2005 Ford Escape TSBs
59 Technical Service Bulletins across 13 categories
Categories
Engine
15 bulletinsFORD/MERCURY: MIL ON WITH DTC P0351-P0356; MULTIPLE COIL PRIMARY CIRCUIT.
Read full bulletin
BUILT ON OR BEFORE 10/03/05. SOME VEHICLES EQUIPPED WITH A 3.0L ENGINE MAY EXHIBIT A MULFUNCTION INDICATOR LAMP (MIL) ON WITH TWO OR MORE DIAGNOSTIC TROUBLE CODES (DTCS) FOR COIL ON PLUG (COP) PRIMARY CIRCUIT FAULTS. *PE
ENGINE STALLING ON ENGAGEMENT/STOPPING.
Read full bulletin
*KB
SPARK KNOCK, HARD START AND/OR HESITATION - VEHICLES BUILT AFTER 08-02-2004 WITH A 3.0L ENGINE.
Read full bulletin
*KB
POSSIBLE ENGINE DAMAGE - INSTALL SPECIAL SERVICE TOOLS PRIOR TO REMOVING CRANKSHAFT PULLEY BOLT.
Read full bulletin
*KB
POSSIBLE ENGINE DAMAGE - INSTALL SPECIAL SERVICE TOOLS PRIOR TO REMOVING CRANKSHAFT PULLEY BOLT - SERVICE TIP.
Read full bulletin
*TT
CAMSHAFT TICK NOISE - 3.0L 4V ENGINE ONLY.
Read full bulletin
*TT
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING.
Read full bulletin
*TT
VIBRATION AT HIGHWAY SPEEDS OVER A WIDE SPEED RANGE ON VEHICLES BUILT AFTER 8/1/2004 EQUIPPED WITH A 3.0L ENGINE AND...
Read full bulletin
CONTINENTAL CONTITRAC P235/70R16 104T TIRES ONLY. *TT
MIL ON WITH MULTIPLE COIL PRIMARY CIRCUIT DTCS P0351 THROUGH P0356-3.0 ENGINE.
Read full bulletin
*SC
NO START WITH SERVICE ENGINE SOON LIGHT ON - DIAGNOSTIC TROUBLE CODE (DTC) P0A90 OR P0A92 IN TRANSMISSION CONTROL MODULE (TCM).
Read full bulletin
*TT
ELECTRIC MOTOR TEMPERATURE INDICATOR LAMP ON - POSSIBLE DIAGNOSTIC TROUBLE CODES (DTCS) P0A2F, P0A3B, P0A3C, P0A3E, P0A7C.
Read full bulletin
*TT
ROUGH IDLE AT LOW MILEAGE.
Read full bulletin
*EH
ENGINE OVERHEATING AND/OR LOSS OF AIR CONDITIONING (A/C) PERFORMANCE.
Read full bulletin
*TT
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS.
Read full bulletin
TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.
OIL LEAK FROM DIPSTICK OR FRONT OR REAR CRANKSHAFT SEALS - HEATED PCV SERVICE KIT - 3.0L DURATEC ENGINE.
Read full bulletin
*TT
Fuel System
10 bulletinsSLOW FUEL FILL AND/OR DTC P0451.
Read full bulletin
*NJ
COLD CLIMATE SLOW FUEL FILL.
Read full bulletin
*NJ
SLOW FUEL FILL DUE TO CLOGGED VENT.
Read full bulletin
*KB
SLOW FUEL FILL. *TT
SLOW FUEL FILL - REPEAT FILLING STATION PUMP SHUT-OFF.
Read full bulletin
*TT
SLOW FILL OR PREMATURE SHUTOFF WHEN FILLING THE FUEL TANK.
Read full bulletin
*EH
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.
Read full bulletin
*TT
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.
Read full bulletin
*TT
MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP.
Read full bulletin
VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT
INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS.
Read full bulletin
*TT
Electrical
8 bulletinsFor 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended.
Read full bulletin
It is also not recommended to order a replacement module using a vehicle identification number (VIN) from a different vehicle. Most modules on these affected vehicles are VIN/vehicle specific and hardware variations between modules do exist. Swapping a module from a vehicle or ordering a module using a different vehicle/VIN can cause ineffective repairs and additional vehicle down time. Make sure all appropriate Workshop Manual (WSM) procedures are followed when diagnosing the condition prior to all module replacements and only order modules using the correct VIN.
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs).
Read full bulletin
The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
2005-08 ESCAPE/ESCAPE HYBRID/MARINER - 2006-08 MARINER HYBRID - WHEEL SPEED SENSOR RING REPLACEMENT PROCEDURE UPDATE TO WORKSHOP MANUAL.
Read full bulletin
*NJ
SERVICE WIRING HARNESS REPLACEMENT GUIDELINES - SERVICE TIPS.
Read full bulletin
*TT
WRENCH LAMP ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0A1F PRESENT IN TBCM AND/OR PCM (POWER TRAIN CONTROL MODULES) MODULES...
Read full bulletin
- VEHICLES BUILT 8/2/2004 THROUGH 1/26/2005. *TT
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.
Read full bulletin
*TT
WHEEL SPEED SENSOR REMOVAL TIP.
Read full bulletin
*EH
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES.
Read full bulletin
*TT
Other
5 bulletinsLONG CRANK/HARD START -- 3.0L.
Read full bulletin
*TT
DRIVABILITY CONCERNS - HESITATION/STUMBLE.
Read full bulletin
*TT
WELD BONDING PROCEDURE.
Read full bulletin
*TT
SAFETY BELT RETRACTION SPEED.
Read full bulletin
*TT
WHEN INSPECTING A TRANSFER CASE IT IS NORMAL TO FIND METALLIC SHAVINGS ON THE MAGNETIC FILL PLUG.
Read full bulletin
*EH
Brakes
4 bulletinsABS LIGHT ON AND DTC C1475 IS SHOWN.
Read full bulletin
*KB
PASSENGER AIR BAG DISABLED (PAD) LAMP INTERMITTENTLY ON WHILE DRIVING - DTC C1414 RETRIEVED DURING OCS DIAGNOSIS/REPAIR.
Read full bulletin
*TT
REAR DISC BRAKE GRIND, RUBBING OR THUMP NOISE.
Read full bulletin
*SC
REAR BRAKE NOISE/MOAN (4 WHEEL DISC ONLY).
Read full bulletin
*TT
Pre-Delivery & Maintenance
4 bulletinsNEUTRAL TOW CAPABILITY - SERVICE KIT REQUIREMENTS.
Read full bulletin
*TT
MIRFIRE DIAGNOSTIC TROUBLE CODES P0316, P0300, P0301, P0302, P0303, OR P0304 - SERVICE TIP.
Read full bulletin
*TT
NEUTRAL TOW CAPABILITY -- SERVICE KIT REQUIREMENTS.
Read full bulletin
*TT
SAFETY BELT WEB STOP BUTTON SERVICE.
Read full bulletin
*EH
Steering
4 bulletinsSTEERING CLUNK/RATTLE NOISE - VEHICLES BUILT 3/29/2005 TO 4/4/2005.
Read full bulletin
*TT
HIGH STEERING EFFORTS IN COLD AMBIENT TEMPERATURES - VEHICLES BUILT PRIOR TO 2/15/2005.
Read full bulletin
*TT
STEERING DRIFT/PULL - IMPROVED DIAGNOSTIC AND REPAIR PROCEDURE - SERVICE TIP.
Read full bulletin
*TT
INTERMITTENT HIGH STEERING EFFORT IN COLD TEMPERATURES.
Read full bulletin
*TT
Lighting
3 bulletinsCONDENSATION INSIDE THE FOGLAMPS.
Read full bulletin
*EH
WATER PUMP PULLEY COVER NO LONGER INSTALLED.
Read full bulletin
*TT
MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P1639 (VEHICLE ID BLOCK CORRUPTED, NOT PROGRAMMED).
Read full bulletin
*TT
Transmission
2 bulletinsSHIFTER RELEASE BUTTON CAP FALLS OFF.
Read full bulletin
*TT
TRANSMISSION CONTROL INDICATOR LAMP (TCIL) ON WITH DIAGNOSTIC TROUBLE CODE P1783 AND/OR P0733 COLD CLIMATE...
Read full bulletin
SHIFT/ENGAGEMENT CONCERNS WITH A CD4E TRANSAXLE. *TT
Tires & Wheels
1 bulletinVIBRATION DIAGNOSIS - TIRE/WHEEL RUNOUT.
Read full bulletin
*TT
Body & Paint
1 bulletinSERVICEABILITY OF INSTRUMENT PANEL REGISTER VENTS.
Read full bulletin
*TT
Hybrid & EV
1 bulletinCHARGING SYSTEM CONCERNS - SERVICE TIP.
Read full bulletin
*TT
Software & Calibration
1 bulletinWARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS.
Read full bulletin
*MJ UPDATE. *TT