLD AMBIENT TEMPERATURES.

SUBJECT ON DRIVER OR PASSENGER FRONT DOOR DIFFICULT TO CLOSE, AND /OR SOME SQUEAK/RATTLE FROM THE HINGE AREA.

SOME VEHICLES EQUIPPED WITH A FACTORY POWER ROOF OPENING PANEL MAY EXHIBIT AN INOPERATIVE OR INCOMPLETE TRAVEL OF THE ROOF PANEL.

SOME VEHICLES MAY EXHIBIT AN EXTERIOR MIRROR THAT IS LOOSE OR SHAKES WHEN DRIVING.

SUBJECT REGARDING REAR LIFTGATE SPOILER REMOVAL AND INSTALLATION.*JB

Safety recall 05S27 - Rear door latch corrosion - requests for recall service action - built on or before 01/26/2005

For 2000-2005 Focus vehicles built on or before 1/26/2005 Safety Recall 05S27 has been issued for vehicles that are...

FORD: REAR DOOR LATCHES ARE EXPERIENCING CORROSION IN PAWL PIVOT AREA THAT PREVENT PROPER ENGAGEMENT OF PAWL INTO...

FORD: ON SOME VEHICLES, OPERATING FOR AN EXTENDED TIME IN HIGH CORROSION AREA, A SAFETY RECALL 05S27 WAS ISSUED, WHERE...

DIFFICULT TO OPEN OR UNABLE TO OPEN HOOD CONDITION.

HOOD RELEASE CABLE BREAKING/BINDING IN COLD WEATHER.

SQUEAK AND RATTLE CONDITION FROM THE INSTRUMENT PANEL.

INFORMATION ON VEHICLES WITH PROGRAMMABLE MODULES.

INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES.

SOME VEHICLES MAY EXHIBIT A DIFFICULT TO TURN, UNABLE TO REMOVE, OR STICKING IGNITION KEY.

SOME VEHICLES BUILT AFTER 10/01/2001 MAY EXHIBIT A DIFFICULT TO TURN IGNITION KEY.

SERVICE WIRING HARNESS REPLACEMENT GUIDELINES - SERVICE TIPS.

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.

UNABLE TO REMOVE IGNITION KEY - SERVICE TIP.

FUEL DELIVERY MODULE (FDM) REPLACEMENT PROCEDURE.

UNABLE TO COMMUNICATE WITH/REPROGRAM POWERTRAIN CONTROL MODULE (PCM).

MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0133 (02 SENSOR SLOW RESPONSE).

RUNS ROUGH AND/OR MALFUNCTION INDICATOR LAMP (MIL) ON CONDITION WITH DIAGNOSTIC TROUBLE CODES (DTCS) P402 AND/OR P0403...

CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4.

HARD START, NO START, BATTERY LAMP FLICKER.

AIRBAG LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) B1932 (AIR BAG DRIVER CIRCUIT OPEN) OR B2232 (AIR BAG DRIVER CIRCUIT OPEN - LOOP #2).

INOPERATIVE OR INACURRATE SPEEDOMETER, 4X4 LAMP ILLUMINATD, AND / OR DIAGNOSTIC TROUBLE CODE P1635 OR P1639.

CONCERNS WITH HEADLAMP MOISTURE/CONDENSATION IN LENS ASSEMBLY.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS.

MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P0133, P1131 OR P2195.

NO CRANK ON START CHARGING SYSTEM WARNING INDICATOR ON DRIVEABILITY CONCERNS AND OR MALFUNCTION INDICATOR LAMP ON.

TURN SIGNAL CANCEL CONCERN.

AUTOMATIC TURN SIGNAL CANCELLATION INOPERATIVE.

CONDENSATION AND/OR WATER ACCUMULATION WITHIN THE FOG LAMP ASSEMBLY.

MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES P1381/P0011 AND/OR P1383/P0012 STORED IN MEMORY.

MANIFOLD OR CATALYTIC CONVERTER HEAT SHIELDS LOOSE/MISSING.

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS.

STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES...

STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK...

STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES...

MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC...

SOME VEHICLES EQUIPPED WITH 15 INCH FIRESTONE TIRES MAY EXHIBIT SIGNS OF DIAGNONAL WEAR OR CUPPING ON THE REAR TIRES.

SOME VEHICLES EQUIPPED WITH 15 INCH FIRESTONE TIRES MAY EXHIBIT SIGNS OF DIAGONAL WEAR OR CUPPING OF THE REAR TIRES.

SOME VEHICLES WITH 15 INCH FIRESTONE TIRES MAY EXHIBIT SIGNS OF DIAGONAL WEAR OR CUPPING ON THE REAR TIRES.

INFORMATION ON NORTH AMERICAN BUILT VEHICLES WHICH WERE NOT EQUIPPED WITH A PERIMETER / ACTIVE ANTI-THEFT ALARM SYSTEM.

THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT).

DIAGONAL WEAR OR CUPPING ON THE REAR TIRES.

REAR TIRE INNER EDGE WEAR.

SOME SVT BUILT PRIOR TO 3/27/2002 ARE EQUIPPED WITH FRONT SEAT BACK TRIM COVER AND FOAM PAD SEAT BACK WITH VELCRO TO...

ABS/ADVANCE TRAC LIGHT ON AND DIAGNOSTIC TROUBLE CODE C1937 OR THE STABILITY ASSIST SYSTEM ACTIVE/FAIL LAMP FLASHING.

REAR BRAKE SQUEAL. *TT

BRAKE AND ANTI-LOCK BRAKE SYSTEM LIGHTS ON AFTER HEC (HYBRID ELECTRONIC CLUSTER) REPLACEMENT.

VEHICLES NOT EQUIPPED WITH ANTI-LOCK BRAKE SYSTEM (ABS) MAY HAVE THE RED BRAKE LIGHT AND AMBER ABS LIGHT ON AFTER HYBRID...

EXCESSIVE FRONT BRAKE PAD WEAR, FRONT BRAKE CREEP/GROAN NOISE, FRONT BRAKE DUST AND/OR ROTOR WEAR.

EXCESSIVE FRONT BRAKE PAD WEAR, FRONT BRAKE CREEP/GROAN NOISE, FRONT BRAKE DUST, AND/OR ROTOR WEAR CONCERN.

CONCERNS WITH FRONT SUSPENSION CREAK, CRUNCH NOISE WHILE TURNING AT SLOW SPEEDS.

FORD: DUE TO HIGH CORROSION AREAS, WHERE VEHICLES ARE OPERATED FOR EXTENDED PERIODS, LOWER CONTROL ARM (LCA) CAN...

REAR SHOCK NOISE FROM THE REAR OF THE VEHICLE OVER BUMPS.

FRONT END CREAKING, CRUNCHING, GRINDING AND/OR RATTLING NOISE FROM THE FRONT SUSPENSION WHILE DRIVING AT SLOW SPEEDS AND/OR WHILE TURNING.

FRONT END CREAKING, CRUNCHING, GRINDING AND OR RATTLING NOISE FROM THE FRONT SUSPENSION WHILE DRIVING AT SLOW SPEEDS AND/OR WHILE TURNING.

LIGHT RATTLING/CHUCKING NOISE FROM THE REAR SUSPENSION WHILE DRIVING OVER SMALL REPETITIVE BUMPS (WASHBOARD) AT SPEEDS LESS THAN 30 MPH.

SUBJECT REGARDING AIR CONDITIONER ADD ON KITS NOT AVAILABLE.

SOME WAGONS MAY EXHIBIT THE LIFTGATE NOT STAYING IN THE FULLY UPRIGHT POSITION IN COLD CLIMATES.

SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS.

A/C CONDENASTION LEAK.

CLIMATE CONTROL A/C SERVICE TECH TIPS.

SOME VEHICLES MAY EXHIBIT A LOCKED REAR SEAT BELT RETRACTOR AFTER MOVING THE REAR SEAT FROM THE FOLD DOWN POSITION TO THE SEATING POSITION.

AIR BAG LIGHT IN WITH ALL OR ANY COMBINATION OF DTC B1881 B2434 B2438 AND OR C1947.

AIRBAG LAMP ILLUMINATED CONDITION WITH DIAGNOSTIC TROUBLE CODES (DTCS) B1881, B2434, B2438, AND C1947.

ERRATIC INSTRUMENT CLUSTER GAUGES AND/OR WARNING INDICATORS - SERVICE TIP.

SAFETY BELT WEB STOP BUTTON SERVICE.

REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS.

SOME VEHICLES EQUIPPED WITH AN IN-DASH 6 DISC RADIO MAY EXHIBIT A SYSTEM CD ERROR E3 OR A STUCK DISC.

STABILITY ASSIST (ADVANCETRAC/IVD) SYSTEMS MAY NOT BE RECALIBRATED PROPERLY USING WDS.