1995 Ford F-150 TSBs

BRAKE SHIFT INTERLOCK.*JB

INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS.

SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM.

ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR...

SUBJECT REGARDING A NEW TRANSMISSION CASE AND MAIN CONTROL RELEASED FOR SERVICE ON AODE / 4R70W TRANSMISSIONS.

VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN...

INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP.

TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART.

CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK.

EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY...

SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,...

SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728.

INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART.

FLUID- TRANSMISSION FLUID USAGE CHARTS.

HIGH SHIFT EFFORTS ON MANUAL TRANSMISSION.

HIGH SHIFT EFFORTS ON MANUAL TRANSMISSION.

SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET.

VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET.

SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET.

TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP.

TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP.

E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM.

INFORMATION ON AODE/4R7W TRANSMISSION MAIN CONTROL & CASE REPLACEMENT.

4X4 FRONT AXLES MUST USE HYPOID 4X4 GEAR OIL P/N F1TZ-19580-A & HIGH TEMP 4X4 FRONT AXLE & WHEEL BEARING GREASE WHEN SERVICING.

REVISED DESIGN TRANSMISSION REAR CASE BUSHING.

THERE MAY BE AN INTERMITTENT LOSS OF TORQUE DURING OR JUST AFTER THE 3-4 UPSHIFT OR IN 4TH GEAR ON SOME VEHICLES.

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK.

NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS.

ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE.

A CONDITION MAY EXIST WITH POSSIBLE ELECTRONC DAMAGE OCCURING TO THE COMPUVALVE FROM VOLTAGE SPIKES BETWEEN THE...

SERVICE TIP INFORMATION REGARDING THE REVERSE CLUTCH PISTON AND PISTON SEAL USAGE.

EXPERIENCING A KNOCKING NOISE WHEN THE ENGINE IS COLD AND UNDER ACCELERATION.

FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR.

FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS.

NEW CLUTCH SLAVE CYLINDER WITH A REDESIGNED LIP SEAL.

THE CLUTCH MAY BE HARD TO DEPRESS DUE TO DUST/CONTAMINATION ENTERING THE SLAVE CYLINDER.

ACCESSORY DRIVE BELTS- FEAD BELT COMES OFF- VEHICLES WITH 4.9L ENGINE.

ENGINE COMPARTMENT NOISE-"BUZZING OR KNOCKING"- RIGHT FRONT OF ENGINE-AFTER STARTING.

ENGINE COMPARTMENT NOISE - BUZZING OR KNOCKING - RIGHT FRONT OF ENGINE - AFTER STARTING - 4.9L ENGINES - F SERIES BUILT...

LONG CRANK - STICKING IDLE AIR CONTROL (IAC) VALVE - VEHICLES BUILT FROM 11/1/94 THROUGH 3/30/96 -STALL - AFTER STARTING...

VIBRATION - DRIVELINE VIBRATION AND/OR DRIVELINE NOISE - REGULAR CAB 4X4 VEHICLES EQUIPPED WITH 7.5L ENGINE AND MANUAL TRANSMISSION.

VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS.

BULLETIN APPLIES TO VEHICLES EQUIPPED W/ A 31TH TRANSAXLE.

SOME E4OD TRANSMISSIONS W/ BUILD DATES 5B03 (FEB.

ENGINE- 'KNOCKING' NOISE - WHEN OPERATING ENGINE AT 200-2300 RPM - FD1460 ENGINE

GENERATOR-MOTORCRAFT 95AMP-FRONT BEARING CONCERN-FD1060/1460 ENGINES- VEHICLES BUILT BEFORE 7/3/95.

KNOCKING NOISE ON INITIAL START-UP.

VEHICLES WITH 7.3L DIRECT INJECTION DIESEL ENGINES MAY EXPERIENCE ONE OR MORE OF THE FOLLOWING CONDITIONS: ROUGH IDLE,...

EARLY WEAR OF FEAD TENSIONER PULLEY ON VEHICLES WITH 5.0L/5.8L ENGINES.

ENGINES UNDERGOING A RUNNING CHANGE TO SMALLER DIAMETER A/C COMPRESSOR PULLEY.

SOME VEHICLES MAY EXHIBIT A DRIFT OR PULL TO THE LEFT WHILE BRAKING.

INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT.

SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT.

AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT.

SUBJECT REGARDING ON-VEHICLE CALIPER-MOUNT LATHE MACHINING SETUP PROCEDURES.

A SHUDDER / VIBRATION AND / OR SQUEALING HEARD WHILE BRAKING - REVISED FRONT BRAKE LINING.

A COMPREHENSIVE PULL AND DRIFT DIAGNOSTIC PROCEDURE HAS BEEN DEVELOPED TO ASSIST TECHNICIANS IN RESOLVING BRAKE PULL OR DRIFT CONCERNS.

THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE.

SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS.

HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE.

BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP.

THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE...

BRAKES - HYDRAULIC - HYDROMAX BRAKE RESEREVOIR MOUNTING BRACKET SEPARATION.

SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE.

SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC)...

CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS.

INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS.

RECOMMENDED GUIDELINES FOR TOWING BEHIND RECREATIONAL VEHICLES.

PART NUMBER INFORMATION FOR THE USE OF A CHILD SEAT TETHER.

UNKNOWN

UNKNOWN

REVISED OIL PAN GASKET.

REVISED OIL FILL PROCEDURES.

UNKNOWN

SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC...

SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES.

WIRING- AFTERMARKET WIRING ALTERATIONS- SERVICE TIP.

POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP.

MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP.

WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS.

WHEN DIAGNOSING AN AIR BAG LAMP FLASH-OUT CODE 33 (PASSENGER SIDE AIR BAG HIGH RESISTANCE OR OPEN) ON A 1994-1996 F150...

UNDER HOOD WIRE HARNESS MAY BECOME CHAFED.

AFTERMARKET WIRING ALTERATIONS - SERVICE TIP.

SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS.

INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS.

PERFORMANCE ENHANCEMENT FOR DEFROSTER.

INFORMATION ON THE DEFROSTER PERFORMANCE ENHANCEMENT.

AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL.

THE A/C HEATER BLOWER WHEEL MAY FRACTURE ON SOME VEHICLES DUE TO ICE FORMATION IN THE BLOWER HOUSING.

WHISTLE NOISE FROM AC WITH CONTROLS ON MAX A/C.

WHISTLE NOISE WHEN TEMPERATURE SET AT FULL HEAT AND HIGH BLOWER.

EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP.

EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM.

INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM.

FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE.

HYDROMOUNTED CAB - EVAPORATIVE EMISSION LINES RUBBING ON THE FENDER.

GREEN CONDENSATE OR WHITE SMOKE COMING FROM EXHAUST PIPE.

NOISE- "RATCHETING"- FRONT AXLE- 4X4- SELF-ENGAGEMENT OF AUTOMATIC HUB LOCKS- BRONCO, F-150 AND F-250 UNDER 8500# GVW.

NOISE- "POPPING/CREAKING"- FRONT FRAME OR SUSPENSION BRACKETS- FRAME- "POPPING/CREAKING"- FASTENER REPLACEMENT.

NOISE - RATCHETING - FRONT AXLE - 4X4 - SELF ENGAGEMENT OF AUTOMATIC HUB LOCKS.

CONCERN OF AUTOMATIC HUBLOCKS SELF-ENGAGING.

A RATTLE FROM THE SPLIT SEAT BENCH MAY BE DUE TO A LOOSE OR MISSING SEAT BUSHING.

SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP.

WINDSHIELD AND INTERIOR GLASS - FOG/FILM.

THE FRONT BUMPER MOUNTING TORQUE SPECIFICATION HAS BEEN REVISED FOR BETTER OVERALL BUMPER RETENTION AND PERFORMANCE.

REVISED MOUNTING TORQUE FOR BUMPERS.

HEADLAMP- HEADLAMP HOUSING MELTS- AMBULANCE AND EMERGENCY VEHICLES ONLY.

GEM CONCERN - CHECK FOR MORE THAN ONE GEM CONTROLLED COMPONENT THAT IS INOPERATIVE OR FOR A STRING OF FALSE GEM DTC'S RECEIVED IN MEMORY.

COOLING SYSTEM - LEAKING RADIATOR HOSE - UPGRADED HOSE CLAMPS.

SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING...

INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE.

THE NGS DISPLAYS INCORRECT DATA FOR THE IGN GEM PID ON THE VEHICLES.

THE NGS DISPLAYS INCORRECT DATE FOR THE ING GEM PID ON THE VEHICLES.

AIR BAG LAMP FLASH-OUT CODE 33 ON VEHICLES EQUIPED WITH A PASSENGER SIDE AIR BAG.

DIAGNOSING AN AIR BAG LAMP FLASH-OUT CODE 33 (PASSENGER SIDE AIR BAG HIGH RESISTANCE OR OPEN)

FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS.

LIGHT CLICKING SENSATION OR LOOSENESS AS THE STEERING WHEEL IS TURNED.