2001 Ford Excursion TSBs

SUBJECT REGARDING VEHICLES EXHIBITING COLD START ROLLING IDLE.

COOLANT LEAK DUE TO A BROKEN LOWER RADIATOR HOSE CLAMP.

ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE.

SOME VEHICLES MAY EXHIBIT A COOLANT LEAK DUE TO A BROKEN RADIATOR HOSE CLAMP.

SOME VEHICLES BUILT AFTER 12/4/00 AND EQUIPPED WITH A 5.4L OR 6.8L ENGINE MAY EXHIBIT INCONSISTENT SPEED OR SURGING WITH...

SOME VEHICLES EQUIPPED WITH 7.3L DI ENGINE MAY EXHIBIT FALSE DIAGNOSTIC TROUBLE CODES P1105, P1106 (UPPER AND LOWER ALTERNATOR FAULTS).

SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA.

SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174.

SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY...

SOME VEHICLES MAY EXHIBITA COOLANT LEAK FROM THE WATER PUMP WEEP HOLE.

SOME VEHICLES BUILT AFTER 12/4/00 AND EQUIPPED WITH A 5.4L OR 6.8L ENGINE MAY EXHIBIT INCONSISTENT SPEED OR SURGING WITH...

SOME VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODE P0344 (CAM SENSOR).

CONCERNS WITH 7.3L ENGINE STARTER SERVICE.

EXPERIENCING DIAGNOSTIC TROUBLE CODE P0344 (CAM SENSOR).

SOME VEHICLES WITH 7.3L DIT ENGINES MAY EXHIBIT LOOSE TURBO BOLTS ON THE TURBO HOUSING.

SOME VEHICLES WITH A 5.4 OR 6.8L ENGINE MAY EXHIBIT SLIGHTLY INCONSISTENT SPEED OR SURGING WITH THE CRUISE CONTROL SET...

SOME VEHICLES EQUIPPED WITH 7.3L ENGINES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS.

A CONDITION MAY EXIST WITH LACK OF POWER UNDER A LOAD, AT CRUISE OR ON ACCELERATION MAY OCCUR ON SOME VEHICLES BUILT...

SOME VEHICLES EQUIPPED WITH A 7.3L DIT ENGINE MAY EXHIBIT LOOSE TURBO BOLTS ON THE TURBO HOUSING.

SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL.

FUEL QUALITY AND MOISTURE IN CERTAIN DIESEL FUELS MAY CAUSE SOME VEHICLES TO EXHIBIT A NO START, GRADUAL LOSS OF POWER,...

SOME VEHICLES EQUIPPED WITH 4R100 TRANSMISSION AND 7.3L ENGINE OR WITH 4R100 6.8L MAY EXHIBIT ENGINE STALL AFTER...

CONCERNS WITH A TURBO HOOT CONDITION.

SOME VEHICLES EQUIPPED WITH 5.4L OR 6.8L ENGINE BUILT THROUGH 9/10/2000 MAY EXHIBIT A MISS SOUND FROM THE EXHAUST.

SOME VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODE(S) P0344 OR P0340 (CAM SENSOR).

SOME VEHICLES EQUIPPED WITH 7.3L ENGINE MAY EXHIBIT A NO-START OR ENGINE STALL CONDITION.

SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT...

WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING.

INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW.

MEMONTARY RETURN TO IDLE DURING AGGRESSIVE ACCELERATION - DIAGNOSTIC TROUBLE CODE (DTC) P0123.

ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS.

DRIVEABILITY-NO START/REPEAT STARTER FAILURE-REPEAT STARTER REPLACEMENT.

ENGINE-LIGHT TICK OR RATTLE TYPE NOISE FROM ENGINE AFTER COLD START.

ENGINE-CYLINDER HEAD DECK LEAK-4.6 AND 5.4L ENGINES-NEW SERVICE-ONLY GASKET AND CYLINDER HEAD KITS AVAILABILITY.

ENGINE OR FUEL SYSTEM CONCERNS WHEN USING FUEL WITH GREATER THAN 5% BIODIESEL CONCENTRATION.

OIL LEAK AT HIGH PRESSURE PUMP FITTINGS AND/OR PLUG.

NO START/REPEAT STARTER FAILURE OR A STICKING/BINDING IGNITION LOCK CYLINDER, STARTER STAYING ENGAGED AT START UP.

SOME VEHICLES BUILT AFTER 12/7/1998 EQUIPPED WITH A 7.3L DIT ENGINE MAY EXHIBIT A HOOT OR HOWLING NOISE FROM THE TURBOCHARGER.

VEHICLES EQUIPPED WITH A 7.3L ENGINE (AFTER SERIAL NUMBER 0661894) - UNDER VALVE COVER (UVC) HARNESS RETAINER CLIP RELEASED FOR SERVICE.

SOME 7.3L DIESEL TURBOCHARGER PEDESTALS MAY LEAK OIL AROUND THE EXHAUST BACK PRESSURE ACTUATOR (EBP).

HIGH PRESSURE OIL PUMP LEAK ON VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE.

A LOSS OF POWER, OIL LEAKS AROUND THE TURBO, AND/OR EXCESSIVE EXHAUST NOISE FROM THE TURBO.

ENGINE OIL PAN CORROSION ON VEHICLES EQUIPPED WITH THE 7.3L DIESEL ENGINE.

EXTERNAL OIL LEAK DIAGNOSIS FOR 7.3L DIT ENGINES.

A LACK OF POWER UNDER A LOAD, AT CRUISE OR ON ACCELERATION MAY OCCUR ON SOME VEHICLES BUILT BEFORE 11/25/2000 EQUIPPED WITH THE 7.3L DIT ENGINE.

FUEL QUALITY AND MOISTURE IN CERTAIN DIESEL FUELS MAY CAUSE SOME VEHICLES TO EXHIBIT A NO START, GRADUAL LOSS OF POWER,...

LEAK OIL AROUND THE EXHAUST BACKPRESSURE ACTUATOR (EBP) - 7.3L DIESEL TURBOCHARGER PEDESTALS.

TURBO PEDESTAL SEAL OIL LEAK AROUND THE EXHAUST BACK PRESSURE (EBP) ACTUATOR.

A LOSS OF POWER, OIL LEAKS AROUND THE TURBO, AND/OR EXCESSIVE EXHAUST NOISE FROM THE TURBO.

ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED...

ROUGH IDLE AND/OR HESITATION WHEN ACCLERATING ON CERTAIN SUPER DUTY VEHICLES EQUIPPED WITH A 5.4L OR 6.8L ENGINE.

COOLANT LEAK DUE TO BROKEN RADIATOR HOSE CLAMP.

LACK OF POWER, SMOKE, OR OIL LEAKS AROUND THE CHARGE AIR COOLER (CAC).

COOLANT LEAK DUE TO A BROKEN LOWER RADIATOR HOSE CLAMP.

SOME VEHICLES MAY EXHIBIT A FEAD BELT SQUEAL.

SOME VEHICLES MAY EXHIBIT A CONDITION OF OIL CONTAMINATION IN COOLING SYSTEM.

SOME VEHICLES MAY EXHIBIT A POPPING NOISE BENEATH THE DRIVER'S FEET AREA COMING FROM THE FLOORBOARD.

SOME VEHICLES MAY EXHIBIT A SQUEAK AND RATTLE CONDITION.

SUBJECT REGARDIDNG SQUEAK AND RATTLE CONDITION.

SOME VEHICLES MAY EXHIBIT A DIFFICULT TO DIAGNOSE CONDITION WITH THE REAR SEAT ENTERTAINMENT CONDITION.

SOME VEHICLES MAY EXHIBIT A BUCK OR JERK (ALSO KNOWN AS HITCHING) DURING HIGHWAY DRIVING AT SPEEDS 40 MPH OR GREATER WITH THE CRUISE CONTROL ENGAGED.

SUBJECT REGARDING DIAGNOSTICS AND / OR MECHANICAL CONCERNS REGARDING THE NEW VENUTURE TRANSFER CASE.

CONCERNS WITH VEHICLES EXHIBITING THE OIL PRESSURE GAUGE REGISTERING LOW OR NO OIL PRESSURE USUALLY ON INITIAL START-UP...

VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK.

SOME VEHICLES MAY EXHIBIT A NOISE COMING FROM THE REAR OF THE VEHICLE WHEN TRAVELING OVER BUMPS.

SAFETY BELT RETRACTION SPEED.

HARD START OR NO START.

A COLD WEATHER REVERSE ENGAGEMENT STALL.

OIL/DUST FILM AT CAC CONNECTIONS.

DIAGNOSTIC TROUBLE CODE (DTC) P0340, POSSIBLE FALSE CODE.

SUBJECT REGARDING REAR BRAKE BLEED SCREW LOCATION ON 1999 - 2002 MODELS.

CONCERNS WITH RATTLE NOISES COMING FROM FRONT BRAKE CALIPERS.

SOME VEHICLES MAY EXHIBIT INCREASED STEERING EFFORTS AT VERY LOW SPEEDS OR WHEN STOPPED WITH THE BRAKES APPLIED.

CONCERNS WITH RATTLE NOISE ORIGINATING FROM THE FRONT BRAKE CALIPERS.

SOME VEHICLES MAY EXHIBIT CALIPER PIN RATTLE NOISE ORIGINATING FROM THE FRONT BRAKE CALIPERS.

SOME VEHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) LIGHT ON, B2141/B2477, AND/OR AN INACCURATE SPEEDOMETER.

INFORMATION REGARDING A RATTLE NOISE ORIGINATING FROM THE FRONT BRAKE CALIPER.*YD

CONCERNS THAT THE ANTI-LOCK BRAKE SYSTEM (ABS) LAMP IS ON WITH DIAGNOSTIC TROUBLE CODES C1230, C1229, OR C1237.

FRONT BRAKE PAD OR CALIPER RATTLE WHEN GOING OVER BUMPS.

A SLIGHT PURGE OF GREASE FROM THE FRONT HUB BEARING UNIT THAT MAY BE NOTED BETWEEN THE HUB UNIT AND THE INBOARD ROTOR FLANGE.

SOME VEHICLES MAY EXHIBIT HIGHER THAN NORMAL STEERING EFFORTS WHEN THE VEHICLES IS AT A VERY LOW SPEED OR STOPPED WITH THE BRAKES APPLIED.

BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES.

BRAKE PULL. 4X4 F-250/350 AND EXCURSION VEHICLES ONLY.

SLIGHT PURGE OF GREASE FROM THE HUB BEARING UNIT.

SOME VEHICLES MAY EXHIBIT A MISS OR POPPING THROUGH THE INTAKE OR EXHAUST.

INFORMATION ON VEHICLES REQUIRING FUEL LINE SERVICE.

FUEL CONDITIONER. LOW POWER, POOR FUEL ECONOMY, FUEL GELLING IN COLD WEATHER, EXCESSIVE WHITE SMOKE ON COLD START, HARD...

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP.

INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS.

LOW POWER, POOR FUEL ECONOMY, FUEL GELLING COLD, EXCESSIVE WHITE SMOKE COLD, OR HARD START.

FUEL SIGNAL TO INSTRUMENT CLUSTER SERVICE TIP.

GRADUAL LOSS OF POWER AT CRUISE.

MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A...

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK...

EXHAUST AIR RUSH NOISE AND LOWER POWER.

SOME VEHICLES EQUIPPED WITH A 4R100 TRANSMISSION AND BUILT BETWEEN JANUARY 1, 2001 AND MAY 1, 2002 MAY EXHIBIT FLASHING...

BRAKE SHIFT INTERLOCK.*JB

INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS.

SOME VEHICLES EQUIPPED WITH A 4R100 AUTOMATIC TRANSMISSION MAY EXHIBIT A REVERSE ENGAGEMENT STALL.

SOME VEHICLES EQUIPPED WITH 4R100 TRANSMISSION, HAVING A TRANSMISSION BUILD DATE BETWEEN 7/27/2000 AND 3/23/2001, MAY...

OWNER NOTIFICATION PROGRAM PARTS UPDATE REGARDING 4R100 TRANSMISSION REPLACEMENT.

OWNER NOTIFICATION INFORMING OWNERS THAT THEIR TRANSMISSION COULD BE DAMAGED INTERNALLY AND, POTENTIALLY, COULD RESULT...

SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM.

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK.

TRANSFER CASE SHIFT ISSUES ON VEHICLES WITH AN ELECTRONIC SHIFT ON THE FLY (ESOF) TRANSFER CASE.

NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS.

SUBJECT REGARDING ROOF RACK SCRATCHES PAINT ON ROOF PANEL.

SOME VEHICLES MAY EXHIBIT A FRONT OR REAR PINION SEAL LEAK.

SOME VEHICLES MAY EXHIBIT A TACKY SURFACE ON THE INSTRUMENT PANEL (IP).

THIS ARITLCE IS TO PROVIDE INFORMATION ON REPLACEMENT OF OLD STYLE HOOD LAMP SWITCH TO THE RVISED MECHANICAL HOOD LAMP SWITCH.

INFORMATION ON VEHICLES EXHIBITING A WATER PUMP SHAFT SEAL LEAK.

INFORMATION ON REAR AXLE PINION SEAL PART USAGE.

VEHICLES MAY EXPERIENCE FRONT SHAFT SEAL LEAKAGE.

ROOF PAINT SCRATCHING FROM LUGGAGE RACK CROSSBARS.

A CLUNK / POPPING NOISE FROM FRONT SWAY BAR AREA.

FRONT LOCKING HUBS. *JB

FRONT HUBS NOT ENGAGING, NOT STAYING ENGAGED AND/OR UNLOCKING.

FRONT HUBS NOT ENGAGING, NOT STAYING ENGAGED AND/OR UNLOCKING.

FRONT HUBS WILL NOT ENGAGE OR DISENGAGE PROPERLY.

ON-VEHICLE FRONT INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT.

NO ENGAGEMENT OR DISENGAGEMENT OF HUB LOCKS AFTER REPLACEMENT OR SERVICE.

CONCERNS OF DIAGNOSTIC TROUBLE CODE P1280 RETRIVED FROMTHE POWER TRAIN CONTROL MODULE (PCM).

INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES.

SUBJECT REGARDING STARTER SERVICE CONTACT REQUEST.

ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS - SERVICE TIPS.

MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY...

SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS.

VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST MODE.

CLIMATE CONTROL A/C SERVICE TECH TIPS.

VACUM PUMP INOPERATIVE OR RUNS CONTINUOSLY - CLIMATE CONTROL DEFAULT TO DEFROST.

VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST.

SOME VEHICLES MAY EXHIBIT LACK OF POWER STEERING ASSIST.

SOME VEHICLES MAY EXHIBIT STIFF STEERING, WANDERING, OR POOR RETURNABILITY AFTER TURNS.

This SKU is a front upper ball joint.

SEAT BELT WARNING SYSTEM - BELT REMINDER FUNCTION, OPERATION AND SERVICE TIPS.

AIR BAG LIGHT ON WITH DIAGNOSTIC TROUBLE CODE (DTC) B1871 OR B1935 FOLLOWING ECS/RCM REPLACEMENT.

GRADUAL LOSS OF POWER AT CRUISE.

REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS.

SOME VEHICLES MAY EXHIBIT INTERFERENCE AND / OR STATIC IN THE LAND-MOBILE RADIO.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS.

WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS.

FIRESTONE TIRE SAFETY CAMPAIGN.