1997 Ford Expedition TSBs

THIS BULLETIN STATES THAT SOME 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER OR LARGER KNOCK SENSOR THREADED HOLD THAN...

SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED).

ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE.

SUBJECT REGARDING EXAGGERATED ENGINE BRAKING ON DECELERATION.

SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED).

SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA.

SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174.

A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTER...

SOME VEHICLES MAY EXHIBIT A VIBRATION AT IDLE AND/OR ENGINE DROANING NOISE ON ACCELERATION FROM A STOP.

SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL.

INFORMATION ON IDLE VIBRATION OR ENGINE DROAN ON ACCELERATION.

THIS BULLETIN ADDRESSES CONCERNS A NOISE AT INTIAL ENGINE STARTUP WHEN COLD FROM THE ACCESSORY DRIVE BELT.

SUBJECT REGARDING HIGH IDLE AND/OR CHECK ENGINE LIGHT CONDITION.

SOME VEHICLES EQUIPPED WITH A 4.6L, 5.4L, OR 6.8L ENGINE MAY EXHIBIT A ROUGH IDLE / MISS AFTER START-UP IN COLD AMBIENT TEMPERATURES.

INFORMATION ON VEHICLES EXHIBITING COLD ENGINE KNOCK.

FOR CERTAIN VEHICLES THE OCTANE SHORTING BAR LOCATED ON THE PASSENGER SIDE OF ENGINE COMPARTMENT NEAR THE BULKHEAD IS...

SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN.

SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW.

SOME VEHICLES EQUIPPED WITH 5.4L ENGINES MAY EXHIBIT A COLD START ENGINE KNOCK CONCERN UNTIL WARMED UP.

INFORMATION ON SETTING THE CHECK ENGINE LIGHT AND SETTING DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK).

THIS BULLETIN STATES THAT FOR CERTAIN VEHICLES IT IS NOT POSSIBLE TO SET THE CHECK ENGINE LIGHT AND SET DIAGNOSTIC...

MALFUNCTION INDICATOR LAMP ON, WITH P0300 - P0308 MISFIRE DIAGNOSTIC TROUBLE CODES WITH A 4.6L ENGINE.

SUBJECT REGARDING A/C VACUUM RESERVOIR / CHECK VALVE LOCATION FOR THE AIR CONDITIONING SYSTEM.

SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES.

COLD START ENGINE NOISE

SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN.

INFORMATION CONCERNING THE OCTANE SHORTING BAR LOCATED ON THE PASSENGER SIDE OF ENGINE COMPARTMENT NEAR THE BULKHEAD IS...

SUBJECT REGARDING IDLE VIBRATION (REPEAT MESSAGE).

EXPERIENCING COLD ENGINE KNOCK (REPEAT / REVISED MESSAGE).

SOME VEHICLES EQUIPPED WITH 4.6L OR 6.8L ENGINES MAY EXHIBIT A COLD START ENGINE NOISE UNTIL WARMED UP.

SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES.

VEHICLES EQUIPPED WITH ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) , MAY EXERIENCE THE BLOWER MOTOR STAYING ON HIGH...

SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES.

SUBJECT REGARDING AIR CONDITIONER VACUUM RESERVOIR / CHECK VALVE LOCATION.

SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP.

VEHICLES WITH 2.4L, 4.6L, AND 5.4L ENGINES MAY EXHIBIT AN A/C MOAN AT IDLE.

SOME VEHICLES MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP.

SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP.

SOME VEHICLES MAY EXHIBIT A IDLE VIBRATION.

SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT...

VEHICLES EQUIPPED WITH WINDSOR ENGINES ONLY MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP.

EXPERIENCING ENGINE KNOCK AT INITIAL COLD STARTUP.

EMISSION RECALL FOR VEHICLES THAT WERE BUILT WITH A FUEL FILLER-VALVE WHICH COULD LEAK WHILE THE VEHICLE IS BEING...

SOME ENGINES MAY EXHIBIT OIL LEAKAGE.

CONCERNS WITH A HARD TO TURN IGNITION KEY AND / OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER.

OWNER NOTIFICATION FOR REPLACEMENT OF ENGINE CYLINDER HEADS.

COLD ENGINE KNOCK 5.4L ACTION.

SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP.

SOME VEHICLES MAY EXPERIENCE AN IDLE VIBRATION.

SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT...

EXPERIENCING A ENGINE KNOCK AT COLD START-UP.

FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS.

FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR.

BRIEF INFORMATION REGARDING CYLINDER HEAD TEMPERATURE (CHT) AND FAIL SAFE COOLING.

FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS.

DURING HIGH IDLE SPEEDS THROTTLE STICKS AFTER STEADY STATE DRIVING IN COLD AMBIENT TEMPERATURES.

CONCERNS OF ENGINE CHECKLIGHT ON AND DTC P1506 ( IDLE AIR CONTROL OVER SPEED ERROR ) AND/OR FAST IDLE.

SOME MOTOR HOME VEHICLES EQUIPPED WITH E4OD TRANSMISSIONS MAY EXPERIENCE HYDRAULIC SYSTEM MALFUNCTIONS AFTER REPLACING THE TRANSMISSION CASE.

SYMPTOMS REGARDING P0300-P0308 MISFIRE DTCS WITH 4.6L ENGINES.

CONCERNS WITH HESITATION, STUMBLE, SURGE, MISS, ROUGH IDLE, STALL AT IDLE.

VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS.

ENGINE- CHECKING ENGINE OIL LEVEL IN OWNER'S GUIDE INCORRECT.

STEERING COLUMN- HIGH SPEED VIBRATION- 4X2 VEHICLES EQUIPPED WITH 5.4L ENGINE.

CHECK ENGINE LIGHT - DTC P0446 - CHECK FOR MOLD FLASHING IN THE 90 DEGREE ELBOW EVAP LINE CONMING OUT OF THE CANNISTER.

ILLUMINATION OF THE CHECK ENGINE LIGHT.

TRANSMISSION- E4OD- COOLER BYPASS VALVE SERVICE DURING TRANSMISSION OVERHAUL- SERVICE TIP.

VEHICLES WITH A ROUGH RUNNING/MISS SYMPTOM WITH A MISFIRE DTC ON A PARTICULAR CYLINDER WHERE NORMAL DIAGNOSIS DOES NOT...

ILLUMINATION OF CHECK ENGINE LIGHT WITH DTC P0446 MAY BE DUE TO CONTAMINATED CANNISTER, EVAP LINES OR VENT SOLENOID.

ENGINEERING IS LOOKING FOR MORE DEFINITION OF VIBRATION CONCERNS ON 4X2 VEHICLES.

CHECK ENGINE LIGHT ON WITH DTC P0455 IN CONTINUOUS MEMORY ON VEHICLE APPLICATIONS.

CHECK ENGINE LIGHT ON WITH DTC P0455 IN CONTINUOUS MEMORY ON 1997 5.4L VEHICLE APPLICATIONS.

ENGINE OVERHEATING- WATER PUMP CONCERN DUE TO FREE SPINNING WATER PUMP IMPELLER.

RUNS ROUGH - MALFUNCTION INDICATOR LAMP (MIL) ON - DIAGNOSTIC TROUBLE CODES (DTCS) P0300 THROUGH P0308 STORED IN MEMORY...

VEHICLES MAY HAVE BEEN BUILT WITH A 240 SECOND MISFIRE DELAY.

ENGINEERING IS INVESTIGATING DEALERSHIP CONCERNS WITH FOULED OR CRACKED SPARK PLUGS.

CERTAIN 1997 VEHCILES MAY HAVE BEEN BUILT WITH THE 240 SECOND MISFIRE DELAY.

IMPROPER RTV APPLICATION AT THE FRONT/REAR LOWER INTAKE MANIFOLD END SEALS & SIDE GASKETS MAY CAUSE AN OIL/COOLANT LEAK.

FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES.

CONCERNS OF CHECK ENGINE LIGHT 'ON'.

CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES.

SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT...

WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING.

USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE.

ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS.

DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT...

BROKEN EXHAUST MANIFOLD STUDS.

ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED...

FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV).

SUBJECT REGARDING DRIVELINE ANGLE-RELATED VIBRATION AT VARIOUS SPEEDS AND LOAD CONDITIONS.

SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS.

SOME VEHICLES MAY EXHIBIT A DRIVELINE VIBRATION AT SPEEDS BETWEEN 60-70 MPH.

VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK.

SOME VEHICLES MAY EXHIBIT HESITATION ON ACCELERATION OR WHILE TURNING.

SOME VEHICLES MAY EXHIBIT A REAR WIPER THAT DOES NOT FUNCTION PROPERLY (JAMMED).

SOME VEHICLES MAY EXHIBIT A REAR WIPER THAT DOES NOT FUNCTION PROPERLY (JAMMED).

INFORMATION ON VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH.

REAR WIPER ARM INSTALLATION.

BRIEF INFORMATION ON VEHICLES EXHIBIT VIBRATION AT CRUISE OVER 50 MPH.

SOME VEHICLES MAY EXHIBIT REAR AXLE NOISE.

SUBJECT REGARDING VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH.

SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE.

SUBJECT REGARDING THE SERVICING OF TRAILER HITCHES ON VEHICLES.

DIAGNOSTIC INFORMATION FOR COMPACT DISC PLAYER PROBLEMS.

SERVICING TRAILER HITCH.

INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA.

SOME 4X4 VEHICLES BUILT WITH CENTER DISCONNECT FRONT AXLES MAY EXHIBIT A MOANING NOISE FROM THE FRONT DIFFERENTIAL WHILE OPERATING IN 4X2 MODE.

INFORMATION ON PROGRAMMING / DIAGNOSING ANY PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES.

INFORMATION REGARDING PROGRAMMING / DIAGNOSING PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES.

CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS.

SOME 1997-1998 EXPLORER/MOUNTAINEER/EXPEDITION OR NAVIGATOR VEHICLES WITH 4-WD 4X4 SYSTEM MAY EXHIBIT BOTH

INFORMATION ON PROCEDURES TO FOLLOW WHEN INSTALLING A REAR WIPER ARM.

VIBRATION AT CRUISE OVER 50 MPH.

ADDRESSING CONCERNS OF A LOW SPEED (UNDER 35 MPH) CLICKING NOISE CAUSED BY A CAGE NUT ROCKING ON THE COTTER PIN FOR THE FRONT AXLE HALF SHAFT SPINDLE.

EXHIBITING A VIBRATION THAT MAY BE INTERPRETED AS AN NVH CONDITION.

CONCERNS WITH FRONT DIFFERENTIAL NOISE.

EXPERIENCING FRONT DIFFERENTIAL NOISE.

INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS.

VEHICLES MAY EXHIBIT A HIGH SPEED DRIVELINE VIBRATION.

INFORMATION ON REPLACING MULTIFUNCTION SWITCH.

INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT.

CONCERNS WITH THE POWER SEAT CONTROL BUTTON ( KNOB ) MAY DETACH FROM THE SWITCH ACTUATOR.

WHEN INSTALLING A REAR WIPER ARM ON SOME VEHICLES, BE SURE TO FOLLOW THE PROCEDURE IN THE 1999 WORKSHOP MANUAL SECTION 501-16-92.

CONCERNS OF SQUEAKY / NOISY PITMAN ARM.

SOME VEHICLES MAY EXHIBIT A LOW SPEED ( UNDER 35MPH ) CLICKING NOISE.

VEHICLES WITH THE E4OD ARE ADDED TO THE FQR ( FORD QUALITY RENEWAL ) ASSEMBLY PROGRAM.

BRIEF INFORMATION GIVING THE CORRECT PART NUMBER FOR TSB 98-3-12.

EXPERIENCING VIBRATION AT CRUISE OVER 50 MPH.

SUBJECT REGARDING COLD AIR FELT ON THE FLOOR WHILE IN HEAT MODE.

COLD AIR MAY BE FELT ON THE FLOOR WHILE IN HEAT MODE ON SOME VEHICLES.

SOME COMPONENTS OF THE FRAME MAY REQUIRE SERVICING DUE TO COLLISION DAMAGE.

REPAIRS TO VINYL COVERED SURFACES.

CONCERNS WITH "SQUEAKING" AND/OR "RATTLING" NOISES MAY OCCUR DURING DIFFERENT DRIVING CHARACTERISTICS AND FROM VARYING POINTS ON THE VEHICLE.

NEWLY DESIGNED VOLUME KNOB, INCORPORATING A MOMENTARY ON/OFF SWITCH.

REQUEST FOR INFORMATION ON CONCERNS OF LEATHER SEAT COVERS WRINKLING, FOLDING,LEATHER WEAR OR CRACKING.

INSTRUCTIONS ON HOW TO ENABLE AND DISABLE THE AUTO LOCK FEATURE.

VEHICLES BUILT BEFORE 4/11/97 MAY EXPERIENCE A RATTLE OR CLUNK.

VEHICLES BUILT BEFORE 3/24/97 MAY EXPERIENCE WIND NOISE AT THE A-PILLAR.

INSTRUCTIONS FOR ENABLING/DISABLING THE AUTOMATIC LOCK FEATURE.

RESETTING OF THE TRIPCOMPUTER ON EXPEDITION & NAVIGATOR WHERE THE INFORMATION IS NOT CONTAINED IN THE OWNERS GUIDE.

INOPERATIVE CD CHANGER MAY BE DUE TO LOOSE 66 PIN CONNECTOR.

INSTRUCTIONS FOR RESETTING THE TRIP COMPUTER.

FRONT DRIVE AXLE FLUID LEAK.

PASSIVE ANTI-THEFT SYSTEM.

IF 4X4 FRONT AXLE IS LEAKING THROUGH THE VENT TUBE, ORDER THE NEW FRONT AXLE TUBE ASSEMBLY FROM THE NATIONAL PARTS DEPOT.

LOOKING FOR MORE DEFINITION OF VIBRATION CONCERNS ON 4X2 VEHICLES.

SOME 5.4L FRONT END SERPETNTINE BELTS MAY MAKE SOME NOISE BETWEEN TEMPERATURES FO 30 F-50 F.

FRONT DRIVE AXLE FLUID LEAK.

DRIVELINE RATTLE OVER BUMPS.

OVERHEATING ON 4.6/5.4L VEHICLES MAY BE CAUSED BY POSSIBLE WATER PUMP CONCERN DUE TO FREE SPINNING WATER PUMP IMPELLER.

FRONT DRIVE AXLE FLUID LEAK.

FEAD BELT SQUEAL, COLD ONLY.

4X4 FRONT AXLE IS LEAKING THROUGH THE VENT TUBE.

DRIVELINE RATTLE OVER BUMPS.

4X4 FRONT AXLE LEAKING THROUGH VENT TUBE.

FEAD BELT SQUEAL, COLD ONLY.

CONCERN FOR VEHICLES EXHIBITING LEAN CODES P0171 & P0174 (VACUUM LEAK).

REVISED SWITCH BEZEL IS AVAILABLE THAT WILL MINIMIZE CARGO CONTACT W/ THE SWITCH.

PROCEDURE FOR RESOLVING THE CONCERN OF WATER ENTRY INTO THE TRANSFER CASE.

INFORMATION ON REPLACING THE COMPASS ASSY FOR ERRATIC/NON-OPERATION.

INFORMATION WHEN ELECTRONIC/HYDRAULIC CONTROL UNIT (EHCU) MALFUNCTIONS.

VEHICLES MAY EXPERIENCE FLUID LEAKS OUT OF THE FRONT AXLE VENT TUBE.

REAR AXLE NOISE REPAIR.

REAR AXLE NOISE REPAIR.

BRAKE SHIFT INTERLOCK.*JB

INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS.

SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM.

ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR...

WHEN DIAGNOSING CRANK / NO START ON CERTAIN VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT (PATS) CHECK THE CUSTOMERS KEY...

SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW.

INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP.

TRANSMISSION FLUID LEAKS AT RADIATOR.

TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART.

INFORMATION REGARDING TRANSMISSION TROUBLE CODES.

VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT,...

CONCERNS WITH CODES P0500, P0503, P1501 OR P1503 WHICH MAY BE CAUSED MY A LOOSE SPEEDOMETER DRIVE GEAR.

INFORMATION REGARDING NEW SERVICE STEERING GEAR.

CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR.

CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK.

EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY...

SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,...

CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR.

SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728.

INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART.

SOME VEHICLES MAY STALL WHEN THE TRANSMISSION IS PLACED INTO GEAR.

A NEW DESIGN TRANSMISSION CASE AND EXTENSION HOUSING HAS BEEN RELEASED.

LOSS OF SOME ACCESSORIES SUCH AS DRIVER'S POWER WINDOW FUNCTION WHEN THE TRANSMISSION IS SHIFTED OUT OF PARK OR NEUTRAL.

SERVICING TIP - TRANSMISSION - THERE ARE TWO DIFFERENT SIZE DIRECT CLUTCH STEEL PLATES WHEN SERVICING 4R44E OR 5R55E TRANSMISSIONS.

FLUID- TRANSMISSION FLUID USAGE CHARTS.

INOPERATIVE OR ERRATIC CRUISE CONTROL OPERATION ALONG WITH HARSH TRANSMISSION SHIFTS.

SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET.

VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET.

SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET.

TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP.

TRANSMISSION - E40D - REVISED DESIGN FORWARD PLANET THRUST WASHER - SERVICE TIP.

TRANSMISSION - E40D - 4R70W - 4R44E - 5R55E - NEW DIGITAL TRANSMISSION RANGE SENSOR - DIAGNOSIS SERVICE TIP.

TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP.

E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM.

4X4 VEHICLES MAY EXHIBIT A GRINDING NOISE WHILE SHIFTING INTO 4L.

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK.

NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS.

CONCERNS WITH SPEED BODY BOOM.

INFORMATION REGARDING POP/THUMP NOISE FROM POWER WINDOW.

SOME VEHICLES MAY EXHIBIT WATER IN THE TRANSFER CASE, THIS COULD CAUSE LOW RANGE 4X4 LAMP TO ILLUMINATE, SHORT OF...

SOME VEHICLES MAY EXHIBIT A BODY BOOM WHILE DRIVING HIGHWAY SPEEDS.

CONCERNS WITH VEHICLES EXHIBITING A WINDSHIELD CREAK / SQUEAK.

ON SOME VEHICLES THE FRONT BUMPERS MAY EXHIBIT RED STAINING (SPOTS) ON THE BUMER WING ENDS.

EXPERIENCING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA.

ON SOME VEHICLES, THE DOOR TRIM PANELS MAY HAVE LOOSE OR BROKEN PULL HANDLES.

INFORMATION PERTAINING TO CONDITIONS WITH RED STAINING (SPOTS) ON THE FRONT BUMPER WING ENDS.

THIS ONLINE SERVICE BULLETIN INVOLVES VEHICLES EXHIBITING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA.

SOME VEHICLES MAY EXHIBIT VIBRATION, SHIMMY AND BODY BOOM AT SPEEDS ABOVE 72 KM/H (45 MPH).

SOME VEHICLES MAY EXPERIENCE AN AUDIBLE 50 HZ BODY BOOM.

CONDITIONS ON BROKENT DOOR PULL HANDLES.

INFORMATION ON USING 1999 PROCEDURES MANUAL FOR SIDE MIRROR REPLACEMENT.

CONDITIONS WITH DOOR TRIM PANEL HAVING LOOSE OR BROKEN PULL HANDLES.

SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP.

SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS.

SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF,...

A NEW SILICONE GASKET AND SEALANT.

SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING.

STRESS CRACKS ON WINDSHIELDS.

RATTLE OR BUZZ IN TAILGATE TRIM PANEL AFTER REMOVAL IF THE RETAINING CLIPS ARE NOT REPLACED AFTER REPAIR.

SOME EXPEDITIONS MAY EXPERIENCE AN INTERMITTENT VISOR VANITY MIRROR LIGHT OPERATION.

VEHICLES MAY EXPERIENCE A STAINING OF THE ANODIZED ALUMINUM TRIM WITH THE USE OF SOME CAR WASHES WHICH CONTAIN ULTRA VIOLET PROTECTANTS.

THE ONLY AUTHORIZED REPAIR FOR A FRONT FRAME BUMPER MOUNTING BRACKET NEEDING REPLACEMENT IS TO REPLACE THE FRAME.

VEHICLES MAY EXPERIENCE AN INTERMITTENT VISOR VANITY MIRROR LIGHT OPERATION.

VEHICLES BUILT WITH RUNNING BOARDS AFTER 1/30/97 WILL NOT HAVE SEALS ON THE LOWER EDGE OF THE FRONT AND REAR DOORS.

INOPERATIVE FLOOR MODE CONCERNS MAY BE DUE TO THE PANEL/FLOOR DOOR VACUUM ACTUATOR LINKAGE DISCONNECTING FROM THE DOOR PIVOT.

INOPERATIVE FLOOR MODE CONCERNS MAY BE DUE TO THE PANEL/FLOOR DOOR VACUUM ACTUATOR LINKAGE DISCONNECTING FROM THE DOOR PIVOT.

DOOR - POWER POINT ACCESS DOOR BREAKS - VEHICLES BUILT THROUGH 8/31/96.

WINDNOISE - FRONT WINDOW RUN LIP HANGING OUT - VEHICLES BUILT THROUGH 8/14/96.

CONCERN WHERE THE DOOR GLASS DROPS WHEN CYCLED DOWN ON VEHICLES WITH THE POWER DOOR OPTION.

POP/THUMP NOISE AT END OF WINDOW MOVEMENT AND/OR DRIVER'S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION.

SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION AND/OR PREMATURE SHUTOFF OF THE GAS PUMP WHEN THE VEHICLE IS BEING REFUELED.

SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION AND/OR PREMATURE SHUTOFF OF THE GAS PUMP WHEN THE VEHICLE IS BEING RE-FUELED.

SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET.

SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION.

A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY.

ERRATIC AND / OR INACCURATE FUEL GAUGE READINGS.

SUBJECT REGARDING VEHICLES EXHIBITING ERRATIC AND / OR INACCURATE FUEL GAUGE READINGS.

MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455

EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP.

EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES.

EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM.

CONCERNS OF BREAKAGE OF THE EXHAUST SYSTEM BETWEEN THE MUFFLER AND TAILPIPE MAY OCCUR ON SOME VEHICLES.

FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE.

FUEL PUMP SENDER, IN AREAS WITH STEEP SLOPES, THE LOW FUEL WARNING LIGHT MAY PREMATURELY ACTIVATE.

THE FUEL GAGE MAY SWING ERRATICALLY ON STEEP SLOPES.

CONDENSATE FORMING ON THE OUTSIDE OF THE EVAPORATOR.

CONCERNS OF CONDENSATE FORMING ON OUTSIDE OF EVAPORATOR CASE.

BELT CHIRP AT COLD START UP IN AMBIENT TEMPERATURES OF 30-50 DEGREES F.

BELT CHIRP AT COLD START UP IN AMBIENT TEMPERATURES OF 30-50 DEGREES F.

SOME EXPEDITIONS MAY EXPERIENCE SOME BELT CHIRP AT COLD START UP IN AMBIENT TEMPERATURES OF 30-50 DEGREES F.

SOME FRONT END SERPENTINE BELTS MAY MAKE NOISE WHEN BETWEEN 30 AND 50 DEGREES FAHRENHEIT.

PUSH CONNECTION BETWEEN THE FLEXIBLE FUEL VAPOR LINE AT THE CARBON CANISTER & THE METAL FUEL VAPOR LINE MAY NOT SEAT FULLY ON THE FUEL VAPOR LINE.

INFORMATION FOR HIGH OR IRREGULAR FUEL GAUGE MOVEMENT OR IRREGULAR LOW FUEL FUEL LIGHT BELOW 1/4 FULL.

HIGH OR IRREGULAR GAUGE MOVEMENT OR IRREGULAR LOW FUEL LIGHT BELOW 1/4 FULL.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK...

SOME VEHICLES MAY EXHIBIT WHEELS THAT SEIZE TO THE HUBS AND ARE DIFFICULT TO REMOVE DURING SERVICE.

SOME VEHICLES WITH AIR SUSPENSION MAY EXHIBIT AN INITIAL OR REPEAT COMPRESSOR DRYER FAILURE.

SOME VEHICLES EQUIPPED WITH AIR SUSPENSION MAY EXHIBIT AN AIR LEAK AND/OR OVERNIGHT BLEED DOWN OF THE AIR SUSPENSION.

SOME VEHICLES MAY EXHIBIT AIR SUSPENSION MALFUNCTION.

SUBJECT REGARDING AIR SUSPENSION COMPRESSOR QUALITY.

SOME VEHICLES MAY EXHIBIT A CHECK SUSPENSION LAMP ON WITH DIAGNOSTIC TROUBLE CODES B2140 OR C2140 EVEN AFTER THE AIR...

SUBJECT PERTAINING TO AIR SUSPENSION LEAKS.

FUEL MAY LEAK FROM THE SPRING LOCK COUPLINGS.

A CLUNKING NOISE HEARD FROM FRONT ENDCAUSED BY FRONT STABILIZER BAR CONTACTING THE FRAME.

THIS BULLETIN MENTIONS HOW SOME HUB O-RINGS MAY BE CUT DURING THE INSTALLATION OF THE WHEELS.

SOME VEHICLES EQUIPPED WITH AIR SUSPENSION MAY EXHIBIT AN INTERMITTENT CHECK SUSPENSION LAMP ON AND DIAGNOSTIC TROUBLE...

IF YOU ENCOUNTER A VEHICLE WITH A MISSING WHEEL HUB O-RING, DO NOT INSTALL A NEW O-RING.

RATTLE OR CLUNK NOISE IN REAR OF VEHICLE CAUSED BY THE BUSHING FALLING OUT OF THE SWAY BAR LINK.

NOISE- "BUZZING"- UNDERHOOD WHEN AIR SUSPENSION IS IN OPERATION.

VEHICLES EQUIPPED WITH 4-WHEEL DRIVE, ROOF RACK AND BASE SUSPENSION MAY EXPERIENCE CLEARANCE DIFFICULTIES WITH CERTAIN GARAGES/CARPORTS.

AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP.

VEHICLES EQUIPPED WITH 4-WHEEL DRIVE, ROOF RACK AND BASE SUSPENSION MAY EXPERIENCE CLEARANCE DIFFICULTIES WITH GARAGE/CARPORTS.

ALL AIR SUSPNESION EXPEDTIONS ARE SHIPPED WITH THE AIR SUSPENSION SWITCH IN THE OFF POSITION.

AIR SUSPENSION VEHICLES ARE SHIPPED WITH THE AIR SUSPENSION SWITCH IN THE OFF POSITION.

PROCEDURE WHEN AIR SUSPENSION LIGHT IS ON.

AIR SUSPENSION COMPRESSOR NOISE.

REPEAT AIR SUSPENSION COMPRESSOR DRIER FAILURES.

REPEAT AIR SUSPENSION COMPRESSOR DRIER FAILURES.

SOME VEHICLES MAY EXHIBIT COURTESY RAIL LAMPS ABOVE THE 2ND ROW SEATS THAT DO NOT OPERATE PROPERLY OR CAUSE A BATTERY DRAW.

FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST...

SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA.

SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC...

INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS.

SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES.

EXHIBITING MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTC(S) PO351 AND / OR P0356 (COIL PRIMARY CIRCUIT MALFUNCTION).

INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS).

MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP.

VEHICLES ARE EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) - VEHICLE WILL NOT START WITHOUT THE CORRECT IGNITION KEY.

POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP.

MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP.

ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) INVALID DIAGNOSTIC CODES U1235 & 155 MAY BE STORED IF THE IGNITION...

CONCERN OF STARTER STAYING ENGAGED.

INFORMATION FOR CONCERNS OS SPEEDOMETER, SPEED CONTROL INOP & VSS (VEHICLE SPEED SENSOR) DTC'S.

CONCERN OF STARTER STAYING ENGAGED, LOOK AT CHAFED WIRE AT THE REAR BRACKET FOR THE RIGHT FRONT UPPER CONTROL ARM.

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.

COURTESY RAIL LAMPS DO NOT OPERATE CORRECTLY OR CAUSE A BATTERY DRAW.

SOME VEHICLES MAY EXHIBIT AMBER ANTI-LOCK BRAKE SYSTEM (ABS) LAMP ON WITH UNDEFINED DIAGNOSTIC TROUBLE CODES (DTCS) STORED.

THIS BULLETIN MENTIONS THAT FOR ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE...

SUBJECT REGARDING A MISSING RUBBER STOP BUMPER FROM THE PARKING BRAKE COTNROL.

ON SOME VEHICLES, THE RUBBER STOP BUMPER MAY BE MISSING FROM THE PARKING BRAKE CONTROL, A REPLACEMENT SERVICE PART IS NOW AVAILABLE.

INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT.

SUBJECT REGARDING ANTI-LOCK BRAKE LAMP ILLUMINATION, INCREASED BREAK PEDAL EFFORT AND / OR FALSE ANTI-LOCK BRAKE SYSTEM (ABS) CYCLING AT LOW SPEEDS.

SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT.

VEHICLES EXPERIENCING INCREASED BRAKE PEDAL EFFORT AND / OR FALSE ABS CYCLING AT LOW SPEEDS, OR ABS LAMP ILLUMINATION.

A NEW PARKING BRAKE CONTROL RUBBER BUMPER STOP IS NOW AVAILABLE FOR SERVICE.

AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT.

SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS.

HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE.

PARKING BRAKE PEDAL TRAVEL AND EFFORT ON EXPEDITIONS BROUGHT INTO THE DEALERSHIP WITH CUSTOMER COMPLAINTS CONCERNING PARKING BRAKE.

PARKING BRAKE PEDAL TRAVEL AND EFFORT ON EXPEDITIONS.

SOFT PARKING BRAKE PEDAL OR LONG PARKING BRAKE PEDAL FEEL.

LONG TRAVEL OF PARKING BRAKE PEDAL.

PROCEDURE FOR BRAKE EXTERIOR LIGHTS STAY ON (TAIL & HIGH MOUNT STOP LIGHT).

PROCEDURE FOR BRAKE WARNING INDICATOR STAYS ON RED IN CLUSTER.

SUBJECT REGARDING INOPERATIVE RUNNING BOARD LIGHTS.*YD

INFORMATION ON VEHICLES EXHIBITING AND O/D OFF LAMP FLASHING WITH DIAGNOSTIC TROUBLE CODE 62 / 628 / 1728.

SUBJECT ON THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODES MAY APPEAR.

LOCKS FAILED. YD

INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND...

THE MALFUCNTION INDICATOR LAMP ( MIL ) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE (DTC) P0455 MAY BE STORED IN MEMORY.

THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE (DTC) P0503 MAY BE STORED IN MEMORY.

EXPERIENCING DIFFICULTIES WITH THE MALFUNCTION INDICATOR LAMP (MIL).

MALFUNCTION INDICATOR LAMP (MIL) - ILLUMINATED- DIAGNOSTIC TROUBLE CODE (DTC) P0446 STORED IN CONTINUOUS MEMORY- VEHICLES BUILT THROUGH 1/17/97.

GEM CONCERN - CHECK FOR MORE THAN ONE GEM CONTROLLED COMPONENT THAT IS INOPERATIVE OR FOR A STRING OF FALSE GEM DTC'S RECEIVED IN MEMORY.

INFORMATION ON VEHICLES THAT MAY EXHIBIT A SLIGHT DELAY IN THE FIRST DRIVE AWAY AFTER THE VEHICLE HAS BEEN PARKED...

INFORMATION FOR WHEN DIAGNOSING CONCERNS W/ FACTORY INSTALLED CELLULAR PHONES.

LIGHT TO MODERATE AXLE NOISE (AXLE WHINE) AT 50 TO 65 MPH (80 TO 105 KPH) DURING ACCELS, DECELS OR CRUISE MAY BE DUE TO...

INFORMATION FOR COMPACT DISC PLAYER PROBLEMS, RADIO MAY DISPLAY NO DJ- NO DUSC OR CD WILL NOT EJECT.

INFORMATION REGARDING VEHICLES THAT EXPERIENCE THE RADIOS THAT DISPLAY NO DJ-NO DISC OR CD WILL NOT EJECT.

DIAGNOSTIC INFORMATION FOR COMPACT DISC PLAYER PROBLES, NO DISC OR CD WILL NOT EJECT.

SUBJECT PERTAINING TO RADIO INOPERATIVE CONDITIONS.

INFORMATION ON REMOVING THE RADIO CHASSIS FROM SOME VEHICLES.

EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO.

VEHICLES WITH PREMIUM RADIOS WILL BE EQUIPPED WITH VOLUME CONTROL/ON-OFF SWITCH.

THE NGS DISPLAYS INCORRECT DATA FOR THE IGN GEM PID ON THE VEHICLES.

THE NGS DISPLAYS INCORRECT DATE FOR THE ING GEM PID ON THE VEHICLES.

SOME 4X2 VEHICLES EQUIPPED WITH P275/60/R17 CONTINENTAL-GENERAL TIRES MAY EXHIBIT A HIGHWAY SPEED TIRE VIBRATION.

SOME 4X2 VEHICLES EQUIPPED WITH P275/60/R17 CONTINENTAL GENERAL TIRES MAY EXHIBIT A HIGHWAY SPEED TIRE VIBRATION.

SAFETY RECALL UPDATE TO REPLACE LOCKING LUG NUTS.

SOME VEHICLES MAY EXHIBIT LOOSE LUGNUTS AND / OR BROKEN WHEEL STUDS.

SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING...

INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE.

FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH.

INFORMATION FOR RECREATIONAL TOWING (ALL WHEELS ON THE GROUND).

SOME VEHICLES EQUIPPED WITH 4 WHEEL DRIVE MAY EXHIBIT A NOTCHY OR STICKING FEELING IN SLOW SPEED TURNS WITH NO EFFECT ON...

STEERING -ALIGNMENT-TOE SET PROCEDURE SERVICE TIP.

ACCELERATOR CABLE CONTACTING THE POWER STEERING RESERVOIR MAY CAUSING ACCELERATOR PEDAL VIBRATION.

CONCERNS FOR THE LABOR TIME STANDARD IN TBS 96-19-02 (STEERING - GRUNT NOISE DURING STEERING WHEEL RETURN FROM FULL RIGHT TURN) IS INCORRECT.

CUSTOMER MAINTENANCE REMINDER - LITERATURE PROGRAM 04L19 - TIE ROD INSPECTION PROCEDURE.

TIE ROD END INSPECTION PROCEDURE.

TIE ROD END INSPECTION PROCEDURE.

TIE ROD END INSPECTION PROCEDURE.

SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS.

INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS.

SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM.

SOME VEHICLES MAY EXHIBIT A WHISTLING NOISE WHILE DRIVING WITH A/C IN THE OFF POSITION AT SPEEDS ABOVE 64 KM/H (40 MPH).

EXPERIENCING NO OR INTERMITTENT AUXILLARY A/C MODE / BLOWER CONTROL ON SOME VEHICLES.

SOME VEHICLES WITH AIR CONDITIONING CAN EXHIBIT A COLD START ACCESSORY DRIVE BELT NOISE (CHIRP) CONCERN.

REATTACHMENT OF HEATER HOSE FITTINGS FOR CONCERN OF NO HEAT, OVERHEAT, OR COOLANT LOSS MAY OCCUR DUE TO HEATER HOSES NOT...

CLIMATE CONTROL A/C SERVICE TECH TIPS.

SUBJECT REGARDING PASSIVE ANTI THEFT SYSTEM (PATS) DIAGNOSTIC SERVICE TIPS.

DIAGNOSTIC SERVICE TIPS ON PASSIVE ANTI THEFT SYSTEM ( PATS ).

IMPORTANT SERVICE INSTRUCTIONS FOR ONP 97-B-17, EXPEDITION ONLY.

REVISION TO THE TECHNICAL INSTRUCTIONS WHEN PERFORMING RECALL 96S60.

REVISED TECHNICAL INSTRUCTIONS CONCERNING RECALL 96S60.

INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP.

REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS.

EXHIBITING AN AIR BAG LAMP ON INTERMITTENTLY WITH LAMP FAULT CODE (LFC) 24, OR DIAGNOSTIC TROUBLE CODE B1924 AND / OR B1342 STORED IN MEMORY.

SOME VEHICLES MAY EXHIBIT AN AIR BAG LIGHT ON INTERMITTENTLY WITH DIAGNOSTIC TROUBLE CODE B1924.

VEHICLES EXHIBITING INTERMITTENT ILLUMINATION OF AIR BAG LIGHT WITH DIAGNOSTIC TROUBLE CODE B1924.