1999 Ford F-150 TSBs

SOME VEHICLES EQUIPPED WITH 5.4L V8 ENGINE MAY EXHIBIT AIR INDUCTION SYSTEM CONDITIONS AS WELL AS ENGINE HESITATION /...

SOME VEHICLES EQUIPPED WITH BI-FUEL (CNG/LPG) ALTERNATE FUEL ENGINES MAY EXHIBIT HARD / NO START, RUNS ROUGH OR MISSES...

SOME LIGHTNING AND HARLEY DAVIDSON SUPERCREWS MAY EXHIBIT CHECK ENGINE LIGHT ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0171 OR P0174.

SOME VEHICLES EQUIPPED WITH THE 5.4L 2V ENGINE MAY EXHIBIT A WHISTLING NOISE FROMTHE FORMED NYLON TUBE INTHE IDLE-AIR BYPASS FLOW CIRCUIT.

ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE.

SOME COMPRESSED NATURAL GAS (CNG) VEHICLES MAY EXHIBIT ROUGH IDLE OR NO START WHEN COLD.

SOME DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES MAY EXHIBIT A ROUGH IDLE, OR NO START IN COLD CONDITIONS.

SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA.

SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174.

SOME VEHICLES MAY EXHIBIT HIGH IDLE AND/OR PCV SYSTEM ICING AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT...

SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY...

A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTE...

SOME VEHICLES EQUIPPED WITH THE ROMEO BUILT 4.6L 2V ENGINE MAY EXHIBIT AN ENGINE OIL LEAK OR OIL WEEPAGE FROM THE...

INFORMATION TO AID IN DIAGNOSIS FOR CLARIFICATION OF LOCK-OFF SOLENOID AND SOLENOID TANK VALVE COIL RSISTANCES FOR BI-FUEL VEHICLES.

SOME VEHICLES MAY EXHIBIT A FUEL FILL VALVE SEALING CONDITION.

SOME VEHICLES EQUIPPED WITH A 4.6L ENGINE AND M5OD 5 SPEED MANUAL TRANSMISSIONS MAY EXHIBIT HESITATION ON ACCELERATION...

SOME VEHICLES, BI FUEL, MAY EXHIBIT A NO START CONDITION IN BOTH THE GASOLINE MODE AND THE ALT FUEL MODE, VEHICLES...

ON SOME VEHICLES THERE MAY BE AN OIL LEAK FROM THE RIGHT HAND HEAD GASKET AT THE REAR OF THE BLOCK / HEAD JOINT.

SOME VEHICLES EQUIPPED WITH A 4.6L ENGINE A 5 SPEED MANUAL TRANSMISSION MAY EXHIBIT A SLIGHT HESITATION ON LIGHT TIP-IN...

VEHICLES EQUIPPED WITH A 4.6L ENGINE AND 5 SPEED MANUAL TRANSMISSION MAY EXHIBIT A SLIGHT HESITATION ON LIGHT TIP-IN...

A CONDITION MAY EXIST WHERE THE MALFUNCTION INDICATOR LAMP IS ON WITH DIAGNOSTIC TROUBLE CODE P0340 (CAMSHAFT POSITION...

SOME VEHILCES EQUIPPED WITH 4.6L ROMEO ENGINE AND MANUAL TRANSMISSION ONLY, MAY EXHIBIT A CHECK ENGINE LIGHT ON AND...

SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL.

SOME VEHICLES MAY EXHIBIT THE ENGINE OIL SENDING UNIT CONTACTING THE OIL DRIP SHIELD ATTACHED TO THE FRONT AXLE.

THIS BULLETIN ADDRESSES CONCERNS A NOISE AT INTIAL ENGINE STARTUP WHEN COLD FROM THE ACCESSORY DRIVE BELT.

SUBJECT REGARDING HIGH IDLE AND/OR CHECK ENGINE LIGHT CONDITION.

SOME VEHICLES EQUIPPED WITH A 4.6L, 5.4L, OR 6.8L ENGINE MAY EXHIBIT A ROUGH IDLE / MISS AFTER START-UP IN COLD AMBIENT TEMPERATURES.

A CONDITION MAY EXIST WITH POSSIBLE ELECTRONC DAMAGE OCCURING TO THE COMPUVALVE FROM VOLTAGE SPIKES BETWEEN THE...

SOME VEHICLES BUILT WITH THE 4.2L ENGINE THAT ARE OPERATING IN MEXICO MAY EXHIBIT A BACKFIRE CONCERN.

SOME VEHICLES BUILT WITH THE 4.2L ENGINE THAT ARE OPERATING IN MEXICO MAY EXHIBIT A BACKFIRE CONCERN.

SUBJECT REGARDING MISFIRE CODES ON ALL ENGINES.

INFORMATION ON VEHICLES EXHIBITING COLD ENGINE KNOCK.

SOME VEHICLES EQUIPPED WITH 5.4L ENGINES MAY EXHIBIT A COLD START ENGINE KNOCK CONCERN UNTIL WARMED UP.

COLD START ENGINE NOISE

SOME VEHICLES EQUIPPED WITH THE 5.4L ENGINE MAY EXHIBIT DIFFICULTY ENGAGING INTO AND OUT OF 4X4 LOW, WHILE COLD.

SOME VEHICLES EQUIPPED WITH 4.6L OR 6.8L ENGINES MAY EXHIBIT A COLD START ENGINE NOISE UNTIL WARMED UP.

SOME VEHICLES WITH THE 5.4 L ENGINE MAY EXHIBIT DIFFICULTY ENGAGING INTO AND OUT OF 4 X 4 LOW, WHILE COLD.

EXHIBITING A CHECK ENGINE LIGHT ON AND POSSIBLE DIAGNOSTIC TROUBLE CODES P0715, P0716, P0717, P0718, P1901 (TURBINE...

SOME VEHICLES WITH 4.6L, OR 6.8L ENGINES MAY EXHIBIT A ROLLER FINGER FOLLOWER COMING OFF DURING ENGINE CRANKING IN COLD...

SOME VEHICLES EQUIPPED WITH THE 5.4L ENGINE, 4R100 TRANSMISSION AND AN AUXILIARY TRANSMISSION OIL COOLER MAY EXHIBIT A COASTDOWN MOAN CONCERN.

SUBJECT REGARDING DISCONTINUE OF THE ENGINE COMPARTMENT BEAUTY SHIELD.

SOME VEHICLES MAY EXHIBIT A IDLE VIBRATION.

SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT...

INFORMATION REGARDING FRONT COVER & WATER PUMP BOLTS-TORQUE VALVE REVISION/3.8-4.2L.

INFORMATION REGARDING A CHANGE IN THE TORQUE VALUES OF THE ENGINE FRONT COVER WATER PUMP BOLTS.

VEHICLES WITH 4.2L ENGINE (CANADIAN) MAY BACKFIRE ON ACCELERATION AT ALL AMBIENT TEMPERATURE.

VEHICLES BUILT AFTER 7/31/99 WILL NO LONGER BE EQUIPPED WITH A SHIELD COVERING THE STARTER RELAY AND C120 / C172...

VEHICLES EQUIPPED WITH THE 5.4L ENGINE, 4R100 TRANSMISSION AND AN AUXILIARY TRANSMISSION OIL COOLER MAY EXHIBIT A COASTDOWN MOAN CONCERN.

CONCERNS WITH A HARD TO TURN IGNITION KEY AND / OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER.

SOME VEHICLES MAY EXPERIENCE AN IDLE VIBRATION.

SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT...

EXPERIENCING A ENGINE KNOCK AT COLD START-UP.

FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS.

FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR.

SOME VEHICLES EQUIPPED WITH THE 5.4L ENGINE, 4R100 TRANSMISSION AN AUXILIARY TRANSMISSION OIL COOLER MAY EXHIBIT A COASTDOWN MOANING NOISE.

FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS.

1999-2008 7.3L/6.0L/6.4L/4.5L DIESEL F-SUPER DUTY - CLEAN THE CHARGE AIR COOLER (CAC) SYSTEM AFTER CERTAIN TURBO OR ENGINE FAILURES - SERVICE TIP.

SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT...

WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING.

USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE.

INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW.

ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS.

DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT...

ENGINE-CYLINDER HEAD DECK LEAK-4.6 AND 5.4L ENGINES-NEW SERVICE-ONLY GASKET AND CYLINDER HEAD KITS AVAILABILITY.

ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION.

BROKEN EXHAUST MANIFOLD STUDS.

SOME DEDICATED CNG VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS DUE TO A LOSS OF INJECTOR PERFORMANCE, RESULTING FROM FUEL QUALITY.

DEDICATED COMPRESSED NATURAL GAS (CNG) ROUGH IDLE OR NO START WHEN COLD VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY.

ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED...

COMPRESSED NATURAL GAS (CNG).

ON SOME DEDICATED CNG VEHICLES, A POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE.

POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE, ON SOME DEDICATED CNG VEHICLES.

INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER,...

INFORMATION ON VEHICLE EXHIBITING EVIDENCE OF OIL IN THE AIR INTAKE SYSTEM.

SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS.

EXHIBITING LACK OF POWER CONDITION WHEN VEHICLE IS OPERATED IN AMBIENT TEMPERATURES.

CONCERNS WITH THE LOWER POWER IN HIGH AMBIENT TEMEPRATURES.

DEDICATED CNG REGULATOR BOWL KIT AVAILABLE.

SOME VEHICLES MAY EXHIBIT A CONDITION WHERE ALL THE GUAGES INTHE INSTRUMENT CLUSTER WILL SWEEP AT INITIAL START UP.

SOME VEHICLES MAY EXHIBIT A LOSS OF COOLANT FROM THE CHARGE AIR COOLER RESERVOIR.

CONCERNS WITH VEHICLES EXHIBITING THE OIL PRESSURE GAUGE REGISTERING LOW OR NO OIL PRESSURE USUALLY ON INITIAL START-UP...

VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK.

SOME VEHICLES MAY REQUIRE TECHNICAL ASSISTANCE FOR SPEEDOMETER ACCURACY CONCERNS.

SOME VEHICLES MAY REQUIRE TECHNICAL ASSISTANCE FOR SPEEDOMETER ACCURACY CONCERNS.

EFFECTIVE JANUARY 4, 1999 CERTAIN VEHICLES BUILT WITH THROW-IN-MATS WILL BE BUILT WITH THE DELTAR CLIP ATTACHMENT AS A...

SUBJECT REGARDING TECHNICAL ASSISTANCE FOR SPEEDOMETER ACCURACY CONCERNS.

INFORMATION ON THE ALIVE MEMORY (DAM) FEATURE DURING VARIOUS DIAGNOSTIC AND REPAIR PROCEDURES.

EXHIBITING A DELAYED OPERATION / INOPERATIVE INSTRUMENT CLUSTER WITH KOEO OR KOER.

SOME VEHICLES MAY EXHIBIT A DELAYED OPERATION / INOPERATIVE INSTRUMENT CLUSTER WITH KOEO OR KOER.

INFORMATION REGARDING ERRACTIC REMOTE ENTRY FUNCTIONS-NEW GEM RELEASED.

CONCERNS WITH A CHATTERING NOISE FROM THE REAR AXLE HEARD WHEN TURNING OR CORNERNING.

CONCERNS WITH ERRATIC REMOTE ENTRY FUNCTIONS.

SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE.

SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC)...

NNERS OF THE EDSR-OF-THE-MONTH QUALITY AWARD ANNOUNCEMENT FOR SEPTEMBER.

BRIEF INFORMATION REGARDING THE DISCONTINUED TOOL BOX.

SOME 4X4 VEHICLES MAY EXHIBIT A MOAN NOISE FROM THE FRONT DIFFERENTIAL WHEN THE VEHICLE IS OPERATING IN 4X2 MODE AND...

(CONTINUED FROM 13251 AND 13252) UNCOMMANDED FRONT WIPER FUNCTION.

INFORMATION REGARDING THE WINNERS OF THE EDSR OF THE MONTH QUALITY AWARDS FOR THE MONTH OF AUGUST.

SUBJECT REGARDING FRONT WIPERS OPERATING WHILE SWITCH IS IN OFF POSITION.

A CONDITION WITH THE AUTO-LOCK FUNCTIONS NOT OPERATION PROPERLY ON VEHICLES BUILT FROM 6/3/1999 THROUGH 6/8/1999.

SOME VEHICLES MAY EXHIBIT AN INDUCTION BACKFIRE ON ACCELERATIONS AND DECELERATIONS DURING ALL AMBIENT TEMPERATURES.

SOME 4X4 VEHICLES BUILT WITH CENTER DISCONNECT FRONT AXLES MAY EXHIBIT A MOANING NOISE FROM THE FRONT DIFFERENTIAL WHILE OPERATING IN 4X2 MODE.

INFORMATION ON RESETTING THE PASSIVE ANTI-THEFT SYSTEM (PATS).

CONCERNS WITH FRONT DIFFERENTIAL NOISE.

EXPERIENCING FRONT DIFFERENTIAL NOISE.

SOME VEHICLES MAY EXHIBIT ACTIVATION OF FRONT WIPERS WITHOUT COMMAND.

EXPERIENCING FRONT WIPERS ACTIVATION WITHOUT COMMAND.

EXPERIENCING A 4-3 COASTDOWN CLUNK WHEN DECELERATING FROM 48-32 KM/H (30-20 MPH).

INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS.

EXPERIENCING WHISTLING NOISE COMING FROM THE FRONT OF THE VEHICLE AT HIGHWAY SPEEDS.

SUBJECT REGARDING FRONT DIFFERENTIAL NOISE INVESTIGATION.

INFORMATION ON DIAGNOSING PASSIVE ANTI-THEFT SYSTEM (PATS) ISSUES.

This SKU is an Oil Dipstick.

REAR AXLE NOISE REPAIR.

REAR AXLE NOISE REPAIR.

AXLE WHINE HOWL. THIS INCLUDES 1997-05 FORD VEHICLES.

A DRIVELINE CLUNK OR BUMP WHEN STARTING FROM A STOP.

EVIDENCE OF OIL IN THE AIR INTAKE SYSTEM.

VEHICLES WITHOUT THE COOLANT LOCK-OFF MAY EXHIBIT A NO START CONDITION.

SOME VEHICLES EQUIPPED WITH A 5-SPEED MAZDA R2 MANUAL TRANSMISSION MAY EXHIBIT A HIGH EFFORT CONDITION WHEN SHIFTING ANY GEAR.

SOME VEHICLES WITH ELECTRONIC SHIFT-ON-THE FLY MAY EXHIBIT AN INADVERTENT 4X4 LOW ENGAGEMENT WHILE DRIVING.

CONCERNS WITH POP/CLUNK/CLICK NOISE FROM THE FRONT SUSPENSION WHEN MAKING LOW-SPEED TURNS IN FORWARD OR REVERSE GEARS.

BRAKE SHIFT INTERLOCK.*JB

INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS.

SOME VEHICLES MAY EXHIBIT INADVERTENT 4X4 HI OR LOW SHIFT EVENTS, 4X4 AND / OR LOW RANGE INDICATOR FLASHING OR SOLID OR...

SOME VEHICLES EQUIPPED WITH A 4R70W AUTOMATIC TRANSMISSION MAY EXHIBIT A CLUNK NOISE DURING THE 2-1 DOWNSHIFT EVENT.

A CONDITION MAY EXIST WHERE A DRIVELINE VIBRATION AND / OR A TRANSMISSION FLUID LEAK FROM THE EXTENSION HOUSING SEAL AREA MAY OCCUR ON SOME VEHICLES.

SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM.

SOME VEHICLES EQUIPPED WITH M50D R2 MAZDA 5 SPEED MANUAL TRANSMISSION MAY EXHIBIT A GEAR SHIFT RATTLE CONDITION IN THIRD GEAR.

SOME VEHICLES WITH 4R100 TRANSMISSION MAY EXHIBIT A FLASHING TCIL WITH DIAGNOSTIC TROUBLE CODE (DTC) 1728 IN MEMORY.DTC...

ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR...

SOME VEHICLES EQUIPPED WITH A MANUAL TRANSFER CASE MAY EXHBIT AN INOPERATIVE SPEEDOMETER.

SOME VEHICLES EQUIPPED WITH 4R100 TRANSMISSION MAY EXHIBIT A FLASHING TCIL WITH DIAGNOSTIC TROUBLE CODE 1728 IN MEMORY.

INFORMATION REGARDING THE 1999 SCHEDULED MAINTENANCE GUIDE FOR ANY LIGHT TRUCK, SPORT UTILITY OR VAN EQUIPPED WITH A...

SOME VEHICLES WITH 4R70W TRANSMISSIONS BUILT FROM 4/16/98 THROUGH 10/30/98 MAY EXHIBIT A LEAK FROM THE VENT AREA OF THE TRANSMISSION.

SOME VEHICLES EQUIPPED WITH 4R100 TRANSMISSION MAY EXHIBIT A FLASHING TCIL WITH DIAGNOSTIC TROUBLE CODE DTC 1728 IN MEMORY.

VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN...

INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP.

SOME VEHICLES WITH 139 INCH WHEELBASE, 4R70W EQUIPPED TRUCKS MAY EXHIBIT A VIBRATION AND TRANSMISSION FLUID LEAK OR...

SOME VEHICLES MAY EXHIBIT A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE FROM SUSTAINED HIGH SPEED OPERATION.

SOME VEHICLES MAY EXHIBIT A VIBRATION AND TRANSMISSION FLUID LEAK OR BUSHING SPIN AND / OR WALK-OUT DURING SUSTAINED HIGH SPEED OPERATION.

INFORMATION REGARDING STEERING GEAR LEAKS FROM INPUT SHAFT SEALS.

INFORMATION REGARDING TRANSMISSION TROUBLE CODES.

SONE POLICE VEHICLES AND OTHER VEHICLES WITH 4R70W MAY EXHIBIT A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING...

INFORMATION REGARDING STEERING GEAR LEAKS FROM INPUT SHAFT SEALS.

ON 4X2 VEHICLES WITH 4R70W AND 139 INCH WHEELBASE, A VIBRATION FROM TRANSMISSION AND / OR A TRANSMISSION FLUID LEAK FROM...

SUBJECT REGARDING INTERMITTENT TRANSMISSION CONTROL INDICATOR LAMP OR MALFUNCTION INDICATOR LAMP ILLUMINATION.

SOME VEHICLES MAY EXHIBIT AN INTERMITTENT TRANSMISSION CONTROL INDICATOR LAMP OR MALFUNCTION INDICATOR LAMP ILLUMINATION.

VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT,...

THE 4R100 TRANSMISSION WILL HAVE AN ORANGE "PRIOR TO REPAIR" TAG ON THE FLUID PAN.

EXPERIENCING A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE.

CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR.

CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK.

CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR.

NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS.

SOME VEHICLES MAY EXPERIENCE A COSMETIC CRACK IN THE OUTER DOOR PANEL AT THE LOWER REAR CORNER OF WINDOW OPENING.*JB

SOME VEHICLES MAY EXHIBIT A LOOSE/DETACHED REAR WINDOW HALO GIMP MOLDING.

SOME VEHICLES EQUIPPED WITH REMOTE LOCKING TAILGATES MAY EXHIBIT A TAILGATE LOCKING ITSELF WHEN THE VEHICLE IS BEING...

CONCERNS THAT SOME TRUCKS MAY EXHIBIT A LOOSE / DETACHED REAR WINDOW HALO TRIM GIMP MOULDING.

CONCERNS WITH THE SIGNAL MIRROR REFLECTIVE SURFACE DETERIORATING OVER TIME, DEVELOPING DARK SPOTS DUE TO CHROME PLATING DELAMINATION.

SOME VEHICLES MAY EXHIBIT A WATER LEAK AROUND THE REAR (SLIDING) WINDOW.

INFORMATION ON DIAGNOSTICING ERRATIC WINDSHIELD WIPER OPERATION.

CONCERNS WITH VEHICLES EXHIBITING A WINDSHIELD CREAK / SQUEAK.

SOME VEHICLES MAY EXHIBIT INTERIOR LIGHTS, POWER WINDOWS AND / OR INOPERATIVE RUNNING BOARD LIGHTS FOR A SHORT PERIOD OF TIME IN THE MORNING.

CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING.

VEHICLES MAY EXPERIENCE INNER FENDER WELL- DENTED OR DINGED FROM STONES BEING THROWN INTO WHEELWELL.

SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING.

SUBJECT REGARDING A LOOSE / DETACHED GIMP MOULDING AT THE REAR WINDOW.

ON SOME VEHICLES THE FRONT BUMPERS MAY EXHIBIT RED STAINING (SPOTS) ON THE BUMER WING ENDS.

EXPERIENCING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA.

INFORMATION REGARDING VEHICLES THAT EXHIBIT CRACKS IN THE DOOR SHEET METAL.

VEHICLES MAY EXHIBIT AN OUTSIDE PASSENGER OR DRIVER SIDE MIRROR SLIGHT FLUTTER / SHAKE AT HIGHWAY SPEEDS.

SOME TRUCKS MAY EXHIBIT A LOOSE / DETACHED GIMP MOULDING AT THE REAR WINDOW.

ON SOME VEHICLES, THE FRONT WINDSHIELD WIPERS MAY OPERATE WHILE THE MULTIFUNCTION SWITCH IS IN THE OFF POSITION.

INFORMATION PERTAINING TO CONDITIONS WITH RED STAINING (SPOTS) ON THE FRONT BUMPER WING ENDS.

CONCERNS WITH OUTSIDE PASSENGER OR DRIVER SIDE MIRROR SLIGHTLY FULTTERING / SHAKING AT HIGHWAY SPEEDS.

THIS ONLINE SERVICE BULLETIN INVOLVES VEHICLES EXHIBITING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA.

INFORMATION ON USING 1999 PROCEDURES MANUAL FOR SIDE MIRROR REPLACEMENT.

EXHIBITING FRONT WINDSHIELD WIPER ACTIVATION WITHOUT COMMAND.

SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP.

SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF,...

POP/THUMP NOISE AT END OF WINDOW MOVEMENT AND/OR DRIVER'S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION.

WINDNOISE AND/OR A WATER LEAK FROM THE SLIDING BACK GLASS AREA.

TAILGATE LOCKING BY ITSELF WHEN SLAMMED SHUT OR WHEN THE VEHICLE IS BEING DRIVEN OVER ROUGH ROADS.

LOCKING TAILGATE LOCKS ITSELF.

DRIVER'S SIDE DOOR GLASS THAT BINDS WHEN OPERATED.

INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES.

SOME VEHICLES MAY EXHIBIT CORROSION AT THE ATTACHMENT POINT OF THE STARTER CABLE B+ TERMINAL, AT THE STARTER SOLENOID.

SOME VEHICLES MAY EXHIBIT A NO CRANK, NO START CONDITION DUE TO CORROSION OF THE STARTER CABLE B+ TERMINAL AT THE STARTER SOLENOID.

CONCERNS WITH CORRODED POSITIVE STARTER CABLE.

INOPERATIVE OR INACCURATE SPEEDOMETER AS WELL AS 4X4 LIGHT INOPERATIVE AND / OR DIAGNOSTIC TROUBLE CODE P1635 AND / OR...

THIS BULLETIN STATES THAT ON SOME VEHICLES (INCLUDING 2002 BLACKWOOD) A BATTERY DISCONNECT OR PARAMETER RESET IS...

INOPERATIVE OR INACCURATE SPEEDOMETER, 4X4 LAMP ILLUMINATED AND / OR DIAGNOSTIC TROUBLE CODES (DTCS) P1635 OR P1639...

SUBJECT REGARDING THE NAGATIVE BATTERY TERMINAL COVER ON SOME VEHICLES.

CERTAIN VEHICLES MAY EXHIBIT AN INOPERATIVE SPEEDOMETER AND DIAGNOSTIC TROUBLE CODE P1635 AFTER A PECM HAS BEEN REPLACED.

SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA.

INFORMATION REGARDING A NEW SERVICE PART RELEASED FOR THE LICENSE PLATE LIGHT CIRCUIT WHICH WILL REDUCE THE COSE OF REPAIRS.

SOME VEHICLES MAY EXHIBIT AN INOPERATIVE SPEEDOMETER AND DTC P1635 AFTER A PCM HAS BEEN REPLACED.

SOME BI-FUEL VEHICLES MAY REQUIRE POWERTRAIN CONTROL MODULE (PCM) REPLACEMENT DURING SERVICE AND MAY NOT RUN ON CNG OR...

ALL VEHICLES MAY EXHIBIT AN INOPERATIVE OR INACCURATE SPEEDOMETER, 4X4 LIGHT INOPERATIVE AND/OR DTC P1635 AFTER A PCM HAS BEEN REPLACED.

SUBJECT REGARING THE IGNITION TAMPER SWITCH.

SUBJECT REGARDING ALL VEHICLES REQUIRES A PARAMETER RESET TO BE PERFORMED ON THE PASSIVE ANTI-THEFT SYSTEM MODULE (PATS...

SOME VEHICLES MAY EXHIBIT A DIAGNOSTIC TROUBLE CODE B1845 (IGNITION TAMPER SWITCH FAILURE) WHEN RETRIEVING DIAGNOSTIC...

INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS.

SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES.

INFORMATION ON USING THE SERVICE BAY TECHNICAL SYSTEM (SBTS) AND NEW GENERATION STAR (NGS) TESTER, AND TO UPDATE THE...

INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS).

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.

GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES.

VARIOUS INTERMITTENT ELECTRICAL CONCERNS INCLUDING BUT NOT LIMITED TO SOME ACCESSORIES REMAINING POWERED UP WITH THE KEY...

INFORMATION ON VEHICLES EXHIBITING A PERCEIVED POOR FUEL RANGE / ECONOMY, AND OR A FAULTY FUEL GAUGE.

SOME BI-FUEL LPG VEHICLES (WITH COOLANT LOCK OFF) MAY EXHIBIT A NO START CONDITION.

SOME BI-FUEL CANG AND LPG VEHICLES MAY EXHIBIT A NO START CONDITION.

SUBJECT REGARDING ALTERNATIVE FUEL VEHICLE COMPRESSED NATURAL GAS TANK INSPECTION.

SUBJECT REGARDING OVERVIEW OF BI-FUEL CNG VEHICLE PARAMETER IDENTIFICATION DATA (PID), INPUTS AND OUTPUTS AS A DIAGNOSTIC AID FOR BI-FUEL VEHICLES.

SOME BI-FUEL VEHICLES MAY EXHIBIT A NO START CONDITION.

THIS BULLETIN INVOLVES FUEL DOOR LABEL APPLICATION / REPLACEMENT.

SOME VEHICLES MAY EXHIBIT A NO CRANK / NO START CONDITION IN TEMPERATURES BELOW 12 DEGREES C (10 DEGREES F).

SOME VEHICLES MAY EXHIBIT AN INTERMITTENT HESITATION OR BUCK WHILE DRIVING IN ANY FUEL MODE (LPG, CNG OR GASOLINE).

EXHIBITING A CRACKLING / POPPING NOISE FROM THE EXHAUST.

SOME VEHICLES BUILT BETWEEN 11/1/97 AND 12/8/99 MAY EXHIBIT A CRACKLING/POPPING NOISE FROM THE EXHAUST.

SOME VEHICLES MAY EXHIBIT A CRACKLING/POPPING NOISE FROM THE EXHAUST, VEHICLES BUILT BETWEEN 11/1/97 AND 12/8/99.

SOME OWNERS MAY REPORT SLOW FUEL GAUGE RESPONSE TIME DURING RE-FUELING.

EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP.

EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM.

Safety recall 11S21 - Fuel tank strap fracture - requests for recall service action

For 1997-2003 F-150, 2004 F-150 Heritage, 1997-1999 F-250 Light Duty, or 2002-2003 Blackwood vehicles Safety Recall...

FORD/LINCOLN: SAFETY RECALL REGARDING HIGH CORROSION AREAS FOR OPERATING, FOR AN EXTENDED TIME, VEHICLES WHERE BOTH OR...

FORD/LINCOLN: SAFETY RECALL ISSUED DUE TO ONE OR BOTH FUEL TANK STRAPS FRACTURING DUE TO BEING IN HIGH CORROSION AREAS...

FORD: CERTAIN 1999-2001 MODEL YEAR VEHICLES UP TO 6000 LB GVWR REGISTERED IN NEW YORK AND CERTAIN 2001 VEHICLES UP TO...

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK...

BI-FUEL LPG VEHICLES (WITH COOLANT LOCK OFF) MAY EXHIBIT A NO START CONDITION.

SOME VEHICLES WITH 4-WHEEL DISC BRAKES MAY EXHIBIT A MOAN FROM THE REAR BRAKES ON LIGHT BRAKE APPLICATIONS.

SOME LIGHTNING MODEL VEHICLES MAY EXHIBIT A REDUCED POWER ASSIST AFTER THE FIRST TWO OR THREE BRAKE APPLICATIONS DURING...

SOME VEHICLES MAY EXHIBIT A GRABBING CONDITION FROM THE REAR DRUM BRAKES DURING THE FIRST FEW BRAKE APPLICATIONS AFTER EXTENDED HUMIDITY EXPOSURE.

INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT.

THIS ONLINE SERVICE BULLETIN MENTIONS THAT LATE BUILT REGULAR CABS WILL NOT OFFER A TOOL BOX TRAY LOCATED BEHIND THE...

SOME VEHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR LAMP ON WITH NO DIAGNOSTIC TROUBLE CODES (DTC) DETECTED.

SOME VHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR LAMP WITH NO DIAGNOSTIC TROUBLE CODES (DTC).

SUBJECT REGARDING ABS ELECTRONIC MODULE NOW AVAILABLE FOR SERVICE.

VEHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR LAMP WITH NO DIAGNOSTIC TROUBLE CODE (DTC) DETECTED.

SUBJECT REGARDING ANTI-LOCK BRAKE LAMP ILLUMINATION, INCREASED BREAK PEDAL EFFORT AND / OR FALSE ANTI-LOCK BRAKE SYSTEM (ABS) CYCLING AT LOW SPEEDS.

CONDITIONS ON REAR DRUM GRABBING DURING FIRST FEW BRAKE APPLICATIONS WHILE BRAKES ARE COLD.

VEHICLES EXPERIENCING INCREASED BRAKE PEDAL EFFORT AND / OR FALSE ABS CYCLING AT LOW SPEEDS, OR ABS LAMP ILLUMINATION.

DRIVELINE CLUNKING/GRUNTING NOISE OR SHUDDER SENSATION DURING LIGHT TO MODERATE ACCELREATION AND/OR BRAKING.

EXHIBITING A POPPING NOISE FROM THE LOWER CONTROL ARM.

SOME VEHICLES BUILT WITH 3-LEAF REAR SPRINGS MAY EXHIBIT A REAR SPRING RATTLE.

VEHICLES BUILT WITH 3-LEAF REAR SPRINGS MAY EXHIBIT A REAR SPRING RATTLE *MJS

SOME VEHICLES MAY EXHIBIT A POPPING NOISE FROM THE LOWE CONTROL ARM.

SOME VEHICLES MAY EXHIBIT A POPPING NOISE FROM THE LOWER CONTROL ARM.

SUBJECT REGARDING THE AVAILABILITY OF REAR SPRING CLIP KITS FOR VEHICLES EXHIBITING REAR SPRING RATTLE.

SUBJECT REGARDING REAR SPRING CLIP KITS FOR VEHICLES EXHIBITING A REAR SPRING RATTLE.

SOME VEHICLES BUILT WITH 3-LEAF OR 4-LEAF REAR SPRINGS MAY EXHIBIT A REAR SPRING RATTLE.

INFORMATION REGARDING EXTENSION HOUSING BUSHING LEAK/SPIN OUT.

INFORMATION REGARDING EXTENSION HOUSING BUSHING LEAK./SPIN-OU.

SUBJECT REGARDING REAR SPRING RATTLE.

REAR LEAF SPRING NOISE.

SNOW PACKING OF THE AIR FILTER WHEN DRIVING IN SEVERE SNOW CONDITIONS MAY EXHIBIT LOSS OF POWER AND / OR THE MALFUNCTION INDICATOR LAMP ILLUMINATING.

INOPERATIVE OR INACURRATE SPEEDOMETER, 4X4 LAMP ILLUMINATD, AND / OR DIAGNOSTIC TROUBLE CODE P1635 OR P1639.

SOME VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS INCLUDING LACKS POWER, HESITATES, HARD TO START, AND/OR...

CERTAIN 1999 AND 2000 MODEL YEAR F150 LIGHTNING VEHICLES - INTERCOOLER REPLACEMENT.

SOME LIGHTNING MODELS MAY EXHIBIT A CLUNKING SOUND FROM THE FRONT END AREA DURING PARKING MANEUVERS.

CONCERNS WITH MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION AND DIAGNOSTIC TROUBLE CODE (DTC) P0171 AND / OR P0174 STORED IN MEMORY.

SOME VEHICLES MAY EXHIBIT A CLUNKING SOUND ON SOME SVT LIGHTNING VEHCLES DURING PARKING MANEUVERS.

INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND...

DAMAGED REAR LICENSE PLATE LAMPS DUE TO ROCKS AND/OR GRAVEL HITTING THE LAMP ASSEMBLIES.

MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES (DTC) P0171, OR P0174.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH NO HARD FAULT.

CUSTOMER MAINTENANCE REMINDER - LITERATURE PROGRAM 04L19 - TIE ROD INSPECTION PROCEDURE.

POWER STEERING LEAK - SERVICE TIP.

WHINE FROM POWER STEERING.

TIE ROD END INSPECTION PROCEDURE.

TIE ROD END INSPECTION PROCEDURE.

REDUCED POWER STEERING ASSIST AND/OR POWER STEERING LEAKS WHEN DRIVEN IN TEMPERATURES EQUAL TO OR LESS THAN -25 DEGREES CELCIUS.

TIE ROD END INSPECTION PROCEDURE.

FIELD SERVICE ACTION 01L07 TO REPLACE INCORRECT TIRE SIZE AND PRESSURE INFORMATION ON THE TIRE INFORMATION LABEL.

SOME VEHICLES MAY EXHIBIT DENTS ON THE WHEEL WELL SHEET METAL OF THE PCIK-UP BOX AREA WHEN USED IN OFF-ROAD APPLICATIONS.

INFORMATION REGARDING OUTWARD DENTS IN PICKUP BOX WHEEL WELLS.

INFORMATION REGARDING OUTWARD DENTS IN PICKUP BOX WHEEL WELLS.

SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING...

SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS.

INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS.

SOME VEHICLES MAY EXHIBIT A WHISTLING NOISE WHILE DRIVING WITH A/C IN THE OFF POSITION AT SPEEDS ABOVE 64 KM/H (40 MPH).

NO/HARD START IN COLD AMBIENTS / NEW TWO-PIECE BLOCK HEATER CORD RELEASED.

SOME VEHICLES MAY EXHIBIT AN INOPERATIVE COURTESY, GLOVE COMPARTMENT, UNDERHOOD, RUNNING BOARD LAMPS, POWER WINDOWS,...

CONCERNS WITH COURTESY, GLOVE COMPARTMENT, UNDERHOOD, RUNNING BOARD LAMPS; POWER WINDOWS; RADIO; AND REAR WIPER ALL...

SUBJECT REGARDING COWL LEAF SCREEN CHANGE.

SUBJECT REGARDING COWL LEAF SCREEN CHANGE.

SUBJECT REGARDING VEHICLES EXHIBITING WINDNOISE AT PRE-DELIVERY.

INFORMATION TO TECHNICIANS REGARDING OBJECTIONABLE WINDNOISE IDENTIFIED DURING PRE-DELIVERY.

CONCERNS WITH THE STORAGE BIN INSIDE THE CONSOLE MAY FALL DOWN INSIDE THE CONSOLE BASECD ON SOME VEHICLES.

REMOTE OIL FILTER ADAPTOR REPLACEMENT - NEW SERVICE PART.

GUIDANCE FOR CNG TANK INSPECTION FOR VEHICLES PRODUCED AFTER DECEMBER 2, 1996.

BRIEF INFORMATION STATING THAT CERTAIN VEHICLES ARE EQUIPPED WITH A NEW HYBRID ELECTRONIC INSTRUMENT CLUSTER (HEC).