1993 Ford F-150 TSBs

INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS.

SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM.

VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN...

INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP.

TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART.

TRANSMISSION-E40D-NO 2-3 UPSHIFT.

SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,...

SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728.

INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART.

FLUID- TRANSMISSION FLUID USAGE CHARTS.

TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP.

TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP.

INFORMATION ON AODE/4R7W TRANSMISSION MAIN CONTROL & CASE REPLACEMENT.

4X4 FRONT AXLES MUST USE HYPOID 4X4 GEAR OIL P/N F1TZ-19580-A & HIGH TEMP 4X4 FRONT AXLE & WHEEL BEARING GREASE WHEN SERVICING.

STEERING GEAR-REPLACEMENT OF BENDIX, STEERING GEAR WITH NEW ROSS STEEERING GEAR.

DELAYED FORWARD ENGAGEMENT AND/OR HEAT STAINED FORWARD CLUTCH PLATES AFTER INSTALLING CENTER SUPPORT SERVICE.

REVISED DESIGN TRANSMISSION REAR CASE BUSHING.

NEW DESIGN TRANSMISSION RANGE SENSOR.

NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS.

SOME VEHICLES MAY EXHIBIT A DRIFT OR PULL TO THE LEFT WHILE BRAKING.

PROCEDURE FOR SERVICING PARKING BRAKE- SERVICE TIP- BRONCO AND F-SERIES BUILT THROUGH 4/22/1994 AND EXPLORER/RANGER BUILT THROUGH 5/13/1994.

INFORMATION REGARDING PARKING BRAKE CONTROL ASSEMBLY CONCERNS- BRONCO AND F-SERIES BUILT THROUGH 4/22/1994 AND EXPLORER/RANGER BUILT THROUGH 5/13/1994.

VEHICLES MAY EXPERIENCE PARKING BRAKE PEDAL WHICH GOES TO THE FLOOR WITH MINIMAL EFFORT- BRONCO AND F-SERIES BUILT...

INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT.

SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT.

AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT.

THE PARKING BRAKE PEDAL MAY GO TO THE FOOR WITH LITTLE OR NO EFFORT DURING APPLICATION.

THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE.

SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS.

HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE.

BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP.

THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE...

SERVICE TIP INFORMATION REGARDING THE REVERSE CLUTCH PISTON AND PISTON SEAL USAGE.

FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR.

FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS.

NEW CLUTCH SLAVE CYLINDER WITH A REDESIGNED LIP SEAL.

THE CLUTCH MAY BE HARD TO DEPRESS DUE TO DUST/CONTAMINATION ENTERING THE SLAVE CYLINDER.

ACCESSORY DRIVE BELTS- FEAD BELT COMES OFF- VEHICLES WITH 4.9L ENGINE.

VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS.

ENGINE- 'KNOCKING' NOISE - WHEN OPERATING ENGINE AT 200-2300 RPM - FD1460 ENGINE

GENERATOR-MOTORCRAFT 95AMP-FRONT BEARING CONCERN-FD1060/1460 ENGINES- VEHICLES BUILT BEFORE 7/3/95.

KNOCKING NOISE ON INITIAL START-UP.

EARLY WEAR OF FEAD TENSIONER PULLEY ON VEHICLES WITH 5.0L/5.8L ENGINES.

CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS.

RECOMMENDED GUIDELINES FOR TOWING BEHIND RECREATIONAL VEHICLES.

PART NUMBER INFORMATION FOR THE USE OF A CHILD SEAT TETHER.

VEHICLES EXPERIENCING OCCASIONAL HARSH REVERSE ENGAGEMENT CONCERNS.

UNKNOWN

UNKNOWN

REVISED OIL PAN GASKET.

UNKNOWN

SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS.

INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS.

PERFORMANCE ENHANCEMENT FOR DEFROSTER.

INFORMATION ON THE DEFROSTER PERFORMANCE ENHANCEMENT.

ANNOUNCING THE FORD OEM AIR CONDITIONING RETROFIT KIT AVAILABILITY.

AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL.

EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP.

EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM.

INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM.

FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE.

HYDROMOUNTED CAB - EVAPORATIVE EMISSION LINES RUBBING ON THE FENDER.

SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES.

WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS.

UNDER HOOD WIRE HARNESS MAY BECOME CHAFED.

SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING...

INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE.

SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP.

WINDSHIELD AND INTERIOR GLASS - FOG/FILM.

NOISE- "POPPING/CREAKING"- FRONT FRAME OR SUSPENSION BRACKETS- FRAME- "POPPING/CREAKING"- FASTENER REPLACEMENT.

A RATTLE FROM THE SPLIT SEAT BENCH MAY BE DUE TO A LOOSE OR MISSING SEAT BUSHING.

HEADLAMP- HEADLAMP HOUSING MELTS- AMBULANCE AND EMERGENCY VEHICLES ONLY.

FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS.