1999 Ford Expedition TSBs

SOME 5.4L WINDSOR POWER IMPROVED ENGINES MAY EXHIBIT A SLIGHT OIL LEAK OR WEEP AT THE CYLINDER HEAD TO BLOCK JOINT.

SOME VEHICLES EQUIPPED WITH THE 5.4L 2V ENGINE MAY EXHIBIT A WHISTLING NOISE FROMTHE FORMED NYLON TUBE INTHE IDLE-AIR BYPASS FLOW CIRCUIT.

SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED).

ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE.

SUBJECT REGARDING EXAGGERATED ENGINE BRAKING ON DECELERATION.

SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED).

SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA.

SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174.

SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY...

A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTE...

SOME VEHICLES EQUIPPED WITH THE ROMEO BUILT 4.6L 2V ENGINE MAY EXHIBIT AN ENGINE OIL LEAK OR OIL WEEPAGE FROM THE...

SOME VEHICLES MAY EXHIBIT A VIBRATION AT IDLE AND/OR ENGINE DROANING NOISE ON ACCELERATION FROM A STOP.

ON SOME VEHICLES THERE MAY BE AN OIL LEAK FROM THE RIGHT HAND HEAD GASKET AT THE REAR OF THE BLOCK / HEAD JOINT.

SOME VEHICLES EQUPPED WITH A 5.4L OR 6.8L ENGINE MAY EXHIBIT A ROLLING / ROUGH IDLE.

A CONDITION MAY EXIST WHERE THE MALFUNCTION INDICATOR LAMP IS ON WITH DIAGNOSTIC TROUBLE CODE P0340 (CAMSHAFT POSITION...

SOME VEHICLES BUILT 7/1998 TO 6/1999 EQUIPPED WITH A 4.6 / 5.4L WINSOR BUILT ENGINES MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAT GASKET AREA.

SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL.

SOME VEHICLES MAY EXHIBIT THE ENGINE OIL SENDING UNIT CONTACTING THE OIL DRIP SHIELD ATTACHED TO THE FRONT AXLE.

SUBJECT REGARDING CERTAIN VEHICLES WITH 4.6L ROMEO ENGINES EXHIBITING AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA.

SOME VEHICLES EQUIPPED WITH 4.6L ROMEO ENGINE MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA.

INFORMATION ON IDLE VIBRATION OR ENGINE DROAN ON ACCELERATION.

THIS BULLETIN ADDRESSES CONCERNS A NOISE AT INTIAL ENGINE STARTUP WHEN COLD FROM THE ACCESSORY DRIVE BELT.

SUBJECT REGARDING HIGH IDLE AND/OR CHECK ENGINE LIGHT CONDITION.

SOME VEHICLES EQUIPPED WITH A 4.6L, 5.4L, OR 6.8L ENGINE MAY EXHIBIT A ROUGH IDLE / MISS AFTER START-UP IN COLD AMBIENT TEMPERATURES.

SOME VEHICLES WITH THE 5.4L ENGINE MAY EXHIBIT DIFFICULTY ENGAGING INTO AND OUT OF 4X4 LOW, WHILE COLD.

INFORMATION ON VEHICLES EXHIBITING COLD ENGINE KNOCK.

INFORMATION ON VEHICLES WITH THE 5.4L ENGINE EXHIBITING DIFFICULTY ENGAGING INTO AND OUT OF 4X4 LOW.

SOME VEHICLES EQUIPPED WITH 5.4L ENGINES MAY EXHIBIT A COLD START ENGINE KNOCK CONCERN UNTIL WARMED UP.

SUBJECT REGARDING A/C VACUUM RESERVOIR / CHECK VALVE LOCATION FOR THE AIR CONDITIONING SYSTEM.

SOME VEHICLES EQUIPPED WITH A 4.6L ENGINE MAY EXHIBIT A HESITATION / STUMBLE AFTER INITIAL VEHICLE START-UP DURING...

COLD START ENGINE NOISE

SOME VEHICLES EQUIPPED WITH THE 5.4L ENGINE MAY EXHIBIT DIFFICULTY ENGAGING INTO AND OUT OF 4X4 LOW, WHILE COLD.

SOME VEHICLES EQUIPPED WITH 4.6L OR 6.8L ENGINES MAY EXHIBIT A COLD START ENGINE NOISE UNTIL WARMED UP.

SOME VEHICLES WITH THE 5.4 L ENGINE MAY EXHIBIT DIFFICULTY ENGAGING INTO AND OUT OF 4 X 4 LOW, WHILE COLD.

EXHIBITING A CHECK ENGINE LIGHT ON AND POSSIBLE DIAGNOSTIC TROUBLE CODES P0715, P0716, P0717, P0718, P1901 (TURBINE...

SOME VEHICLES BUILT 7/1998 TO 6/1999 EQUIPPED WITH A 4.6 / 5.4L WINDSOR BUILT ENGINES MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA.

SOME VEHICLES WITH 4.6L, OR 6.8L ENGINES MAY EXHIBIT A ROLLER FINGER FOLLOWER COMING OFF DURING ENGINE CRANKING IN COLD...

VEHICLES EQUIPPED WITH ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) , MAY EXERIENCE THE BLOWER MOTOR STAYING ON HIGH...

SOME VEHICLES BUILT 7/1998 TO 6/1999 EQUIPPED WITH A 4.6 / 5.4L WINDSOR BUILT ENGINE MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA.

SOME VEHICLES EQUIPPED WITH THE 5.4L ENGINE, 4R100 TRANSMISSION AND AN AUXILIARY TRANSMISSION OIL COOLER MAY EXHIBIT A COASTDOWN MOAN CONCERN.

SUBJECT REGARDING AIR CONDITIONER VACUUM RESERVOIR / CHECK VALVE LOCATION.

SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP.

SOME VEHICLES MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP.

EXHIBITING A HESITATION / STUMBLE AFTER INITIAL VEHICLE START-UP DURING ACCELERATOR TIP-IN, WITH A COLD ENGINE.

SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP.

SOME VEHICLES MAY EXHIBIT A IDLE VIBRATION.

SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT...

VEHICLES EQUIPPED WITH WINDSOR ENGINES ONLY MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP.

EXPERIENCING ENGINE KNOCK AT INITIAL COLD STARTUP.

VEHICLES EQUIPPED WITH THE 5.4L ENGINE, 4R100 TRANSMISSION AND AN AUXILIARY TRANSMISSION OIL COOLER MAY EXHIBIT A COASTDOWN MOAN CONCERN.

CONCERNS WITH A HARD TO TURN IGNITION KEY AND / OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER.

SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP.

SOME VEHICLES BUILT AFTER 2/1/1999 EQUIPPED WITH 5.4L-2V ENGINES AND 4R100 TRANSMISSIONS MAY EXHIBIT A DRIVELINE CLUNK /...

SOME VEHICLES MAY EXPERIENCE AN IDLE VIBRATION.

SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT...

EXPERIENCING A ENGINE KNOCK AT COLD START-UP.

FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS.

FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR.

SOME VEHICLES EQUIPPED WITH THE 5.4L ENGINE, 4R100 TRANSMISSION AN AUXILIARY TRANSMISSION OIL COOLER MAY EXHIBIT A COASTDOWN MOANING NOISE.

FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS.

SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT...

WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING.

USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE.

INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW.

ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS.

DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT...

ENGINE-LIGHT TICK OR RATTLE TYPE NOISE FROM ENGINE AFTER COLD START.

ENGINE-CYLINDER HEAD DECK LEAK-4.6 AND 5.4L ENGINES-NEW SERVICE-ONLY GASKET AND CYLINDER HEAD KITS AVAILABILITY.

BROKEN EXHAUST MANIFOLD STUDS.

ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED...

FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV).

SUBJECT REGARDING DRIVELINE ANGLE-RELATED VIBRATION AT VARIOUS SPEEDS AND LOAD CONDITIONS.

SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS.

EXHIBITING LACK OF POWER CONDITION WHEN VEHICLE IS OPERATED IN AMBIENT TEMPERATURES.

SOME VEHICLES BUILT BEFORE JUNE 8, 2000 AND EQUIPPED WITH A4WD MAY EXHIBIT A HIGH-SPEED MOAN OR DRIVELINE PULSATION/SHUDDER.

CONCERNS WITH THE LOWER POWER IN HIGH AMBIENT TEMEPRATURES.

SOME VEHICLES MAY EXHIBIT A CONDITION WHERE ALL THE GUAGES INTHE INSTRUMENT CLUSTER WILL SWEEP AT INITIAL START UP.

SOME VEHICLES MAY EXHIBIT A DRIVELINE VIBRATION AT SPEEDS BETWEEN 60-70 MPH.

CONCERNS WITH VEHICLES EXHIBITING THE OIL PRESSURE GAUGE REGISTERING LOW OR NO OIL PRESSURE USUALLY ON INITIAL START-UP...

VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK.

SOME VEHICLES MAY EXHIBIT HESITATION ON ACCELERATION OR WHILE TURNING.

INFORMATION ON SQUEAK AND RATTLE NOISE CONDITIONS.

SOME VEHICLES MAY EXHIBIT A REAR WIPER THAT DOES NOT FUNCTION PROPERLY (JAMMED).

SOME VEHICLES MAY REQUIRE TECHNICAL ASSISTANCE FOR SPEEDOMETER ACCURACY CONCERNS.

SOME VEHICLES MAY REQUIRE TECHNICAL ASSISTANCE FOR SPEEDOMETER ACCURACY CONCERNS.

SOME VEHICLES MAY EXHIBIT A REAR WIPER THAT DOES NOT FUNCTION PROPERLY (JAMMED).

INFORMATION ON THE ALIVE MEMORY (DAM) FEATURE DURING VARIOUS DIAGNOSTIC AND REPAIR PROCEDURES.

REAR WIPER ARM INSTALLATION.

EXHIBITING A DELAYED OPERATION / INOPERATIVE INSTRUMENT CLUSTER WITH KOEO OR KOER.

SOME VEHICLES MAY EXHIBIT A DELAYED OPERATION / INOPERATIVE INSTRUMENT CLUSTER WITH KOEO OR KOER.

INFORMATION REGARDING ERRACTIC REMOTE ENTRY FUNCTIONS-NEW GEM RELEASED.

CONCERNS WITH A CHATTERING NOISE FROM THE REAR AXLE HEARD WHEN TURNING OR CORNERNING.

INFORMATION REGARDING MULTIFUNCTION SWITCH REPLACEMENT.

EFFECTIVE NOVEMBER 2, 1998 CERTAIN VEHICLES OF THE 4R100 ARE ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM.

SOME VEHICLES MAY REQUIRE THE KEEP ALIVE MEMORY (KAM) TO BE RESET DURING VARIOUS DIAGNOSTIC AND REPAIR PROCEDURES.

INFORMATION REGARDING VEHICLES MODELS OF THE 4R100 THAT ARE ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM.

THIS BULLETIN MENTIONS THAT THE INSTRUCTIONS FOR THE OPERATION OF THE KEYLESS ENTRY SYSTEM FOR CERTAIN VEHICLES WERE OMITTED FROM THE OWNERS GUIDE.

CONCERNS WITH ERRATIC REMOTE ENTRY FUNCTIONS.

SOME VEHICLES MAY EXHIBIT A FRONT WASHER OPERATING WITHOUT COMMAND.

VEHICLES EQUIPPED WITH LIMITED SLIP/TRACTION-LOK REAR AXLES MAY EXHIBIT A CHATTER NOISE WHILE TURNING.

SOME VEHICLES EQUIPPED WITH A4WD MAY EXHIBIT A DRIVELINE PULSATON / SHUDDER VIBRATION UNDER LOW SPEED ACCELERATION IN A STRAIGHT LINE.

SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE.

SOME VEHICLES MAY EXHIBIT A VIBRATION/MOAN AT HIGHWAY SPEEDS.

SUBJECT REGARDING THE SERVICING OF TRAILER HITCHES ON VEHICLES.

DIAGNOSTIC INFORMATION FOR COMPACT DISC PLAYER PROBLEMS.

SERVICING TRAILER HITCH.

SOME VEHICLES MAY EXHIBIT A FRONT WASHER OPERATING WITHOUT COMMAND.

INFORMATION REGARDING THE REVISED TOWING SPECIFICATIONS.

SOME VEHICLES MAY EXHIBIT A CD CHANGER WITH A CD MAGAZINE THAT JAMS / WILL NOT EJECT.

SOME VEHICLES MAY EXHIBIT A CD CHANGER WITH A CD MAGAZINE THAT JAMS / WILL NOT EJECT.

SOME 4X4S MAY EXHIBIT A SHUDDER / VIBRATION UNDER ACCELERATION IN A STRAIGHT LINE FROM A STOP.

SUBJECT REGARDING VEHICLES EXHIBITING A SHUDDER / VIBRATION UNDER ACCELERATION IN A STRAIGHT LINE FROM A STOP.

(CONTINUED FROM 13251 AND 13252) UNCOMMANDED FRONT WIPER FUNCTION.

INFORMATION REGARDING THE WINNERS OF THE EDSR OF THE MONTH QUALITY AWARDS FOR THE MONTH OF AUGUST.

VEHICLES BUILT THROUGH 1/10/1999 MAY EXHIBIT VIBRATION FELT THROUGH THE ACCELERATOR PEDAL.

SUBJECT REGARDING FRONT WIPERS OPERATING WHILE SWITCH IS IN OFF POSITION.

INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA.

SOME 4X4 VEHICLES BUILT WITH CENTER DISCONNECT FRONT AXLES MAY EXHIBIT A MOANING NOISE FROM THE FRONT DIFFERENTIAL WHILE OPERATING IN 4X2 MODE.

INFORMATION ON PROCEDURES TO FOLLOW WHEN INSTALLING A REAR WIPER ARM.

ADDRESSING CONCERNS OF A LOW SPEED (UNDER 35 MPH) CLICKING NOISE CAUSED BY A CAGE NUT ROCKING ON THE COTTER PIN FOR THE FRONT AXLE HALF SHAFT SPINDLE.

EXPERIENCING A DRIVELINE CLUNK / JERK DURING TIP-IN.

INFORMATION ON RESETTING THE PASSIVE ANTI-THEFT SYSTEM (PATS).

CONCERNS WITH FRONT DIFFERENTIAL NOISE.

EXPERIENCING FRONT DIFFERENTIAL NOISE.

SOME VEHICLES MAY EXHIBIT ACTIVATION OF FRONT WIPERS WITHOUT COMMAND.

EXPERIENCING FRONT WIPERS ACTIVATION WITHOUT COMMAND.

SOME VEHICLES MAY EXPERIENCE A DRIVELINE CLUNK / JERK DURING TIP-IN.

EXPERIENCING VIBRATION IN THE ACCELERATOR PEDAL ON SOME VEHICLES.

INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS.

VEHICLES MAY EXHIBIT A HIGH SPEED DRIVELINE VIBRATION.

INFORMATION ON DIAGNOSING PASSIVE ANTI-THEFT SYSTEM (PATS) ISSUES.

CONCERNS WITH THE POWER SEAT CONTROL BUTTON ( KNOB ) MAY DETACH FROM THE SWITCH ACTUATOR.

WHEN INSTALLING A REAR WIPER ARM ON SOME VEHICLES, BE SURE TO FOLLOW THE PROCEDURE IN THE 1999 WORKSHOP MANUAL SECTION 501-16-92.

REAR AXLE NOISE REPAIR.

REAR AXLE NOISE REPAIR.

SOME VEHICLES WITH ELECTRONIC SHIFT-ON-THE FLY MAY EXHIBIT AN INADVERTENT 4X4 LOW ENGAGEMENT WHILE DRIVING.

CONCERNS WITH POP/CLUNK/CLICK NOISE FROM THE FRONT SUSPENSION WHEN MAKING LOW-SPEED TURNS IN FORWARD OR REVERSE GEARS.

CONCERNS WITH A POP/CLUNK/CLICK NOISE COMING FROM THE FRONT SUSPENSION WHEN MAKING LOW-SPEED TURNS IN FORWARD OR REVERSE GEARS.

BRAKE SHIFT INTERLOCK.*JB

INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS.

EXHIBITING AN UNCOMMANDED SHIFT WHEEL LOW DURING LOW SPEED MANEUVERING.

SOME VEHICLES MAY EXHIBIT INADVERTENT 4X4 HI OR LOW SHIFT EVENTS, 4X4 AND / OR LOW RANGE INDICATOR FLASHING OR SOLID OR...

SOME VEHICLES EQUIPPED WITH A 4R70W AUTOMATIC TRANSMISSION MAY EXHIBIT A CLUNK NOISE DURING THE 2-1 DOWNSHIFT EVENT.

SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM.

SOME VEHICLES EQUIPPED WITH 4R100 TRANSMISSION MAY EXHIBIT A DIAGNOSTIC TROUBLE CODE P1744 (TORQUE CONVERTER CLUTCH SLIPPAGE DETECTED).

SOME VEHICLES EQUIPPED WITH 4R100 TRANSMISSION MAY EXHIBIT A DIAGNOSTIC TROUBLE CODE (DTC) P1744 (TORQUE CONVERTER CLUTCH SLIPPAGE DETECTED).

SOME VEHICLES WITH 4R100 TRANSMISSION MAY EXHIBIT A FLASHING TCIL WITH DIAGNOSTIC TROUBLE CODE (DTC) 1728 IN MEMORY.DTC...

ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR...

SOME VEHICLES EQUIPPED WITH 4R100 TRANSMISSION MAY EXHIBIT A FLASHING TCIL WITH DIAGNOSTIC TROUBLE CODE 1728 IN MEMORY.

INFORMATION REGARDING THE 1999 SCHEDULED MAINTENANCE GUIDE FOR ANY LIGHT TRUCK, SPORT UTILITY OR VAN EQUIPPED WITH A...

SOME VEHICLES WITH 4R70W TRANSMISSIONS BUILT FROM 4/16/98 THROUGH 10/30/98 MAY EXHIBIT A LEAK FROM THE VENT AREA OF THE TRANSMISSION.

SOME VEHICLES EQUIPPED WITH 4R100 TRANSMISSION MAY EXHIBIT A FLASHING TCIL WITH DIAGNOSTIC TROUBLE CODE DTC 1728 IN MEMORY.

VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN...

INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP.

INFORMATION REGARDING E40D/4R100 TRANSMISSION FLUID COOLER FLOW TEST SPECIFICATION.

INFORMATION REGARDING TRANSMISSION TROUBLE CODES.

SUBJECT REGARDING E40D / 4R100 TRANSMISSION FLUID COOLER FLOW TEST SPECIFICATION.

SUBJECT REGARDING INTERMITTENT TRANSMISSION CONTROL INDICATOR LAMP OR MALFUNCTION INDICATOR LAMP ILLUMINATION.

SOME VEHICLES MAY EXHIBIT AN INTERMITTENT TRANSMISSION CONTROL INDICATOR LAMP OR MALFUNCTION INDICATOR LAMP ILLUMINATION.

VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT,...

THE 4R100 TRANSMISSION WILL HAVE AN ORANGE "PRIOR TO REPAIR" TAG ON THE FLUID PAN.

INFORMATION REGARDING NEW SERVICE STEERING GEAR.

NEW SERVICE STEERING GEAR.

CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR.

SUBJECT ON NEW HIGHER EFFORT STEERING GEARS.

VEHICLE EXHIBITING DIAGNOSTIC TROUBLE CODE P1744 (TORQUE CONVERTER CLUTCH SLIPPAGE).

CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR.

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK.

NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS.

INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES.

SOME VEHICLES MAY EXHIBIT COURTESY RAIL LAMPS ABOVE THE 2ND ROW SEATS THAT DO NOT OPERATE PROPERLY OR CAUSE A BATTERY DRAW.

INOPERATIVE OR INACCURATE SPEEDOMETER AS WELL AS 4X4 LIGHT INOPERATIVE AND / OR DIAGNOSTIC TROUBLE CODE P1635 AND / OR...

THIS BULLETIN STATES THAT ON SOME VEHICLES (INCLUDING 2002 BLACKWOOD) A BATTERY DISCONNECT OR PARAMETER RESET IS...

INOPERATIVE OR INACCURATE SPEEDOMETER, 4X4 LAMP ILLUMINATED AND / OR DIAGNOSTIC TROUBLE CODES (DTCS) P1635 OR P1639...

FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST...

SUBJECT REGARDING THE NAGATIVE BATTERY TERMINAL COVER ON SOME VEHICLES.

CERTAIN VEHICLES MAY EXHIBIT AN INOPERATIVE SPEEDOMETER AND DIAGNOSTIC TROUBLE CODE P1635 AFTER A PECM HAS BEEN REPLACED.

SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA.

SOME VEHICLES MAY EXHIBIT AN INOPERATIVE SPEEDOMETER AND DTC P1635 AFTER A PCM HAS BEEN REPLACED.

ALL VEHICLES MAY EXHIBIT AN INOPERATIVE OR INACCURATE SPEEDOMETER, 4X4 LIGHT INOPERATIVE AND/OR DTC P1635 AFTER A PCM HAS BEEN REPLACED.

SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC...

SUBJECT REGARDING MEGA FUSE BRACKET COVER.

SUBJECT REGARDING ALL VEHICLES REQUIRES A PARAMETER RESET TO BE PERFORMED ON THE PASSIVE ANTI-THEFT SYSTEM MODULE (PATS...

INFORMATION ON REPLACING AND REMOVING THE GENERIC ELECTRONIC MODULE (GEM).

INFORMATION ON REMOVING AND / OR REPLACING THE GENERIC ELECTRONIC MODULE (GEM).

INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS.

SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES.

THIS ONLINE BULLETIN MENTIONS THAT VEHICLES BUILT ON OR AFTER 6/25/99 NO LONGER ARE EQUIPPED WITH A MEGA FUSE BRACKET COVER (XL34-14A099-F).

INFORMATION ON USING THE SERVICE BAY TECHNICAL SYSTEM (SBTS) AND NEW GENERATION STAR (NGS) TESTER, AND TO UPDATE THE...

EXHIBITING MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTC(S) PO351 AND / OR P0356 (COIL PRIMARY CIRCUIT MALFUNCTION).

INFORMATION ON SETTING COMPASS MODULE AT PRE-DELIVERY.

INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS).

MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP.

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.

COURTESY RAIL LAMPS DO NOT OPERATE CORRECTLY OR CAUSE A BATTERY DRAW.

CONCERNS WITH SPEED BODY BOOM.

INFORMATION REGARDING POP/THUMP NOISE FROM POWER WINDOW.

CONCERNS WITH THE SIGNAL MIRROR REFLECTIVE SURFACE DETERIORATING OVER TIME, DEVELOPING DARK SPOTS DUE TO CHROME PLATING DELAMINATION.

INFORMATION ON VEHICLES EQUIPPED WITH SIGNAL MIRRORS.

INFORMATION ON VEHICLES EQUIPPED WITH SIGNAL MIRRORS.

SOME VEHICLES MAY EXHIBIT A BODY BOOM WHILE DRIVING HIGHWAY SPEEDS.

CONCERNS WITH VEHICLES EXHIBITING A WINDSHIELD CREAK / SQUEAK.

SOME VEHICLES MAY EXHIBIT INTERIOR LIGHTS, POWER WINDOWS AND / OR INOPERATIVE RUNNING BOARD LIGHTS FOR A SHORT PERIOD OF TIME IN THE MORNING.

EXHIBITING JERKY OR UNEVEN WINDSHIELD WIPER ARM MOVEMENT.

ON SOME VEHICLES THE FRONT BUMPERS MAY EXHIBIT RED STAINING (SPOTS) ON THE BUMER WING ENDS.

BRIEF INFORMATION DESCRIBING EXTERIOR REAR VIEW MIRROR DIAGNOSIS.

EXPERIENCING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA.

ON SOME VEHICLES, THE FRONT WINDSHIELD WIPERS MAY OPERATE WHILE THE MULTIFUNCTION SWITCH IS IN THE OFF POSITION.

INFORMATION PERTAINING TO CONDITIONS WITH RED STAINING (SPOTS) ON THE FRONT BUMPER WING ENDS.

SOME VEHICLES MAY EXHIBIT AN EXTERIOR REAR VIEW MIRROR WITH A SLIGHT FLUTTER / SHAKE.

THIS ONLINE SERVICE BULLETIN INVOLVES VEHICLES EXHIBITING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA.

SOME VEHICLES MAY EXHIBIT VIBRATION, SHIMMY AND BODY BOOM AT SPEEDS ABOVE 72 KM/H (45 MPH).

INFORMATION ON USING 1999 PROCEDURES MANUAL FOR SIDE MIRROR REPLACEMENT.

EXHIBITING FRONT WINDSHIELD WIPER ACTIVATION WITHOUT COMMAND.

SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP.

SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF,...

POP/THUMP NOISE AT END OF WINDOW MOVEMENT AND/OR DRIVER'S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION.

SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION AND/OR PREMATURE SHUTOFF OF THE GAS PUMP WHEN THE VEHICLE IS BEING REFUELED.

SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION AND/OR PREMATURE SHUTOFF OF THE GAS PUMP WHEN THE VEHICLE IS BEING RE-FUELED.

SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION.

EXHIBITING A CRACKLING / POPPING NOISE FROM THE EXHAUST.

VEHICLES WITH OHV/SOHC, 5.0L 4.6L, 5.4L MAY EXHIBIT A (MIL) ON WITH EVAP SYSTEM DTC'S P1450,PO455,PO466.

SOME VEHICLES BUILT BETWEEN 11/1/97 AND 12/8/99 MAY EXHIBIT A CRACKLING/POPPING NOISE FROM THE EXHAUST.

SOME VEHICLES MAY EXHIBIT A CRACKLING/POPPING NOISE FROM THE EXHAUST, VEHICLES BUILT BETWEEN 11/1/97 AND 12/8/99.

A PRODUCTION CHANGE WAS PUT INTO EFFECT THAT DISCONTINUED THE INSTANTANEOUS FUEL ECONOMY DISPLAY.

SOME OWNERS MAY REPORT SLOW FUEL GAUGE RESPONSE TIME DURING RE-FUELING.

PRODUCTION CHANGE WAS PUT INTO EFFECT THAT DISCONTINUED THE INSTANTANEOUS FUEL ECONOMY DISPLAY.

EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP.

EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM.

CONCERNS OF BREAKAGE OF THE EXHAUST SYSTEM BETWEEN THE MUFFLER AND TAILPIPE MAY OCCUR ON SOME VEHICLES.

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK...

SOME VEHICLES MAY EXHIBIT WHEELS THAT SEIZE TO THE HUBS AND ARE DIFFICULT TO REMOVE DURING SERVICE.

SOME VEHICLES WITH AIR SUSPENSION MAY EXHIBIT AN INITIAL OR REPEAT COMPRESSOR DRYER FAILURE.

SOME VEHICLES EQUIPPED WITH AIR SUSPENSION MAY EXHIBIT AN AIR LEAK AND/OR OVERNIGHT BLEED DOWN OF THE AIR SUSPENSION.

SOME VEHICLES MAY EXHIBIT AIR SUSPENSION MALFUNCTION.

SOME VEHICLES MAY EXHIBIT A POP/CLUNK/CLICK NOISE FROM THE FRONT SUSPENSION WHEN MAKING LOW SPEED TURNS IN EITHER FORWARD OR REVERSE.

SUBJECT REGARDING AIR SUSPENSION COMPRESSOR QUALITY.

SOME VEHICLES MAY EXHIBIT A CHECK SUSPENSION LAMP ON WITH DIAGNOSTIC TROUBLE CODES B2140 OR C2140 EVEN AFTER THE AIR...

SUBJECT PERTAINING TO AIR SUSPENSION LEAKS.

EXPEDITION AND NAVIGATORS EQUIPPED WITH FOUR WHEEL AIR SUSPENSION MAY REQUIRE A RIDE HEIGHT ADJUSTMENT PROCEDURE BE...

SOME VEHICLES EQUIPPED WITH FOUR WHEEL AIR SUSPENSION MAY REQUIRE A RIDE HEIGHT ADJUSTMENT PROCEDURE BE PERFORMED BEFORE SETTING ALIGNMENT.

SUBJECT REGARDING VEHICLES WITH FOUR WHEEL AIR SUSPENSION MAY REQUIRE A RIDE HEIGHT ADJUSTMENT PROCEDURE PERFORMED BEFORE SETTING ALIGNMENT.

SOME VEHICLES EQUIPPED WITH AIR SUSPENSION MAY EXHIBIT AN INTERMITTENT CHECK SUSPENSION LAMP ON AND DIAGNOSTIC TROUBLE...

AIR SUSPENSION COMPRESSOR NOISE.

REPEAT AIR SUSPENSION COMPRESSOR DRIER FAILURES.

REPEAT AIR SUSPENSION COMPRESSOR DRIER FAILURES.

SOME VEHICLES MAY EXHIBIT AMBER ANTI-LOCK BRAKE SYSTEM (ABS) LAMP ON WITH UNDEFINED DIAGNOSTIC TROUBLE CODES (DTCS) STORED.

THIS BULLETIN MENTIONS THAT FOR ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE...

INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT.

SOME VEHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR LAMP ON WITH NO DIAGNOSTIC TROUBLE CODES (DTC) DETECTED.

SOME VHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR LAMP WITH NO DIAGNOSTIC TROUBLE CODES (DTC).

SUBJECT REGARDING ABS ELECTRONIC MODULE NOW AVAILABLE FOR SERVICE.

VEHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR LAMP WITH NO DIAGNOSTIC TROUBLE CODE (DTC) DETECTED.

SUBJECT REGARDING ANTI-LOCK BRAKE LAMP ILLUMINATION, INCREASED BREAK PEDAL EFFORT AND / OR FALSE ANTI-LOCK BRAKE SYSTEM (ABS) CYCLING AT LOW SPEEDS.

VEHICLES EXPERIENCING INCREASED BRAKE PEDAL EFFORT AND / OR FALSE ABS CYCLING AT LOW SPEEDS, OR ABS LAMP ILLUMINATION.

VEHICLES WITH KEYLESS ENTRY PAD MAY EXHIBIT DEAD BATTERY, NO START, INTERIOR LAMP/HEADLAMP SELF-ACTIVATION, OR INOPERATIVE KEYLESS ENTRY PAD.

SOME VEHICLES MAY EXHIBIT AN INOPERATIVE COURTESY, GLOVE COMPARTMENT, UNDERHOOD, RUNNING BOARD LAMPS, POWER WINDOWS,...

CONCERNS WITH COURTESY, GLOVE COMPARTMENT, UNDERHOOD, RUNNING BOARD LAMPS; POWER WINDOWS; RADIO; AND REAR WIPER ALL...

INFORMATION FOR COMPACT DISC PLAYER PROBLEMS, RADIO MAY DISPLAY NO DJ- NO DUSC OR CD WILL NOT EJECT.

INFORMATION REGARDING VEHICLES THAT EXPERIENCE THE RADIOS THAT DISPLAY NO DJ-NO DISC OR CD WILL NOT EJECT.

INFORMATION REGARDING AMBIENT TEMPERTURE DISPLAY STRATEGY.

SUBJECT REGARDING COWL LEAF SCREEN CHANGE.

SUBJECT REGARDING COWL LEAF SCREEN CHANGE.

SOME VEHICLES EQUIPPED WITH A DUAL MEDIA (AM / FM / CASSETTE / CD) OR AM / FM CASSETTE RADIO MAY EXHIBIT AN INTERMITTENT OR INOPERATIVE REAR SPEAKER.

CONCERNS WITH CLIMATE CONTROL SYSTEM AIR DISCHARGED THROUGH THE DEFROSTER DUCTS ONLY, REGARDLESS OF SETTING.

SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS.

CONDITIONS ON CLIMATE CONTROL SYSTEM AIR FLOWS THROUGH DEFROST ONLY.

VEHICLES MAY EXPERIENCE AIR CONDITIONING INACCURATE AMBIENT TEMPERATURE DISPLAYED- VEHICLES EQUIPPED WITH EATC-...

INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS.

SOME VEHICLES MAY EXHIBIT A WHISTLING NOISE WHILE DRIVING WITH A/C IN THE OFF POSITION AT SPEEDS ABOVE 64 KM/H (40 MPH).

CLIMATE CONTROL A/C SERVICE TECH TIPS.

SOME 4X2 VEHICLES EQUIPPED WITH P275/60/R17 CONTINENTAL-GENERAL TIRES MAY EXHIBIT A HIGHWAY SPEED TIRE VIBRATION.

SOME 4X2 VEHICLES EQUIPPED WITH P275/60/R17 CONTINENTAL GENERAL TIRES MAY EXHIBIT A HIGHWAY SPEED TIRE VIBRATION.

OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION - REGARDING REPLACEMENT OF WILDERNESS AT TIRES.

SOME VEHICLES MAY EXHIBIT A DIFFICULT TO REMOVE WHEEL RIM CONDITION.

SUBJECT REGARDING ALIGNMENT INFORMATION.

SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING...

SOME VEHICLES EQUIPPED WITH 4 WHEEL DRIVE MAY EXHIBIT A NOTCHY OR STICKING FEELING IN SLOW SPEED TURNS WITH NO EFFECT ON...

CUSTOMER MAINTENANCE REMINDER - LITERATURE PROGRAM 04L19 - TIE ROD INSPECTION PROCEDURE.

TIE ROD END INSPECTION PROCEDURE.

TIE ROD END INSPECTION PROCEDURE.

TIE ROD END INSPECTION PROCEDURE.

EXHIBITING AN INACCURATE COMPASS READINGS IF NOT SET AT PRE-DELIVERY INSPECTION (PDI).

SOME VEHICLES MAY EXHIBIT INACCURATE COMPASS READINGS IF NOT SET AT PRE-DELIVERY INSPECTION (PDI).

REMOTE OIL FILTER ADAPTOR REPLACEMENT - NEW SERVICE PART.

REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS.

INOPERATIVE OR INACURRATE SPEEDOMETER, 4X4 LAMP ILLUMINATD, AND / OR DIAGNOSTIC TROUBLE CODE P1635 OR P1639.

SUBJECT REGARDING INOPERATIVE RUNNING BOARD LIGHTS.*YD

INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND...

BRIEF INFORMATION STATING THAT CERTAIN VEHICLES ARE EQUIPPED WITH A NEW HYBRID ELECTRONIC INSTRUMENT CLUSTER (HEC).