2000 Ford Econoline TSBs

SOME 5.4L WINDSOR POWER IMPROVED ENGINES MAY EXHIBIT A SLIGHT OIL LEAK OR WEEP AT THE CYLINDER HEAD TO BLOCK JOINT.

SOME VEHICLES EQUIPPED WITH 4.2L AND 3.8L ENGINES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P1518.

SOME VEHICLES EQUIPPED WITH 7.3L DIT ENGINE MAY EXHIBIT AN ENGINE THAT RUNS ROUGH, MISSES, BUCK / JERK, HESITATE /...

A CONDITION MAY EXIST WHERE THE MALFUNCTION INDICATOR LAMP IS ON WITH DIAGNOSTIC TROUBLE CODE P0340 (CAMSHAFT POSITION...

SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL.

THIS BULLETIN ADDRESSES CONCERNS A NOISE AT INTIAL ENGINE STARTUP WHEN COLD FROM THE ACCESSORY DRIVE BELT.

CONCERNS WITH THE INTAKE MANIFOLD LEAKING OR WEEPING COOLANT FROM PASSENGER SIDE GASKET AT RIGHT REAR CORNER OF HEAD-TO-MANIFOLD JOINT.

SOME VEHICLES EQUIPPED WITH POWERSTROKE DIESEL ENGINES AFTER SERIAL NUMBER 0896812 (ENGINE BUILD DATE), MAY EXHIBIT A...

SOME VEHICLES MAY PRODUCE A MALFUNCTION INDICATOR LAMP ILLUMINATED, ROUGH IDLE, A CHECK ENGINE LIGHT, AND DIAGNOSTIC...

SOME VEHICLES EQUIPPED WITH A 4.6L, 5.4L, OR 6.8L ENGINE MAY EXHIBIT A ROUGH IDLE / MISS AFTER START-UP IN COLD AMBIENT TEMPERATURES.

A CONDITION MAY EXIST WITH POSSIBLE ELECTRONC DAMAGE OCCURING TO THE COMPUVALVE FROM VOLTAGE SPIKES BETWEEN THE...

SOME VEHICLES EQUIPPED WITH 7.3 DIT ENGINE MAY EXHIBIT ENGINE ROUGHNESS, MISSES, BUCK / JERK, HESITATION / STUMBLE,...

INFORMATION ON THE 7.3L DIT ENGINES, ROTUNDA TOOL HAS ISSUED AN INJECTOR PERFORMANCE ANALYZER THAT MAY NOW BE PRUCHASED...

SOME VEHICLES BUILT BETWEEN 10/24/99 AND 11/8/99 EQUIPPED WITH 7.3L POWERSTROKE ENGINE THAT HAVE CALIFORNIA EMISSIONS...

SOME VEHICLES MAY EXHIBIT ANY OF P0350 - P0358 COIL (DIAGNOSTIC TROUBLE CODES), CHECK ENGINE LIGHT, AND ROUGH IDLE.

SOME VEHICLES MAY EXHIBIT ANY OF P0350 THROUGH P0358 COIL DIAGNOSTIC TROUBLE CODES, CHECK ENGINE LIGHT ON AND ROUGH IDLE UNDER COLD START CONDITIONS.

SOME VEHICLES EQUIPPED WITH 7.3L DIT ENGINE MAY EXHIBIT A ROUGH ENGINE IDLE.

SOME VEHICLES EQUIPPED WITH 73L DIT ENGINE MAY EXHIBIT A ROUGH ENGINE IDLE.

SOME VEHICLES EQUIPPED WITH 7.3L DIT DIESEL ENGINE MAY EXHIBIT FUEL CACKLE IN WARM WEATHER AND / OR IN A HIGH ALTITUDE AREA.

SOME MEDIUM TRUCKS EQUIPPED WITH 7.3L DIT MAY EXHIBIT AN INTERMITTENT ENGINE KNOCK PERCEIVED TO BE FUEL CACKLE.

INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART.

SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES.

VEHICLES BUILT AFTER 5/19/1999 WITH THE 7.3L DIT WITH A ENGINE SERIAL # GREATER THAN 1039780 NOW HAVE A FILTER SCREEN...

INFORMATION ON 7.3L DIT VEHICLES EXHIBITING AN INTERMITTENT ENGINE KNOCK WHICH MAY BE PERCEIVED AS A ROD KNOCK.

ENGINE OR FUEL SYSTEM CONCERNS WHEN USING FUEL WITH GREATER THAN 5% BIODIESEL CONCENTRATION.

VEHICLES EQUIPPED WITH A 7.3L ENGINE (AFTER SERIAL NUMBER 0661894) - UNDER VALVE COVER (UVC) HARNESS RETAINER CLIP RELEASED FOR SERVICE.

VEHICLES EQUIPPED WITH 7.3L DIT ENGINE BUILT AFTER ENGINE SERIAL NUMBER 896812 MAY HAVE A INJECTION CONTROL PRESSURE...

FOR 7.3L DIT ENGINES, ROTUNDA TOOL HAS ISSUED AN INJECTOR PERFORMANCE ANALYZER THAT MAY NOW BE PURCHASED AS AN EFFECTIVE...

FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV).

CONCERNS OF DIAGNOSTIC TROUBLE CODE P1280 RETRIVED FROMTHE POWER TRAIN CONTROL MODULE (PCM).

INOPERATIVE OR INACCURATE SPEEDOMETER, 4X4 LAMP ILLUMINATED AND / OR DIAGNOSTIC TROUBLE CODES (DTCS) P1635 OR P1639...

INOPERATIVE OR INACCURATE SPEEDOMETER, 4X4 LAMP ILLUMINATED, AND / OR DIAGNOSTIC TROUBLE CODES (DTCS) P1635 OR P1639...

VEHICLES WITH 7.3L DIESEL AND APCM (AUXILIARY POWERTRAIN CONTROL MODULE), MAY HAVE MOUNTING HARDWARE IN THE APCM KIT...

A DEAD BATTERY AND CIRCUIT BOARD CONCERNS DURING PREDELIVERY INSPECTION.

INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS.

SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES.

GLOW PLUG CONTROL MODULE ON 7.3L DIESEL VEHICLES WITH CALIFORNIA EMISSIONS - SERVICE TIP.

SOME VEHICLES EQUIPPED WITH THE 4R70W AUTOMATIC TRANSMISSION MAY EXHIBIT A TICKING OR CLICKING TYPE NOISE IN FIRST GEAR.

SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM.

VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN...

VEHICLES MAY EXPERIENCE PARTICLE CONTAMINANTS, FROM PRIOR TRANSMISSIION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE...

INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP.

SERVICE PROCEDURE FOR ORANGE SERVICE TAGGED 4T100 TRANSMISSIONS.

SERVICE PROCEDURE FOR GREEN SERVICE TAGGED 4R70W TRANSMISSIONS.

NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS.

THIS SERVICE ACTION REQUIRES THE REPLACEMENT OF TWO EMISSION CONTROL LABELS.

SUBJECT REGARDING MEDIUM TRUCKS EQUIPPED WITH 7.3L DIT EXHIBITING FUEL CACKLE.

SOME VEHICLES MAY EXHIBIT FUEL CACKLE IN WARM WEATHER AND / OR IN A HIGH ALTITUDE AREA.

INFORMATION REGARDING FUEL CACKLE.

LOW POWER, POOR FUEL ECONOMY, FUEL GELLING COLD, EXCESSIVE WHITE SMOKE COLD, OR HARD START.

EMISSION RECALL 04E10: COMPRESSED NATURAL GAS (CNG) VEHICLES - FITTING CONNECTOR REPLACEMENT.

EXHAUST AIR RUSH NOISE AND LOWER POWER.

WITHOUT FRONT BRAKE DUST SHIELDS MAY EXHIBIT PREMATURE WEAR OF THE FRONT WHEEL BEARINGS DUE TO DAMAGED INNER WHEEL...

SOME VEHICLES WITH REAR BRAKE DRUMS MAY EXHIBIT BRAKE SQUEAL NOISE.

SOME VEHICLES WITHOUT FRONT BRAKE DUST SHIELDS MAY EXHIBIT PREMATURE WEAR OF THE FRONT WHEEL BEARINGS DUE TO DAMAGED INNER WHEEL BEARING SEALS.

SOME VEHICLES WITHOUT FRONT BRAKE DUST SHIELDS MAY EXHIBIT PREMATURE WEAR OF THE FRONT WHEEL BEARINGS DUE TO DAMAGED INNER WHEEL BEARING SEALS.

SOME VEHICLES WITH REAR BRAKE DRUMS MAY EXHIBIT BRAKE SQUEAL NOISE.

INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT.

REPEATED BLOWN FUSES FOR REAR IN VEHICLE CIRCUITS WITH INOPERATIVE REAR BRAKE OR TAIL LAMPS.

DEDICATED CNG REGULATOR BOWL KIT AVAILABLE.

SOME VEHICLES WITH DANA 80 REAR AXLES MAY EXHIBIT AN EXCESSIVE AMOUNT OF AXLE WHINE NOISE.

INFORMATION ON REAR AXLE WHINE-VEHICLES EQUIPPED WITH DANA 80 AXLES-5.4L/6.8L AND 7.3L.

CUSTOMERS MAY BE CONCERNED THAT VEHICLE LOOKS LIKE IT DOGTRACKS, DUE TO A UNIQUE FEATURE OF THE VEHICLE THAT COMBINE TO...

MERLIN MULTIPLEX SYSTEM WHEN A PROER/GROUND LUG IS NOT CORRECTLY TIGHTENED OR BECOMES LOOSE FOR ANY REASON; ERRATIC...

DIAGNOSTIC TROUBLE CODE (DTC) P0340, POSSIBLE FALSE CODE.

INFORMATION ON VEHICLES EXHIBITING A WATER PUMP SHAFT SEAL LEAK.

VEHICLES MAY EXPERIENCE FRONT SHAFT SEAL LEAKAGE.

SOME VEHICLES MAY EXHIBIT A-PILLAR SHEET METAL CRACKS AROUND FRONT DOOR HINGES; FRONT DOOR SKIN SEPARATES AND DOOR INNER...

SOME VEHICLES MAY EXHIBIT A-PILLAR SHEET METAL CRACKS AROUND FRONT DOOR HINGES; FRONT DOOR SKIN SEPARATES AND DOOR INNER...

SOME VEHICLES MAY EXPERIENCE A MALFUNCTION INDICATOR LAMP ON WITH A DIAGNOSTIC TROUBLE CODE P1518.

SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ON WITH A DIAGNOSTIC TROUBLE CODE P1518.

INFORMATION ON THE NEW MUSTANG, COBRA R AND ECONOLINED FEATURED ON THE NEXT SPOTLIGHT ON QSF SHOW.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS.

SOME VEHICLES WITH AN ILLUMINATED AIR BAG LAMP MAY HAVE MODIFIED SEAT CONFIGURATIONS.

SOME VEHICLES WITH AN ILLUMINATED AIR BAG LAMP MAY HAVE MODIFIED SEAT CONFIGURATIONS WHICH MAY HAVE BEEN CHANGED BY MODIFIERS OR THE CUSTOMER.

AIR BAG LAMP ILLUMINATED.

SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS.

INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS.

SOME VEHICLES MAY EXHIBIT INTERFERENCE AND / OR STATIC IN THE LAND-MOBILE RADIO.

SOME VEHICLES WITH HIGH ODOMETER READING OR SEVERE SERVICE MAY EXHIBIT A CREAKING NOISE WHEN TURNING WHEEL OR DRIVING...

VEHICLES WITHOUT FRONT DUST SHIELDS MAY EXHIBIT PREMATURE WEAR OF THE FRONT WHEEL BEARINGS DUE TO DAMAGED INNER WHEEL BEARING SEALS.

This SKU is a front upper ball joint.