2002 Ford F-150 TSBs

WHITE FLAKES COMING FROM THE AIR CONDITIONER VENTS WHEN THE BLOWER MOTOR IS ENGAGED.

SOME VEHICLES EQUIPPED WITH 4.2L, 4.6L AND 5.4L ENGINE MAY EXHIBIT A LACK OF POWER CONDITION.

SOME VEHICLES EQUIPPED WITH 5.4L V8 ENGINE MAY EXHIBIT AIR INDUCTION SYSTEM CONDITIONS AS WELL AS ENGINE HESITATION /...

SOME VEHICLES EQUIPPED WITH BI-FUEL (CNG/LPG) ALTERNATE FUEL ENGINES MAY EXHIBIT HARD / NO START, RUNS ROUGH OR MISSES...

SOME VEHICLES MAY EXHIBIT AN ILLUMINATED MALFUNCTION INDICATOR LAMP ALONG WITH DIAGNOSTIC TROUBLE CODE P0316 (MISFIRE...

SOME LIGHTNING AND HARLEY DAVIDSON SUPERCREWS MAY EXHIBIT CHECK ENGINE LIGHT ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0171 OR P0174.

SOME VEHICLES EQUIPPED WITH A 4.6/5.4L ENGINE MAY EXHIBIT AN ILLUMINATED MALFUNCTION INDICATOR LAMP ALONG WITH DIAGNOSTIC TROUBLE CODE P0316 STORED.

SOME VEHICLES EQUIPPED WITH THE 5.4L 2V ENGINE MAY EXHIBIT A WHISTLING NOISE FROMTHE FORMED NYLON TUBE INTHE IDLE-AIR BYPASS FLOW CIRCUIT.

SOME BI-FUEL LPG VEHICLES MAY EXHIBIT A NO START, ROLLING IDLE, SURGING IDLE AND / OR SURGE AT CRUISE CONDITION IN LPG...

SUBJECT REGARDING IDLER ARM REPLACEMENT SPECIFICATIONS.

ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE.

SOME VEHICLES MAY EXHIBIT A HIGHER THAN NORMAL BASE IDLE SPEED WHEN INITIALLY RECEIVED FROM THE ASSEMBLY PLANT.

SOME VEHICLES EQUIPPED WITH A 4.6L ENGINE AND AUTOMATIC TRANSMISSION MAY EXHIBIT A HIGHER THAN NORMAL IDLE CONDITION, HOT OR COLD.

SOME VEHICLES MAY EXHIBIT A HIGHER THAN NORMAL BASE IDLE SPEED WHEN THE VEHICLE IS INITIALLY RECEIVED FROM THE ASSEMBLY PLANT.

SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA.

SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174.

SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY...

A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTER...

1999-2008 7.3L/6.0L/6.4L/4.5L DIESEL F-SUPER DUTY - CLEAN THE CHARGE AIR COOLER (CAC) SYSTEM AFTER CERTAIN TURBO OR ENGINE FAILURES - SERVICE TIP.

SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT...

WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING.

MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P1131 AND/OR P1151 - 4.2L ENGINE.

USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE.

INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW.

ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS.

DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT...

COOLING SYSTEM-MOTORCRAFT PREMIUM GOLD ENGINE COOLANT-SERIVCE TIPS.

ROLLING IDLE/POOR FUEL ECONOMY.

ENGINE-CYLINDER HEAD DECK LEAK-4.6 AND 5.4L ENGINES-NEW SERVICE-ONLY GASKET AND CYLINDER HEAD KITS AVAILABILITY.

ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION.

ENGINE-ROMEO BUILT 4.6L 2V-TICK NOISE FROM ENGINE-ENGINES BUILT BEFORE 9/17/2003.

STEERING IDLER ARM NOISE.

BROKEN EXHAUST MANIFOLD STUDS.

ROUGH IDLE AND/OR MISFIRE WITH DIAGNOSTIC TROUBLE CODE P0316 AFTER AN OVERNIGHT SOAK IN EXTREME COLD AND HIGH HUMIDITY CONDITIONS.

A VIBRATION AND/OR RATTLE CONDITION WHEN THE ENGINE IS AT IDLE IN GEAR OR WHEN ACCELERATING FROM A SLOW SPEED 32 KM/H (20 MPH).

SOME DEDICATED CNG VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS DUE TO A LOSS OF INJECTOR PERFORMANCE, RESULTING FROM FUEL QUALITY.

TICKING/TAPPING NOISE WITH THE ENGINE WARMED UP AND THE TRANSMISSION IN GEAR AT IDLE.

DEDICATED COMPRESSED NATURAL GAS (CNG) ROUGH IDLE OR NO START WHEN COLD VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY.

ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED...

NOISE FROM THE FRONT END OF THE VEHICLE WHICH APPEARS TO BE COMING FROM THE STEERING IDLER ARM.

SOME VEHICLES, EQUIPPED WITH THE 4.6L 2V ENGINE, WITH AN ENGINE BUILD DATE PRIOR TO 8/29/03 MAY EXHIBIT AN ENGINE TICK...

VIBRATION AND/OR RATTLE CONDITION WHEN THE ENGINE IS AT IDLE IN GEAR OR WHEN ACCELERATING FROM A SLOW SPEED (20 MPH, 32 KM/H).

COMPRESSED NATURAL GAS (CNG).

ROLLING IDLE AFTER SHIFTING TO PARK OR NEUTRAL, FROM DRIVE OR REVERSE, WHEN THE ENGINE TEMPERATURE IS 100 - 140 DEGREES F.

ON SOME DEDICATED CNG VEHICLES, A POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE.

POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE, ON SOME DEDICATED CNG VEHICLES.

INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER,...

INFORMATION ON VEHICLE EXHIBITING EVIDENCE OF OIL IN THE AIR INTAKE SYSTEM.

SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS.

EXHIBITING LACK OF POWER CONDITION WHEN VEHICLE IS OPERATED IN AMBIENT TEMPERATURES.

CONCERNS WITH THE LOWER POWER IN HIGH AMBIENT TEMEPRATURES.

DEDICATED CNG REGULATOR BOWL KIT AVAILABLE.

CONCERNS WITH DIAGNOSTIC TROUBLE CODES P1516, P1518, P1519, AND P1520.

This SKU is an Oil Dipstick.

REAR AXLE NOISE REPAIR.

REAR AXLE NOISE REPAIR.

AXLE WHINE HOWL. THIS INCLUDES 1997-05 FORD VEHICLES.

A DRIVELINE CLUNK OR BUMP WHEN STARTING FROM A STOP.

SAFETY BELT RETRACTION SPEED.

MULTIPLE VEHICLES USING FEHP REAR AXLE FLUID.

HERITAGE F-150 4X2 WITH 8.8 INCH REAR AXLE - WHINE/HOWL NOISE FROM REAR AXLE.

AXLE WHINE 40-60 MPH.

EVIDENCE OF OIL IN THE AIR INTAKE SYSTEM.

WHINE/HOWL FROM REAR AXLE 40 TO 60 MPH.

WHINE / HOWL FROM REAR AXLE.

VEHICLES WITHOUT THE COOLANT LOCK-OFF MAY EXHIBIT A NO START CONDITION.

THROTTLE CONTROL SPLASH SHIELD INSTALLATION REQUIREMENTS.

SOME BI-FUEL CNG VEHICLES MAY EXHIBIT A CRANK NO START CONDITION WHILE OPERATING IN ALTERNATE FUEL MODE WITH THE ALT FUEL LIGHT ON.

INFORMATION ON VEHICLES EXHIBITING A PERCEIVED POOR FUEL RANGE / ECONOMY, AND OR A FAULTY FUEL GAUGE.

SOME BI-FUEL CANG AND LPG VEHICLES MAY EXHIBIT A NO START CONDITION.

SOME BI-FUEL CNG VEHICLES MAY EXHIBIT A CRANK NO START CONDITION WHILE OPERATING IN ALTERNATE FUEL MODE, WITH THE ALT FUEL LIGHT ON.

SUBJECT REGARDING ALTERNATIVE FUEL VEHICLE COMPRESSED NATURAL GAS TANK INSPECTION.

Safety recall 11S21 - Fuel tank strap fracture - requests for recall service action

For 1997-2003 F-150, 2004 F-150 Heritage, 1997-1999 F-250 Light Duty, or 2002-2003 Blackwood vehicles Safety Recall...

FORD/LINCOLN: SAFETY RECALL REGARDING HIGH CORROSION AREAS FOR OPERATING, FOR AN EXTENDED TIME, VEHICLES WHERE BOTH OR...

FORD/LINCOLN: SAFETY RECALL ISSUED DUE TO ONE OR BOTH FUEL TANK STRAPS FRACTURING DUE TO BEING IN HIGH CORROSION AREAS...

HEAVY STATIC OR SIGNAL LOSS ON TWO WAY RADIO COMMUNICATION .

MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP.

STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES...

FUEL SIGNAL TO INSTRUMENT CLUSTER SERVICE TIP.

STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK...

STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES...

MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC...

SOME VEHICLES MAY EXHIBIT AN INTERMITTENT SOFT CLUTCH PEDAL WHICH MAY CAUSE DIFFICULTY IN SHIFTING GEARS (A NOTCHY FEEL).

SOME VEHICLES EQUIPPED WITH A 5-SPEED MAZDA R2 MANUAL TRANSMISSION MAY EXHIBIT A HIGH EFFORT CONDITION WHEN SHIFTING ANY GEAR.

SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES P0740,...

SOME VEHICLES WITH ELECTRONIC SHIFT-ON-THE FLY MAY EXHIBIT AN INADVERTENT 4X4 LOW ENGAGEMENT WHILE DRIVING.

SOME VEHICLES EQUIPPED WITH A 4R100 TRANSMISSION AND BUILT BETWEEN JANUARY 1, 2001 AND MAY 1, 2002 MAY EXHIBIT FLASHING...

CONCERNS WITH POP/CLUNK/CLICK NOISE FROM THE FRONT SUSPENSION WHEN MAKING LOW-SPEED TURNS IN FORWARD OR REVERSE GEARS.

BRAKE SHIFT INTERLOCK.*JB

INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS.

INTERMITTENT CLUNK ON 3-2 DOWNSHIFT DURING COASTDOWN/TIP-IN.

NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS.

ALUMINUM CORROSION - SERVICE TIP.

POP/THUMP NOISE AT END OF WINDOW MOVEMENT AND/OR DRIVER'S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION.

REAR AXLE SEAL LEAK - CONTACT REQUEST.

WINDNOISE AND/OR A WATER LEAK FROM THE SLIDING BACK GLASS AREA.

TAILGATE LOCKING BY ITSELF WHEN SLAMMED SHUT OR WHEN THE VEHICLE IS BEING DRIVEN OVER ROUGH ROADS.

LOCKING TAILGATE LOCKS ITSELF.

DRIVER'S SIDE DOOR GLASS THAT BINDS WHEN OPERATED.

CUSTOMER MAINTENANCE REMINDER - LITERATURE PROGRAM 04L19 - TIE ROD INSPECTION PROCEDURE.

POWER STEERING LEAK - SERVICE TIP.

WHINE FROM POWER STEERING.

TIE ROD END INSPECTION PROCEDURE.

TIE ROD END INSPECTION PROCEDURE.

REDUCED POWER STEERING ASSIST AND/OR POWER STEERING LEAKS WHEN DRIVEN IN TEMPERATURES EQUAL TO OR LESS THAN -25 DEGREES CELCIUS.

TIE ROD END INSPECTION PROCEDURE.

SOME SUPER CREW VEHICLES MAY EXHIBIT LOOSE, POOR FITTING, OR WRINKLED SEAT COVER UPHOLSTERY.

SNOW PACKING OF THE AIR FILTER WHEN DRIVING IN SEVERE SNOW CONDITIONS MAY EXHIBIT LOSS OF POWER AND / OR THE MALFUNCTION INDICATOR LAMP ILLUMINATING.

INOPERATIVE OR INACURRATE SPEEDOMETER, 4X4 LAMP ILLUMINATD, AND / OR DIAGNOSTIC TROUBLE CODE P1635 OR P1639.

DAMAGED REAR LICENSE PLATE LAMPS DUE TO ROCKS AND/OR GRAVEL HITTING THE LAMP ASSEMBLIES.

MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES (DTC) P0171, OR P0174.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH NO HARD FAULT.

INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES.

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.

GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES.

SPLICING NEW WIRE(S) INTO EXISTING ELECTRICAL HARNESS.

SERVICING MULTIFUNCTION SWITCH WIRING INTERFERENCE.

VARIOUS INTERMITTENT ELECTRICAL CONCERNS INCLUDING BUT NOT LIMITED TO SOME ACCESSORIES REMAINING POWERED UP WITH THE KEY...

INFORMATION REGARDING IMRC SET SCREW WARRANTY REPAIR.*JB

SOME SUPERCREWS ARE EQUIPPED WITH A DIGITAL MEMO RECORDER MOUNTED ON THE DRIVER'S SIDE SUN VISOR WHICH ALLOWS MEMOS TO...

BED EXTENDER COMPONENT REPLACEMENT SERVICE TIP.

SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS.

NO/HARD START IN COLD AMBIENTS / NEW TWO-PIECE BLOCK HEATER CORD RELEASED.

AIR CONDITIONER CONDENSATE LEAK ON PASSENGER FLOOR.

SOME VEHICLES WITH 4-WHEEL DISC BRAKES MAY EXHIBIT A MOAN FROM THE REAR BRAKES ON LIGHT BRAKE APPLICATIONS.

DRIVELINE CLUNKING/GRUNTING NOISE OR SHUDDER SENSATION DURING LIGHT TO MODERATE ACCELREATION AND/OR BRAKING.

THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT).

CORRECT LUG NUT TORQUE SPECIFICATIONS - INCREASE WHEEL NUT AND STUD SIZE - SERVICE TIP.

GUIDANCE FOR CNG TANK INSPECTION FOR VEHICLES PRODUCED AFTER DECEMBER 2, 1996.

INFORMATION ON REMOVING STICKER FROM SEAT BELT.

REAR LEAF SPRING NOISE.

CD OR CD6 RADIO OVERHEATING.