2003 Ford Explorer Sport Trac TSBs

ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE.

FRONT AXLE LEAKS FLUID FROM VENT TUBE - VEHICLES EQUIPPED WITH 4X4 OR AWD.

SAFETY BELT RETRACTION SPEED.

4X4 NOT ENGAGING OR INTERMITTENT 4X4 ENGAGEMENT - VEHICLES BUILT PRIOR TO 4/1/2004.

POWER LUMBAR BLADDER EXPANDING THROUGH BACK OF SEAT.

SPEED CONTROL INOPERATIVE OR NOT HOLDING THE SET SPEED.

EQUIPPED WITH A HARD TONNEAU COVER.

NO START/NO COMMUNICATION-CONTACT REQUEST.

LACKS POWER/RUNS ROUGH/BLACK SMOKE CONDITION.

SEAT MATERIAL RIPPING AND/OR SEPARATING AT THE SEAMS.

GENERATOR NOISE IN COLD AMBIENT TEMPERATURES.

SCRAPING NOISE FROM THE RIGHT REAR AXLE AREA USUALLY WHILE TURNING LEFT.

GENERATOR WHISTLE/HOOT NOISE IN COLD AMBIENT TEMPERATURES.

VIBRATION WHEN DRIVING 35-75 MPH.

VIBRATION/MOAN CONDITION WHILE DRIVING AT HIGHWAY SPEEDS (75-80 MPH) ON 4X4 VEHICLES EQUIPPED WITH A 4.10 AXLE RATIO.

FLUID MAY LEAK OUT OF THE FRONT AXLE VENT TUBE.

STEERING SHUDDER DURING LOW SPEED MANEUVERS - 4.0L ENGINE.

FAST IDLE STRATEGY TO PREVENT SPARK PLUG FOULING.

OIL LEAK FROM OIL FILTER ADAPTER - 4.0L SOHC ENGINE BUILT BEFORE 4/1/2004.

NEW TONNEAU COVER LOCK CYLINDER RETAINER CLIPS RELEASED FOR SERVICE.

NOISE-GEAR WHINE NOISE IN 1ST AND 2ND GEAR ONLY-VEHICLES EQUIPPED WITH 5R55E TRANSMISSION AND 4.0L ENGINE ONLY.

ROUGH IDLE, HESITATION ON COLD ENGINE TIP-IN AND/OR HESITATION DURING A 5-3 DOWNSHIFT.

INTERMITTENT ENGINE DRIVEABILITY ISSUES.

MULTIPLE VEHICLES WITH 3.0L OR 4.0L ENGINES LACKS POWER/RUNS ROUGH/BLACK SMOKE.

ROUGH IDLE AND/OR CHECK ENGINE LAMP DUE TO CLOSURE HOSE WHICH BECOMES LOOSE OR DISCONNECTED AT THE RIGHT HAND CAM COVER.

IDLE AIR CONTROL (IAC) VALVE DIAGNOSTIC SERVICE TIPS.

INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER,...

MALFUNCTION INDICATOR LAMP COMING ON WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0171, P0172, P0174 AND/OR P0175 (FUEL SYSTEM TOO RICH OR LEAN).

EMISSIONS RECALL 03E05: EVAPORATIVE EMISSIONS CANISTER FRESH AIR INLET HOSE CONNECTOR REPLACEMENT.*MR

MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A...

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK...

SLOW FUEL FILL CONDITION ON CERTAIN VEHICLES BUILT AFTER 3/3/02.

EXCESSIVE FUEL GAUGE FLUCTUATION WHILE DRIVING (QSF).

REVISED PROCEDURE FOR ADJUSTING ALIGNMENT ON ALL SUSPENSIONS - NEW RIGHT HAND UPPER CONTROL ARM DESIGN FOR TORSION BAR FRONT SUSPENSIONS.

SQUEAKING NOISE FROM REAR SWAY BAR LINK.

REAR LEAF SPRING NOISE.

SQUEAK NOISE FROM THE REAR STABILIZER BAR LINK.

VARIOUS NOISE ISSUES FROM THE REAR LEAF SPRINGS WHILE DRIVING.

DIAGNOSTIC TROUBLE CODE (DTC) C1233 & C1234 - REPLACE ANTI-LOCK BRAKE SYSTEM EUC.

REAR BRAKE ROTOR RUBS ON BACKING PLATE / CONTACT REQUEST.

SQUEALING NOISE FROM THE FRONT BRAKES WHEN APPLIED.

SQUEALING NOISE FROM THE FRONT BRAKES WHEN THE BRAKES ARE APPLIED.

PAINT PEELING AND/OR BUBBLING ON THE CENTER FINISH PANEL OF THE INSTRUMENT PANEL.

WATER LEAK NEAR THE ROOF OPENING PANEL.

POWER REAR WINDOW BOUNCES BACK OPEN WHEN CLOSING.

TAILGATE LOCKING BY ITSELF WHEN SLAMMED SHUT OR WHEN THE VEHICLE IS BEING DRIVEN OVER ROUGH ROADS.

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.

GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES.

NO START, NO COMMUNICATION WITH POWER TRAIN CONTROL MODULE (PCM) USING WDS/NGS OR A MISS/BUCK/JERK WHILE DRIVING.

SAFETY BELT WEB STOP BUTTON SERVICE.

BED EXTENDER COMPONENT REPLACEMENT SERVICE TIP.

REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS.

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK.

WEAR-THROUGH CONDITION ON THE ABRASION SLEEVE OF THE UPPER RADIATOR HOSE NEAR THE AIR CONDITIONING ACCUMULATOR OR TRANSMISSION FLUID DIPSTICK.

NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS.

STEERING SHUDDER FELT WHEN TURNING, DRIVING AT SLOW SPEEDS OR AT STOP.

CLICKING/POPPING NOISE FROM UPPER STEERING COLUMN AREA WHEN TURNING.

STEERING WHEEL SHUDDER DURING LOW SPEED TURNING MANEUVERS.

MOAN/VIBRATION DURING AIR CONDITIONING OPERATION.

LACK OF AIR CONDITIONER COOLING.

IRREGULAR TIRE WEAR. *SC

LACKS POWER / BLACK SMOKE / RUNS ROUGH, USUALLY WITH NO MALFUNCTION INDICATOR LAMP ON OR DIAGNOSTIC TROUBLE CODES.