2004 Ford Escape TSBs
47 Technical Service Bulletins across 15 categories
Categories
Electrical
6 bulletinsThe Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs).
Read full bulletin
The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
PCM FAILURE - ELECTRICAL ACCESSORIES INTERMITTENT - INOPERATIVE.
Read full bulletin
*TT
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.
Read full bulletin
*TT
WHEEL SPEED SENSOR REMOVAL TIP.
Read full bulletin
*EH
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES.
Read full bulletin
*TT
AIRBAG LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES (DTCS) B1877 (DRIVER PRETENSIONER CIRCUIT OPEN) OR B1881 (PASSENGER PRETENSIONER CIRCUIT OPEN).
Read full bulletin
*TT THIS BULLETIN SUPERSEDES TSB 03-20-11 DATED 2003. *TT
Engine
6 bulletinsPOSSIBLE ENGINE DAMAGE - INSTALL SPECIAL SERVICE TOOLS PRIOR TO REMOVING CRANKSHAFT PULLEY BOLT - SERVICE TIP.
Read full bulletin
*TT
CAMSHAFT TICK NOISE - 3.0L 4V ENGINE ONLY.
Read full bulletin
*TT
REPLACE TIMING BELT IDLER PULLEY DURING 2.0L ZETEC ENGINE CYLINDER HEAD REPLACEMENT - SERVICE TIP.
Read full bulletin
*TT
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING.
Read full bulletin
*TT
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS.
Read full bulletin
TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED...
Read full bulletin
USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT
Fuel System
6 bulletinsREAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.
Read full bulletin
*TT
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.
Read full bulletin
*TT
MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP.
Read full bulletin
VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT
INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS.
Read full bulletin
*TT
DEMONSTRATION/DELIVERY HOLD - SPECIAL FIELD ACTION 03L17.
Read full bulletin
REVISED SMOG EMISSIONS INFORMATION. *TT
FUEL SIGNAL TO INSTRUMENT CLUSTER SERVICE TIP.
Read full bulletin
*TT
Pre-Delivery & Maintenance
4 bulletinsNEUTRAL TOW CAPABILITY - SERVICE KIT REQUIREMENTS.
Read full bulletin
*TT
NEUTRAL TOW CAPABILITY -- SERVICE KIT REQUIREMENTS.
Read full bulletin
*TT
SAFETY BELT WEB STOP BUTTON SERVICE.
Read full bulletin
*EH
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS.
Read full bulletin
*TT
Air Bags & Safety
4 bulletinsRESTRAINT SYSTEM - SAFETY BELT BUCKLE AND PRETENSIONER DIAGNOSTIC TROUBLE CODE (DTC) B1877 AND/OR B1881.
Read full bulletin
*TT
SIDE AIR BAG DIAGNOSTIC TROUBLE CODE (DTC) B1994 OR B1998.
Read full bulletin
*TT
SAFETY BELT BUCKLE AND PRETENSIONER DIAGNOSTIC TROUBLE CODE (DTC) B1877, B1881, B1885 OR B1886.
Read full bulletin
*TT
AIR BAG WARNING LAMP ON .
Read full bulletin
*EH
Suspension
3 bulletinsSafety recall 14S02 - Corrosion at forward attachment of lower control arm - requests for recall service action
2001-2004 Escape vehicles Safety Recall 14S02 has been issued for vehicles that are operated in high corrosion areas for...
Read full bulletin
an extended period, where a corrosion-related separation of the forward attachment of the lower control arm (LCA) from the subframe may occur. Separation of the LCA from the subframe may result in diminished vehicle directional control, increasing the risk of a crash.
FORD: THE LOWER CONTROL ARM (LCA) FORWARD ATTACHMENT WILL SEPARATE FROM SUBFRAME, CAUSING DIMINISHING DIRECTIONAL...
Read full bulletin
CONTROL, DUE TO OPERATING IN HIGH CORROSION AREAS FOR EXTENDED PERIOD OF TIME. MODEL 2001-2004 ESCAPE. *PE
Other
3 bulletinsSAFETY BELT RETRACTION SPEED.
Read full bulletin
*TT
A FINAL DRIVE WHINE AT 25-45 MPH (40-72 KM/H).
Read full bulletin
*TT
FRONT SAFETY BELT SLOW TO RETRACT AND/OR MISSING WEB STOP BUTTON.
Read full bulletin
*TT
Lighting
3 bulletinsCONDENSATION INSIDE THE FOGLAMPS.
Read full bulletin
*EH
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS.
Read full bulletin
VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT
FINAL DRIVE WHINE MOST NOTICEABLE AT 25-45 MPH DURING LIGHT ACCELERATION OR DECELERATION.
Read full bulletin
*TT
Steering
3 bulletinsSTEERING DRIFT/PULL - IMPROVED DIAGNOSTIC AND REPAIR PROCEDURE - SERVICE TIP.
Read full bulletin
*TT
LOW PRESSURE POWER STEERING LINE LEAK AFTER COLD SOAK IN TEMPERATURES OF -23C (-10) OR LOWER.
Read full bulletin
*MJ
TIE ROD END INSPECTION PROCEDURE.
Read full bulletin
*TT
Transmission
3 bulletinsTRANSMISSION CONTROL INDICATOR LAMP (TCIL) ON WITH DIAGNOSTIC TROUBLE CODE P1783 AND/OR P0733 COLD CLIMATE...
Read full bulletin
SHIFT/ENGAGEMENT CONCERNS WITH A CD4E TRANSAXLE. *TT
CLUTCH CHATTER WHEN COLD.
Read full bulletin
*TT
HARSH SHIFTS AND ENGAGEMENTS WITH ONLY DIAGNOSTIC TROUBLE CODE (DTC) P1502.
Read full bulletin
*TT
Brakes
2 bulletinsEXCESSIVE FRONT ROTOR WEAR AND/OR BRAKE DUST.
Read full bulletin
*TT
EXCESSIVE BRAKE PAD/LINING DUST AND WEAR.
Read full bulletin
*TT
Tires & Wheels
1 bulletinVIBRATION DIAGNOSIS - TIRE/WHEEL RUNOUT.
Read full bulletin
*TT
Body & Paint
1 bulletinSERVICEABILITY OF INSTRUMENT PANEL REGISTER VENTS.
Read full bulletin
*TT
HVAC & Climate
1 bulletinHIGH AIRFLOW FROM DEFROSTER VENTS WHEN IN FLOOR OR FLOOR DEFROST MODES.
Read full bulletin
*EH
Software & Calibration
1 bulletinWARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS.
Read full bulletin
*MJ UPDATE. *TT