2002 Ford Explorer TSBs

SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC (SINGLE OVER-HEAD CAM) ENGINE MAY EXHIBIT A PRIMARY TIMING CHAIN RATTLE NOISE.

SUBJECT REGARDING INTERMITTENT ENGINE QUIT DURING TRANSMISSION ENGAGEMENTS OR PARKING MANEUVERS.

INFORMATION ON DIAGNOSING ENGINE RATTLE NOISE FROM PRIMARY CHAIN DRIVE AREA BETWEEN 2000-3000 RPM ON COLD ENGINE OPERATION ONLY.

SOME VEHICLES EQUIPPED WITH A V6 ENGINE MAY EXHIBIT A STEERING RATTLE NOISE WHICH MAY BE HEARD AND FELT IN THE STEERING WHEEL AND COLUMN.

SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED).

SOME VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0300 (RANDOM MISFIRE) OR P0301.

SOME VEHICLES MAY EXHIBIT AN INTAKE MANIFOLD CROSSOVER (FIRST RUNNER) COOLANT SEEPAGE CONDITION.

SOME VEHICLES EQUIPPED WITH 4.6L ENGINES MAY EXHIBIT A HIGH FREQUENCY WHINE NOISE (HAIR DRYER TYPE NOISE), THAT LASTS...

SOME VEHICLES MAY EXHIBIT A CHECK ENGINE LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457 (GROSS LEAK AFTER FUEL FILL).

CONCERNS WITH SPARK KNOCK NOISE OR CHAIN RATTLE NOISE BETWEEN 2000-3000 RPM, DURING COLD ENGINE OPERATION ONLY.

ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE.

SOME VEHICLES EQUIPPED WITH THE 4.0L ENGINE MAY EXHIBIT A CONDITION OF UNABLE TO ACCESS WITH THE SECURILOCK PASSIVE ANTI-THEFT SYSTEM (PATS).

EXHIBITING ROUGH IDLE, OR ROUGH IDLE UPON INITIAL START-UP THAT CLEARS UP AFTER A FEW MINUTES.

SOME VEHICLES WITH THE 4.0L ENGINE MAY EXHIBIT AN ENGINE FLUTTER NOISE.

SOME VEHICLES BUILT PRIOR TO 11/11/2001 EQUIPPED WITH 5R55W TRANSMISSION AND 4.6L ENGINE, MAY EXHIBIT A BUZZING NOISE...

SOME 4.0L SOHC MAY EXHIBIT AN ENGINE OIL LEAK CONDITION, COMING FROM THE OIL PAN OR LADDER FRAME AREA.

INFORMATION REGARDING ENGINE WIND NOISE.*YH

SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED).

SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA.

SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174.

EXHIBIT HARSH 1-2, 3-4 UPSHIFTS AT LIGHT TO MEDIUM THROTTLE ON SOME VEHICLES EQUIPPED WITH A 4.6L ENGINE AND 5R55W...

SOME VEHICLES WITH 5R5W MAY EXHIBIT A NO ENGAGEMENT CONDITION.

SOME OWNERS MAY NOTICE A KNOCKING NOISE FROM THE REAR OF THE VEHICLE WHEN THE BRAKES ARE APPLIED.

SOME VEHICLES MAY EXHIBIT DRIVABILITY CONDITIONS OR CHECK ENGINE LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0455 OR P0457.

SOME VEHICLES MAY EXHIBIT DRIVABILITY CONDITIONS OR CHECK ENGINE LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0455 OR P0457 STORED.

SOME VEHICLES EQUPPED WITH 4.0L ENGINE MAY EXHIBIT EXCESSIVE SULPHUR SMELL FROMTHE EXHAUST SYSTEM WHILE OPERATING UNDER...

SOME VEHICLES EQUIPPED WITH 4.6L ENGINE AND 5R55W TRANSMISSION MAY EXHIBIT VARIOUS FIRM AND/OR SOFT SHIFTS.

SOME VEHICLES EQUIPPED WITH 4.0L ENGINE MAY EXHIBIT A ROUGH IDLE CONDITION.

SOME VEHICLES EQUIPPED WITH 4.0L ENGINE MAY EXHIBIT EXCESSIVE SULPHUR SMELL FROM THE EXHAUST SYSTEM WHILE OEPRATING UNDER DRIVE MODES.

SOME VEHICLES EQUIPPED WITH A 4.0L ENGINE AND 5R55W AUTOMATIC TRANSMISSION BUILT 11/13/2000 THROUGH 5/21/2001 MAY...

SOME VEHICLES MAY REQUIRE EXCESSIVE EFFORT WHEN TRYING TO INSERT THE KEY INTO THE IGNITION LOCK CYLINDER.

SOME VEHICLES EQUIPPED WITH A 4.0L ENGINE MAY EXHIBIT AN INTERMITTENT HESITATION ON ACCELERATION.

SOME VEHICLES MAY EXHIBIT A ROUGH IDLE OR ROUGH IDLE AFTER INITIAL START-UP THAT CLEARS UP AFTER A FEW MINUTES.

SOME VEHICLES MAY EXHIBIT A ROUGH IDLE OR ROUGHT IDLE AFTER INITIAL START-UP THAT CLEARS UP AFTER A FEW MINUTES.

EXHIBITING DRIVABILITY CONDITIONS OR CHECK ENGINE LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED).

SOME VEHICLES EQUIPPED WITH A 5R55W AUTOMATIC TRANSMISSION MAY EXHIBIT A TICK NOISE WHILE AT IDLE IN PARK AND NEUTRAL.

VEHICLES WITH 4.0L ENGINE MAY EXHIBIT AN INTERMITTENT HESITATION ON ACCELERATION.

SOME VEHICLES MAY EXHIBIT A REPETITIVE THUMP / KNOCK NOISE FROM THE REAR WHICH IS PROPORTIONAL TO WHEEL SPEED WHEN BRAKE.

SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS OR CHECK ENGINE LAMP (MIL) ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED).

INFORMATION ON OBTAINING ENGINEERING ASSISTANCE FOR ANTI-LOCK BRAKE SYSTEM.

INFORMATION ON THE INTAKE MANIFOLD VALLEY STUFFER BAG.

SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC ENGINE MAY EXHIBIT A PRIMARY CHAIN RATTLE NOISE (SOMETIMES DESCRIBED AS A SPARK KNOCK-TYPE NOISE).

SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT...

EXTENDED COVERAGE PROGRAM 05N04 - EXTENDED COVERAGE FOR COMPOSITE INTAKE MANIFOLD.

WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING.

HARD START/NO START CONDITION DURING COLD AMBEINT TEMPERATURES AFTER SHORT HOT SOAK PERIOD-4.0L ENGINE.

ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS.

RATTLE NOISE FROM PRIMARY CHAIN DRIVE AREA 2000-3000 RPM - 4.0L SOHC ENGINE.

RUNS ROUGH OR MISFIRE - DIAGNOSTIC TROUBLE CODES P0300-P0308 OR P0316.

ENGINE-ROMEO BUILT 4.6L 2V-TICK NOISE FROM ENGINE-ENGINES BUILT BEFORE 9/17/2003.

MULTIPLE VEHICLES WITH 3.0L OR 4.0L ENGINES LACKS POWER/RUNS ROUGH/BLACK SMOKE.

EXCESSIVE ENGINE COOLING FAN NOISE.

DRIVEABILITY CONDITIONS DUE TO CALIBRATION VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE.

SHUDDER DURING 4/5 UPSHIFT AND/OR 5/4 DOWNSHIFT ON VEHICLES EQUIPPED WITH A 4.6L ENGINE AND 5R55W AUTOMATIC TRANSMISSION.

ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED...

ROUGH/ROLLING IDLE OR HESITATION AFTER FIRST STARTUP OR A ROUGH/ROLLING ENGINE SPEED WHEN RETURNING TO IDLE AFTER A SHORT TRIP.

ROUGH IDLE / ENGINE SHAKE.

SOME VEHICLES, EQUIPPED WITH THE 4.6L 2V ENGINE, WITH AN ENGINE BUILD DATE PRIOR TO 8/29/03 MAY EXHIBIT AN ENGINE TICK...

ROUGH / ROLLING IDLE AND HESITATION ON ACCELERATION AFTER A FIRST COLD STARTUP.

IDLE AIR CONTROL (IAC) VALVE DIAGNOSTIC SERVICE TIPS.

INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER,...

SOME VEHICLES BUILT SINCE OCTOBER 1, 2001 MAY EXHIBIT A NO START CONDITION OR AN INTERMITTENT NO START CONDITION, AND /...

SOME 4DR VEHICLES MAY EXHIBIT SEATING APPEARANCE OR RELATED ISSUES.

CONCERNS WITH CLUNK NOISE FROM FRONT AXLE AREA.

SOME VEHICLES MAY EXHIBIT AN INTERMITTENT NO CRANK CONDITION AND NO COMMUNICATION FROM THE POWERTRAIN ELECTRONIC...

SOME VEHICLES EQUIPPED WITH 3RD ROW SEATING MAY EXHIBIT A CONDITION WITH THE SEAT RELEASE LATCH STICKING/BINDING.

SOME VEHICLES MAY EXHIBIT AN INTERMITTENT NO CRANK CONDITION AND NO COMMUNICATION FROM THE POWERTRAIN ELECTRONIC...

SOME VEHICLES MAY EXPERIENCED A STRONG SULPHUR ODOR DURING CERTAIN DRIVE MODES.*YD

SOME 4X4 VEHICLES WITH FEWER THAN 10,000 MILES MAY EXHIBIT GREASE OOZING FROM THE FRONT DRIVESHAFT CV JOINT.

INFORMATION REGARDING THE SMOKERS PACKAGE.

INFORMATION REGARDING MISDIAGNOSIS OF MAIN CONTROLS - INCORRECT PRESSURES.

INFORMATION REGARDING NEW COMPASS SETTING PROCEDURE, PDI MUST SET ALL.

SOME VEHICLES EQUIPPED WITH A CLASS II HITCH MAY EXHIBIT INSUFFICIENT CLEARANCE INT HE RECEIVER TO ATTACH TUBULAR HITCH ACESSORIES TO THE VEHICLE.

FLUID LEAK IN THE CONVERTER HOUSING AREA ON VEHICLES BUILT 11/13/2000 THROUGH 4/27/2001.

SOME VEHICLES WITH FEWER THAN 10,000 MILES MAY EXHIBIT GREASE OOZING FROM THE FRONT DRIVESHAFT CV JOINT.

INFORMATION ON THE LOCATION OF THE HEATED SEAT SWITCH.

INFORMATION ON PERFORMING ANY PASSTIVE ANTI-THEFT (PATS) SYSTEM FUNCTIONS INCLUDING KEY REPLACEMENTS WITH WDS OR NGS.

SOME VEHICLES EQUIPPED WITH 7 PASSENGER SEATING MAY EXHIBIT THE 2ND ROW 40 PERCENT SEAT BACK STAYING IN THE DOWN POSITION.

SOME VEHICLES MAY EXHIBIT AN INTERMITTENT NO CRANK CONDITION AND NO COMMUNICATION FROM THE POWERTRAIN ELECTRONIC...

INFORMATION ON AVAILABILITY OF NEUTRAL TOW KIT.

SUBJECT REGARDING EDSR BONUS POINTS.

ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE.

VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK.

REAR AXLE NOISE REPAIR.

NO START/HARD START N HOT SOAK RESTART.

REAR AXLE NOISE REPAIR.

AXLE WHINE HOWL. THIS INCLUDES 1997-05 FORD VEHICLES.

SAFETY BELT RETRACTION SPEED.

LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS.

SUN VISOR RATTLE / DETROIT AREA DEALERS CONTACT REQUEST.

DRIVELINE 1ST ORDER VIBRATION/BOOM/DRONE.

NO CRANK/NO START CONDITION WHEN VEHICLE TEMPERATURE IS BELOW FREEZING (32F/0C).

REAR AXLE NOISE. OASIS.

MULTIPLE VEHICLES USING FEHP REAR AXLE FLUID.

CONTACT ST LOUIS ASSEMBLY PLANT/ST LOUIS VICINITY ONLY.

REAR AXLE NOISE. *TT

BELT SLIPPAGE. *TT

REAR AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNS.

REAR AXLE NOISE. ALSO INCLUDES LINCOLN AVIATOR 2002.

CERTIFIED REAR AXLE AVAILABLE.

GENERATOR NOISE IN COLD AMBIENT TEMPERATURES.

VIBRATION CONDITION. CONTACT REQUEST ST.

GENERATOR WHISTLE/HOOT NOISE IN COLD AMBIENT TEMPERATURES.

DRIVELINE VIBRATION ON DRONE/BOOM AT HIGHWAY SPEEDS.

CHATTER, SHUDDER, A BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNS ON VEHICLES EQUIPPED WITH THE 9.75 INCH OR 8.8 INCH LIMITED SLIP REAR AXLE.

REAR AXLE VIBRATION/DRONE ABOVE 60 MPH.

AXLE WHINE AT CRUISE OR DURING ACCELERATION/ DECELERATION.

EXCESSIVE WHINE NOISE FROM THE REAR AXLE AT CRUISE, OR ON ACCELERATION AND/OR DECELERATION.

A WHINE NOISE ON TIP-IN AT SPEEDS OF 45 TO 65 MPH.

REAR DRIVELINE PING/CREAK/POP NOISE.

AN AUDIBLE CREAK / CLICK / POP (NOT A CLUNK) FROM THE REAR DRIVELINE.

SQUEAKING ACCELERATOR PEDAL WHILE DRIVING DURING COLD, HOT, DUSTY, AND DRY CONDITIONS.

FLUID LEAK FROM THE CONVERTER HOUSING AREA.

SUBJECT REGARDING REAR LIFTGATE APPLIQUE (TRIM PANEL) CRACKS.

SOME VEHICLES MAY EXHIBIT A RATTLE NOISE WHEN CLOSING EITHER THE MIDGATE OR THE REAR LIFTGATE.

CONCERNS WITH SQUEAK AND RATTLE NOISS COMING FROM THE INSTRUMENT PANEL AND FROM THE SIDE DOOR WINDOWS.

SOME VEHICLES MAY EXHIBIT A FLUTTER/TURBULENCE NOISE CONDITION (I.E., HELICOPTER NOISE) AT HIGHWAY SPEEDS WHEN THE REAR...

SOME VEHICLES MAY EXHIBIT THE DRIVERS DOOR UNLOCKING AFTER IT HAS BEEN LOCKED.

SOME VEHICLES MAY DEVELOP YELLOW STAINS ON THE REAR LIFTGATE PAINT, USUALLY NOTICED ON WHITE COLORED VEHICLES.

SOME VEHICLES PRODUCED BEFORE 6/3/2001 MAY EXHIBIT THE MOONROOF OPENING INTERIOR MOLDING COMING LOOSE OR THE SUNSHADE TEARING DURING USE.

SOME VEHICLES MAY EXHIBIT A CONDITION IN WHICH THE REAR DOOR(S) WILL NOT UNLOCK VIA MANUAL OR POWER OPERATION.

SPECIAL SERVICE INSTRUCTIONS FOR THE LIFTGATE GLASS BRACKET INSPECTION AND TORQUE PROCEDURE.

Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns...

Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns...

FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL.

BACKGLASS DIFFICULT TO CLOSE AND AN INTERMITTENT DOOR AJAR LAMP.

AXLE SEAL LEAKS. *EH

ALUMINUM CORROSION - SERVICE TIP.

REAR POWER WINDOW(S) INOPERATIVE.

BROKEN REAR CARGO STORAGE DOOR LIFT HANDLE.

AXLE SEAL LEAKS. LEAKS FROM REAR HALFSHAFT AXLE SEAL.

PAINT-PREMATURE CLEARCOAT CRACKING-SERVICE TIPS.

LIFTGATE GLASS APPLIQUE DAMAGED/CRACKED.

LIFTGATE GLASS BRACKET INSPECTION AND TORQUE PROCEDURE.

BREAKAGE OF A LIFTGATE WINDOW HINGE.

LIFTGATE GLASS APPLIQUE DAMAGED/CRACKED - SERVICE PROCEDURE.

FLUID LEAKS FROM THE REAR HALFSHAFT SEAL.

BACK GLASS HINGE RATTLING/LOOSENESS, GLASS MISALIGNMENT AND/OR GLASS HARD-TO-CLOSE.

SUBJECT REGARDING 5R55W AUTOMATIC TRANSMISSION HARSH UPSHIFTS DURING LIGHT TO MEDIUM THROTTLE CONCERNS.

SOME VEHICLES PRODUCED BEFORE 9/6/2001 EQUIPPED WITH THE 5R55W TRANSMISSION MAY EXHIBIT A TICK NOISE EMANATING FROM THE...

BRAKE SHIFT INTERLOCK.*JB

INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS.

SOME VEHICLES EQUIPPED WITH 5R55W TRANSMISSION MAY EXHIBIT A WHINE NOISE THAT OCCURS IN 3RD GEAR ONLY.

SOME VEHICLES EQUIPPED WITH 5R55W TRANSMISSION MAY EXHIBIT NO TRANSMISSION ENGAGEMENT INTO FORWARD AND / OR REVERSE GEAR.

VEHICLES EQUIPPED WITH THE 5R55W AUTOMATIC TRANSMISSION BUILT PRIOR TO 08/01/2001 MAY EXHIBIT A NEUTRAL OUT CONDITION WHEN COMING TO A STOP.

SOME VEHICLES MAY EXHIBIT A TRANSMISSION SHIFTER STUCK IN THE PARK GEAR POSITION.

SOME VEHICLES BUILT 11/13/2000 THORUGH 3/8/2001 EQUIPPED WITH A 5R55W TRANSMISSION MAY EXHIBIT A TRANSMISSION CONTROL...

SOME 4-DOOR VEHICLES BUILT 11/13/2000 THROUGH 4/2/2001 EQUIPPED WITH THE 5R55W TRANSMISSION MAY EXHIBIT A FLUID LEAK AT...

SOME VEHICLES EQUIPPED WITH 5R55W TRANSMISSION MAY EXHIBIT VARIOUS FIRM AND / OR SOFT SHIFTS.

SOME VEHICLES EQUIPPED WITH 5R55W TRANSMISSION MAY EXHIBIT VARIOUS FIRM AND / OR SOFT SHIFTS.

SOME VEHICLES MAY EXHIBIT A TRANSMISSION SHIFTER STUCK IN THE PARK GEAR POSITION.

SOME VEHICLES BUILT 11/13/2000 THROUGH 3/8/2001 EQUIPPED WITH A 5R55W TRANSMISSION MAY EXHIBIT A TRANSMISSION CONTROL...

A FLUID LEAK AT THE TRANSMISSION COOLER LINE-TO-TRANSMISSION CASE CONNECTION.

SOME VEHICLES MAY EXHIBIT A TINNY RATTLE NOISE COMING FROM THE CENTER STEERING COLUMN AREA WHILE DRIVING OVER BUMPY ROADS.

INFORMATION REGARDING TRANSMISSION OIL LEVEL CHECKING GUIDELINES.

SOME VEHICLES EQUIPPED WITH 5R55W TRANSMISSION MAY EXHIBIT VARIOUS FIRM AND / OR SOFT SHIFTS.

INFORMATION ON VEHICLES EQUIPPED WITH WITH 5R55W TRANSMISSION HAVING A (POWERTRAIN CONTROL MODULE) PCM ADAPTIVE LEARNING...

SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM.

5R55W TRANSMISSION - NO 3RD GEAR OR SLIPPING 2-3 SHIFT - DIAGNOSTIC TROUBLE CODE P0733 AND P0745 - VEHICLES BUILT PRIOR TO 3/4/2002.

GEAR SELECTOR LEVER - INCREASED EFFORT TO SHIFT FROM DRIVE TO PARK.

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK.

REAR 3.55 AXLE NOISE.

NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS.

SOME VEHICLES MAY EXHIBIT EXCESSIVE SULPHUR SMEEL FROM THE EXHAUST UNDER CERTAIN DRIVE MODES.

SOME VEHICLES MAY EXHIBIT FUEL DIAGNOSTIC TROUBLE CODES P0171, P0172, P0174, P0175 OR MASS AIR FLOW DIAGNOSTIC TROUBLE...

INFORMATION ON VEHICLES EXHIBITNG FUEL LINE DAMAGE DUE TO PINCHING/SQUEEZING OF THE FUEL RETURN LINE.

SOME VEHICLES, BUILT PRIOR TO 8/01/2001, MAY EXHIBIT A WHINE OR HOWL NOISE DURING COLD STARTS AT TEMPERATURES BELOW 4 DEGREES C (40 DEGREES F).

FUEL HESITATION WHILE MAKING HARD SWEEPING RIGHT HAND TURNS (SUCH AS A HIGHWAY ON-RAMP)

SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ON WITH EGR SYSTEM RELATED DIAGNOSTIC TROUBLE CODES P0400,...

MALFUNCTION INDICATOR LAMP COMING ON WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0171, P0172, P0174 AND/OR P0175 (FUEL SYSTEM TOO RICH OR LEAN).

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

FUEL GAUGE SLOW TO UPDATE AFTER REFUELING.

EXCESSIVE SULFUR SMELL FROM EXHAUST.

FUEL GAUGE SLOW TO UPDATE.

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP.

INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS.

STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES...

MESSAGE CENTER DISPLAYS COMPUTING FUEL INSTEAD OF DISTANCE TO EMPTY.

FUEL SIGNAL TO INSTRUMENT CLUSTER SERVICE TIP.

STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK...

STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES...

INTERMITTENT FUEL GAUGE LEVEL DROPPING TO EMPTY WHEN FUEL LEVEL IS NOT ACTUALLY EMPTY.

MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC...

INFORMATION USED WHEN REPLACING THE DRIVERS SEAT MODULE.

SOME VEHICLES MAY EXHIBIT UNINTENDED SMART UNLOCK ACTIVATION WITHOUT KEY IN IGNITION.

INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES.

SOME VEHICLES MAY EXHIBIT A BATTERY DRAW AND/OR A DEAD BATTERY CONDITION.

SOME VEHICLES MAY EXHIBIT INTERMITTENT DIFFICULTY TURNING THE IGNITION KEY UPON STARTING.

SOME VEHICLES MAY EXHIBIT EXCESSIVE EFFORTS WHEN TRYING TO INSERT OR REMOVE THE KEY FROM THE IGNITION LOCK.

MALFUNCTION INDICATOR LAMP ON WITH PCM DIAGNOSTIC TROUBLE CODE P0463 AND/OR IC DIAGNOSTIC TROUBLE CODE B1201 - FUEL...

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.

OPEN FUSE F2.20 (5 AMP) AND/OR F2.1 (30 AMP) WHICH MAY RESULT IN LOSS OF FUNCTION OF SEVERAL SYSTEMS INCLUDING POWER...

ELECTRICAL-CENTRAL SECURITY MODULE (CSM) SERVICE TIPS.

CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4.

AN INTERMITTENT OR CONTINUOUS OPEN OF FUSE 1.15.

OPEN F2.20 5 AMP FUSE WHICH MAY RESULT IN LOSS OF FUNCTION OF SEVERAL SYSTEMS INCLUDING POWER SEATS, ADJUSTABLE PEDALS AND POWER DOOR LOCKS.

UNINTENDED DOOR UNLOCKS WITHOUT KEY IN IGNITION (QSF).

BATTERY LIGHT ON OR AN ALTERNATOR THAT IS NOT CHARGING.

4X4 CONTROL MODULE NOT INTERCHANGEABLE ISSUES.

SUBJECT REGARDING THEFT LIGHT RELOCATION.

SUBJECT REGARDING CIGAR LIGHTER REVISED INSTALLATION PROCEDURES.

SOME VEHICLES MAY EXHIBIT A NEED FOR HEADLAMP AIM ADJUST AFTER DRIVING ON ROUGH ROADS.

INOPERATIVE OR INACURRATE SPEEDOMETER, 4X4 LAMP ILLUMINATD, AND / OR DIAGNOSTIC TROUBLE CODE P1635 OR P1639.

INFORMATION REGARDING MALFUNCTION INDICATOR LIGHT ILLUMINATING WITH DIAGNOSTIC TROUBLE CODE P0300/P0301.*YH

INFORMATION REGARDING AUTOLOCK ENABLED/DISABLE PROCEDURE CORRECTION.

MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P1633 AND / OR P1639 WITH NO DRIVEABILITY CONCERN PRESENT.

MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P1633 AND / OR P1639 WITH NO DRIVEABILITY CONCERN PRESENT.

FRONT SEAT(S) SLIGHT MOVEMENT WHEN ACCELERATING AND/OR DECELERATING.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS.

MALFUNCTION INDICATOR LAMP (MIL) ON AND HARD START/LONG CRANK.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND DIAGNOSTIC TROUBLE CODES (DTC'S) P0171, P0172, P0174, OR P0175.

CONCERNS WITH BRAKE VIBRATION, ROUGHNESS AND / OR GRINDING NOISE, AND EXCESSIVE BRAKE ROTOR CORROSION.

SOME VEHICLES MAY EXHIBIT A YELLOW FOUR WHEEL ANTI-LOCK BRAKE (4WABS) LAMP ILLUMINATED AND A DIAGNOSTIC TROUBLE CODE...

SOME VEHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM LIGHT ON WITH DIAGNOSTIC TROUBLE CODE C1230 AND / OR C1237 FROM THE ANTI-LOCK BRAKE SYSTEM.

SOME VEHICLES MAY EXHIBIT AN ERROR INDICATING THAT THERE IS NO COMMUNICATION OR RETURN DIAGNOSTIC TROUBLE CODES (DTC)...

INFORMATION REGARDING TRAILER WIRING - BRAKE CONTROLLER CONNECTOR LOCATION.

ANTI-LOCK BRAKE SYSTEM (ABS) LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODE (DTC) C1235, C1236, C1237 ON VEHICLES WITH...

THE AMBER ANTI-LOCK BRAKE SYSTEM (ABS) WARNING LIGHT ON WITH DIAGNOSTIC TROUBLE CODES C1235, C1236/C1237 STORED IN MEMORY.

ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR LAMP ON WITH CODES C1235 AND C1236 OR C1237.

BLINKING/HALF ILLUMINATED SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AND/OR ANTI-LOCK BRAKE (ABS) WARNING INDICATORS AFTER COLD...

INFORMATION ON POWER STEERING LEAK CONDITION.

SOME VEHICLES EQUIPPED WITH DUAL AUTOMATIC TEMPERATURE CONTROL (DATC) MAY EXHIBIT INOPERATIVE REDUNDANT STEERING WHEEL CONTROLS (RSWC).

SOME 4 DOOR VEHICLES MAY EXHIBIT A STEERING COLUMN RATTLE AT SPEEDS OF 10-20 MPH ON UNEVEN SURFACES.

STIFF STEERING OR POOR STEERING WHEEL RETURNABILITY.

SOME VEHICLES MAY EXHIBIT A SCRUNCH NOISE FROM THE UPPER STEERING COLUMN WHEN MAKING NEAR FULL LOCK TURNS.

STEERING WHEEL SHUDDER DURING LOW-SPEED TURNING MANEUVERS.

SOME VEHICLES MAY EXHIBIT A STEERING WHEEL SHUDDER DURING LOW SPEED TURNING MANEUVERS.

LOW SPEED OR STATIONARY NOISE/VIBRATION AT LOWER STEERING SHAFT AREA WHEN TURNING.

POOR FIT BETWEEN DRIVER AIR BAG AND STEERING WHEEL.

CONCERNS WITH A/C PERFORMANCE TEMP.

SOME VEHICLES MAY EXHIBIT UNEVEN AIR DISCHARGE TEMPERATURES IN A/C COOLING MODES.

SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS.

SOME VEHICLES EQUIPPED WITH THE MANUAL A/C SYSTEM MAY EXHIBIT A CONTINUOUS CLICKING NOISE FROM THE BLEND DOOR ACTUATOR...

LOW OIL PRESSURE INDICATION/WARNING, A/C COMPRESSOR INOPERATIVE AND/OR NO CRANK CONDITION ON 4.6L EQUIPPED VEHICLES.

HIGH SIDE PRESSURE FLUCTUATIONS ON VEHICLES EQUIPPED WITH A FIXED SCROLL A/C COMPRESSOR.

AIR CONDITIONER HOOTING NOISE DURING LIGHT LOAD ACCELERATION AT LOW SPEEDS, FROM 1000-1300 RPM.

AXLE WHINE HOWL SERVICE WITH INDIVIDUAL PARTS INSTEAD OF AN AXLE ASSEMBLY.

REAR AXLE DATE CODE INSPECTION AND SERVICE.

REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS.

NO CRANK CONDITION. SERVICE TIPS.

THROTTLE CABLE ROUTING AND SPLASH SHIELD MODIFICATION WHEN REPLACING THROTTLE CABLE DURING NORMAL SERVICE.

EXHIBITING SQUEAK / CREAK NOISES DURING FRONT SUSPENSION MOVEMENT.

SOME VEHICLES MAY EXHIBIT A NOISY AND / OR LOOSE FRONT WHEEL BEARING.

INFORMATION ON FRONT WHEEL HUB ASSEMBLIES.

NOISE FROM REAR WHEEL HUB BEARINGS.

SOME VEHICLES MAY EXHIBIT DAMAGE TO THE RADIO ANTENNA AFTER RUNNING THROUGH CERTAIN CAR WASHES.

DISTANCE TO EMPTY NOT DISPLAYED.

INSTRUMENT CLUSTER LOCKING UP AND ACCESSORIES SUCH AS THE RADIO, POWER WINDOWS, POWER LOCKS AND MOONROOF INOPERATIVE.

CLUSTER LOCKING UP & VARIOUS ACCESSORIES SUCH AS THE RADIO, POWER WINDOWS, POWER LOCKS AND MOONROOF BEING INOPERATIVE.

UPDATED REAR HALFSHAFT REMOVAL PROCEDURE.

WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS.

STABILITY ASSIST (ADVANCETRAC/IVD) SYSTEMS MAY NOT BE RECALIBRATED PROPERLY USING WDS.

THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT).

OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION - REGARDING REPLACEMENT OF WILDERNESS AT TIRES.

INTERMITTENT AIR BAG WARNING LAMP ON, MEMORY SEAT, AND/OR ADJUSTABLE PEDAL CONCERNS.

ILLUMINATED AIR BAG WARNING LAMP WITH DIAGNOSTIC TROUBLE CODE (DTC) B2292.