2001 Ford Expedition TSBs

WHITE FLAKES COMING FROM THE AIR CONDITIONER VENTS WHEN THE BLOWER MOTOR IS ENGAGED.

SOME 5.4L WINDSOR POWER IMPROVED ENGINES MAY EXHIBIT A SLIGHT OIL LEAK OR WEEP AT THE CYLINDER HEAD TO BLOCK JOINT.

SOME VEHICLES EQUIPPED WITH A 4.6L ROMEO ENGINE MAY EXHIBIT A SLIGHT OIL LEAK OR WEEP AT THE CYLINDER HEAD TO BLOCK JOINT.

SOME VEHICLES EQUIPPED WITH THE 5.4L 2V ENGINE MAY EXHIBIT A WHISTLING NOISE FROMTHE FORMED NYLON TUBE INTHE IDLE-AIR BYPASS FLOW CIRCUIT.

SUBJECT REGARDING IDLER ARM REPLACEMENT SPECIFICATIONS.

CONCERNS WITH VEHICLES WITH A 5.4L 2V ENGINE EXHIBITINGNG A LACK OF POWER CONDITION.

SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED).

CONCERNS WITH WHITE FLAKES COMING FROM THE AIR CONDITIONER VENTS WHEN THE BLOWER MOTOR IS ENGAGED.

ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE.

SOME VEHICLES MAY EXHIBIT A WEAK HORN CHIRP CONFIRMATION WHEN THE TRANSMITTER IS USED TO LOCK THE DOORS AND/OR AN...

SUBJECT REGARDING EXAGGERATED ENGINE BRAKING ON DECELERATION.

SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED).

SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA.

SOME VEHICLES MAY EXHIBIT A WEAK HORN CHIRP CONFIRMATION WHEN THE KEY FOB IS USED, OR AN INOPERATIVE HORN WHEN THE ENGINE IS NOT RUNNING.

SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174.

SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY...

A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTER...

SOME VEHICLES MAY EXHIBIT A VIBRATION AT IDLE AND/OR ENGINE DROANING NOISE ON ACCELERATION FROM A STOP.

SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL.

SOME VEHICLES MAY EXHIBIT THE ENGINE OIL SENDING UNIT CONTACTING THE OIL DRIP SHIELD ATTACHED TO THE FRONT AXLE.

SUBJECT REGARDING CERTAIN VEHICLES WITH 4.6L ROMEO ENGINES EXHIBITING AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA.

ENGINEERING IS INVESTIGATING VEHICLES RECEIVED FROM THE ASSEMBLY PLANT WITH THE CHECK AIR SUSPENSION LAMP REMAINING...

SOME VEHICLES EQUIPPED WITH 4.6L ROMEO ENGINE MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA.

INFORMATION ON IDLE VIBRATION OR ENGINE DROAN ON ACCELERATION.

INFORMATION REGARDING POWER STEERING PUMP BOLT-CORRECT PLACEMENT OF BOLTS AND WASHER-WINDSOR BUILT ENGINES.

SUBJECT REGARDING HIGH IDLE AND/OR CHECK ENGINE LIGHT CONDITION.

SOME VEHICLES MAY EXHIBIT A ROUGH IDLE CONDITION AS RECEIVED DIRECTLY FROM THE ASSEMLY PLANT.

SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT...

WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING.

USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE.

INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW.

ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS.

DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT...

ENGINE-LIGHT TICK OR RATTLE TYPE NOISE FROM ENGINE AFTER COLD START.

ENGINE-CYLINDER HEAD DECK LEAK-4.6 AND 5.4L ENGINES-NEW SERVICE-ONLY GASKET AND CYLINDER HEAD KITS AVAILABILITY.

ENGINE-ROMEO BUILT 4.6L 2V-TICK NOISE FROM ENGINE-ENGINES BUILT BEFORE 9/17/2003.

STEERING IDLER ARM NOISE.

BROKEN EXHAUST MANIFOLD STUDS.

ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED...

SOME VEHICLES, EQUIPPED WITH THE 4.6L 2V ENGINE, WITH AN ENGINE BUILD DATE PRIOR TO 8/29/03 MAY EXHIBIT AN ENGINE TICK...

FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV).

SUBJECT REGARDING DRIVELINE ANGLE-RELATED VIBRATION AT VARIOUS SPEEDS AND LOAD CONDITIONS.

SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS.

EXHIBITING LACK OF POWER CONDITION WHEN VEHICLE IS OPERATED IN AMBIENT TEMPERATURES.

CONCERNS WITH THE LOWER POWER IN HIGH AMBIENT TEMEPRATURES.

SOME VEHICLES MAY EXHIBIT A CONDITION WHERE ALL THE GUAGES INTHE INSTRUMENT CLUSTER WILL SWEEP AT INITIAL START UP.

CUSTOMERS MAY COMPLAIN OF WIND NOISE.

SOME VEHICLES MAY EXHIBIT A WEAK SOUNDING HORN CHIRP.

SOME VEHICLES MAY EXHIBIT A DRIVELINE VIBRATION AT SPEEDS BETWEEN 60-70 MPH.

CONCERNS WITH VEHICLES EXHIBITING THE OIL PRESSURE GAUGE REGISTERING LOW OR NO OIL PRESSURE USUALLY ON INITIAL START-UP...

VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK.

SOME VEHICLES MAY EXHIBIT HOLES, TEARS, SNAGS OR CRACKS ON THE SEAT UPHOLSTERY.

SUBJECT REGARDING OUTER BELT MOLDING FINISH CHANGE.

INFORMATION ON THE REAR SEAT ENTERTAINMENT SYSTEM (RSE) ACCESSORIES KIT.

INFORMATION REGARDING HORN CHIRP WITH FUNCTION OF SPEED CONTROL BUTTONS.

INFORMATION ON SQUEAK AND RATTLE NOISE CONDITIONS.

REAR AXLE NOISE REPAIR.

REAR AXLE NOISE REPAIR.

SAFETY BELT RETRACTION SPEED.

SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES P0740,...

SOME VEHICLES WITH ELECTRONIC SHIFT-ON-THE FLY MAY EXHIBIT AN INADVERTENT 4X4 LOW ENGAGEMENT WHILE DRIVING.

SOME VEHICLES EQUIPPED WITH A 4R100 TRANSMISSION AND BUILT BETWEEN JANUARY 1, 2001 AND MAY 1, 2002 MAY EXHIBIT FLASHING...

CONCERNS WITH POP/CLUNK/CLICK NOISE FROM THE FRONT SUSPENSION WHEN MAKING LOW-SPEED TURNS IN FORWARD OR REVERSE GEARS.

CONCERNS WITH A POP/CLUNK/CLICK NOISE COMING FROM THE FRONT SUSPENSION WHEN MAKING LOW-SPEED TURNS IN FORWARD OR REVERSE GEARS.

BRAKE SHIFT INTERLOCK.*JB

INFORMATION REGARDING EXTERNAL TRANSMISSION COOLER DISCONNECT TOOL.

INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS.

EXHIBITING AN UNCOMMANDED SHIFT WHEEL LOW DURING LOW SPEED MANEUVERING.

SOME VEHICLES EQUIPPED WITH A 4R70W AUTOMATIC TRANSMISSION EXHIBITING A NO FORWARD OR A DELAYED ENGAGEMENT MAY HAVE A DAMAGED FORWARD CLUTCH.

SOME VEHICLES MAY EXHIBIT INADVERTENT 4X4 HI OR LOW SHIFT EVENTS, 4X4 AND / OR LOW RANGE INDICATOR FLASHING OR SOLID OR...

SOME VEHICLES EQUIPPED WITH A 4R70W AUTOMATIC TRANSMISSION MAY EXHIBIT A CLUNK NOISE DURING THE 2-1 DOWNSHIFT EVENT.

SOME VEHICLES EQUIPPED WITH 4R100 TRANSMISSION, HAVING A TRANSMISSION BUILD DATE BETWEEN 7/27/2000 AND 3/23/2001, MAY...

OWNER NOTIFICATION PROGRAM PARTS UPDATE REGARDING 4R100 TRANSMISSION REPLACEMENT.

OWNER NOTIFICATION INFORMING OWNERS THAT THEIR TRANSMISSION COULD BE DAMAGED INTERNALLY AND, POTENTIALLY, COULD RESULT...

SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM.

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK.

NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS.

SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION AND/OR PREMATURE SHUTOFF OF THE GAS PUMP WHEN THE VEHICLE IS BEING REFUELED.

SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION AND/OR PREMATURE SHUTOFF OF THE GAS PUMP WHEN THE VEHICLE IS BEING RE-FUELED.

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP.

INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS.

STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES...

FUEL SIGNAL TO INSTRUMENT CLUSTER SERVICE TIP.

STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK...

STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES...

MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC...

SOME VEHICLES MAY EXHIBIT WHEELS THAT SEIZE TO THE HUBS AND ARE DIFFICULT TO REMOVE DURING SERVICE.

SOME VEHICLES WITH AIR SUSPENSION MAY EXHIBIT AN INITIAL OR REPEAT COMPRESSOR DRYER FAILURE.

SOME VEHICLES EQUIPPED WITH AIR SUSPENSION MAY EXHIBIT AN AIR LEAK AND/OR OVERNIGHT BLEED DOWN OF THE AIR SUSPENSION.

SOME VEHICLES MAY EXHIBIT AIR SUSPENSION MALFUNCTION.

SOME VEHICLES MAY EXHIBIT A POP/CLUNK/CLICK NOISE FROM THE FRONT SUSPENSION WHEN MAKING LOW SPEED TURNS IN EITHER FORWARD OR REVERSE.

SUBJECT REGARDING AIR SUSPENSION COMPRESSOR QUALITY.

SOME VEHICLES MAY EXHIBIT A CHECK SUSPENSION LAMP ON WITH DIAGNOSTIC TROUBLE CODES B2140 OR C2140 EVEN AFTER THE AIR...

SUBJECT PERTAINING TO AIR SUSPENSION LEAKS.

AIR SUSPENSION COMPRESSOR NOISE.

REPEAT AIR SUSPENSION COMPRESSOR DRIER FAILURES.

REPEAT AIR SUSPENSION COMPRESSOR DRIER FAILURES.

CONCERNS WITH SPEED BODY BOOM.

SOME VEHICLES MAY EXHIBIT AN AXLE TUBE SEAL LEAKAGE AND AN AXLE BEARING THAT IS LOOSE IN THE AXLE HOUSING, AND/OR A...

INFORMATION REGARDING POP/THUMP NOISE FROM POWER WINDOW.

CERTAIN SUPERCREWS AND SOME VEHICLES MAY EXHIBIT A WIND NOISE / BOOM WHEN DRIVEN AT HIGH SPEEDS ABOVE 55 MPH WITH THE...

This article supersedes TSB 19-2026 to update the vehicle model years affected.

Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns...

Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns...

ALUMINUM CORROSION - SERVICE TIP.

POP/THUMP NOISE AT END OF WINDOW MOVEMENT AND/OR DRIVER'S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION.

INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES.

SOME VEHICLES NOT EQUIPPED WITH SIDE AIR BAGS MAY EXHIBIT DIAGNOSTIC TROUBLE CODE B1998 (PASSENGER SIDE AIR BAG CIRCUIT...

INFORMATION DFPE SENSOR LOCATION.

THIS BULLETIN STATES THAT ON SOME VEHICLES (INCLUDING 2002 BLACKWOOD) A BATTERY DISCONNECT OR PARAMETER RESET IS...

SOME VEHICLES NOT EQUIPPED WITH SIDE AIR BAGS, MAY EXHIBIT A DIAGNOSTIC TROUBLE CODE (DTC) B1998 (PASSENGER SIDE AIR BAG...

CONCERNS WITH DRIVER SEAT MODULE - NGS / WDS SPECIAL INSTRUCTIONS.

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.

COURTESY RAIL LAMPS DO NOT OPERATE CORRECTLY OR CAUSE A BATTERY DRAW.

CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4.

SOME VEHICLES EQUIPPED WITH 4 WHEEL DRIVE MAY EXHIBIT A NOTCHY OR STICKING FEELING IN SLOW SPEED TURNS WITH NO EFFECT ON...

SOME VEHICLES BUILT AFTER 4/10/2001 AND EQUIPPED WITH AIR SUSPENSION , MAY EXHIBIT AN ELECTRONIC VARIABLE ORIFICE (EVO)...

SOME VEHICLES BUILT AFTER 04/10/01, EQUIPPED WITH AIR SUSPENSION, MAY EXHIBIT A ELECTRONIC VARIABLE ORIFICE (EVO)...

INFORMATION ON DISCONTINUATION OF ELECTRONIC VARIABLE ORIFICE (EVO) STEERING.

CUSTOMER MAINTENANCE REMINDER - LITERATURE PROGRAM 04L19 - TIE ROD INSPECTION PROCEDURE.

TIE ROD END INSPECTION PROCEDURE.

TIE ROD END INSPECTION PROCEDURE.

TIE ROD END INSPECTION PROCEDURE.

SOME 4X2 VEHICLES EQUIPPED WITH P275/60/R17 CONTINENTAL-GENERAL TIRES MAY EXHIBIT A HIGHWAY SPEED TIRE VIBRATION.

SOME 4X2 VEHICLES EQUIPPED WITH P275/60/R17 CONTINENTAL GENERAL TIRES MAY EXHIBIT A HIGHWAY SPEED TIRE VIBRATION.

OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION - REGARDING REPLACEMENT OF WILDERNESS AT TIRES.

SOME VEHICLES MAY EXHIBIT A DIFFICULT TO REMOVE WHEEL RIM CONDITION.

SOME VEHICLES EQUIPPED WITH CONTINENTAL / GENERAL P275 / 60R17 TIRES MAY EXHIBIT A TIRE VIBRATION.

CORRECT LUG NUT TORQUE SPECIFICATIONS - INCREASE WHEEL NUT AND STUD SIZE - SERVICE TIP.

CONCERNS WITH CLIMATE CONTROL SYSTEM AIR DISCHARGED THROUGH THE DEFROSTER DUCTS ONLY, REGARDLESS OF SETTING.

SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS.

CONDITIONS ON CLIMATE CONTROL SYSTEM AIR FLOWS THROUGH DEFROST ONLY.

CLIMATE CONTROL A/C SERVICE TECH TIPS.

CONCERNS THAT THE ANTI-LOCK BRAKE SYSTEM (ABS) LAMP IS ON WITH DIAGNOSTIC TROUBLE CODES C1230, C1229, OR C1237.

SOME VEHICLES MAY EXHIBIT AMBER ANTI-LOCK BRAKE SYSTEM (ABS) LAMP ON WITH UNDEFINED DIAGNOSTIC TROUBLE CODES (DTCS) STORED.

VEHICLES WITH KEYLESS ENTRY PAD MAY EXHIBIT DEAD BATTERY, NO START, INTERIOR LAMP/HEADLAMP SELF-ACTIVATION, OR INOPERATIVE KEYLESS ENTRY PAD.

INOPERATIVE OR INACURRATE SPEEDOMETER, 4X4 LAMP ILLUMINATD, AND / OR DIAGNOSTIC TROUBLE CODE P1635 OR P1639.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS.

SEAT BELT WARNING SYSTEM - BELT REMINDER FUNCTION, OPERATION AND SERVICE TIPS.

AIRBAG WARNING LAMP ON WITH DIAGNOSTIC TROUBLE CODE (DTC) B1994/B1998 ON VEHICLES WITHOUT SIDE AIR BAGS.

INFORMATION ON RADIO OPERATION WITH REAR SEAT ENTERTAINMENT SYSTEM.

WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS.

REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS.