1993 Ford Econoline TSBs

SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM.

VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN...

INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP.

TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART.

TRANSMISSION-E40D-NO 2-3 UPSHIFT.

SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,...

SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728.

INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART.

FLUID- TRANSMISSION FLUID USAGE CHARTS.

TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP.

TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP.

INFORMATION ON AODE/4R7W TRANSMISSION MAIN CONTROL & CASE REPLACEMENT.

REVISED DESIGN TRANSMISSION REAR CASE BUSHING.

NEW DESIGN TRANSMISSION RANGE SENSOR.

VEHICLES MAY EXHIBIT A SHIFT CONCERN.

SEVERE DRIVELINE VIBRATION OR TRANSMISSION EXTENTION HOUSING BUSHING SPINOUT.

UPGRADE KIT FOR THE E40D TRANSMISSION.

TRANSMISSION OVERHEATING, CONVERTER COVER DISCOLORATION, CLUTCHES BURNED AND BURNT FLUID *TW

NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS.

SERVICE TIP INFORMATION REGARDING THE REVERSE CLUTCH PISTON AND PISTON SEAL USAGE.

CONCERNS WITH A HARD TO TURN IGNITION KEY AND / OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER.

FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR.

SOME VEHICLES MAY DEVELOP "CAVITATION" EROSION IN THE CYLINDER WALL OF THE ENGINE.

A HARD TO TURN IGNITION KEY, AND/OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER MAY OCCUR ON SOME VEHICLES.

HARD START- EXTREME COLD AMBIENT TEMPERATURE- VEHICLES WITH 7.3L DIESEL ENGINE.

ACCESSORY DRIVE BELTS- FEAD BELT COMES OFF- VEHICLES WITH 4.9L ENGINE.

VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS.

KNOCKING NOISE ON INITIAL START-UP.

DURING HIGHWAY DECELERATION OR ENGINE START-UP, THERE MAY BE A HOOTING NOISE COMING FROM THE ENGINE COMPARTMENT.

EARLY WEAR OF FEAD TENSIONER PULLEY ON VEHICLES WITH 5.0L/5.8L ENGINES.

NEW TORQUE-TO-YIELD CYLINDER HEAD BOLT KIT.

SERVICE PROCEDURE FOR CATALYTIC CONVERTER RESTRICTION ISSUES - PROCEDURE REQUIRES THE USE OF NEW ECM, IAC VALVE AND EXPANSION CHAMBER.

ENGINE HESITATION/SURGE DURING LIGHT ACCELERATION.

HOOTING NOISE FROM THE ENGINE COMPARTMENT.

INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT.

SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT.

AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT.

THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE.

SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS.

HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE.

BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP.

THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE...

EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP.

EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM.

INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM.

FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE.

ACCESSORY DRIVE BELTS - ALL 7.3 IDI DIESELS COME OFF ACCESSORY DRIVE PULLEYS - VEHICLES BUILT AFTER 2/15/92.

SOME VEHICLES MAY EXHIBIT A LACK OF POWER OR A NO START CONDITION DUE TO AN EXHAUST RESTRICTION.

SOME DIESEL POWERED VEHICLES ARE EXPERIENCING DRIVE BELT TRACKING CONCERNS DUE TO FRONT END ACCESSORY DRIVE PULLEYS (FEAD) MISALIGNMENT.

NO START CONDITION CAUSED BY PLUGGED CATALYTIC CONVERTER.

SOME VEHICLES MAY EXHIBIT A STEERING PULL TO THE RIGHT OR LEFT.

VEHICLES MAY EXHIBIT A STEERING PULL TO THE RIGHT OR LEFT, DUE TO INCORRECT FRONT END ALIGNMENT SETTINGS.

COMPLAINTS OF TIRE WEAR AND LOOSE FEELINGS IN THE STEERING SYSTEM.

SUBJECT REGARDING A HIGH NUMBER OF BALL JOINTS BEING REPLACED AS THE RESULT OF ROUTINE INSPECTIONS OR OF COMPLAINTS OF...

SOME VEHICLES MAY EXHIBIT A "SQUEAKING" OR "MOANING" NOISE FROM THE STEERING COLUMN WHILE TURNING.

This SKU is a front upper ball joint.

CUSTOMERS MAY BE CONCERNED THAT VEHICLE LOOKS LIKE IT DOGTRACKS, DUE TO A UNIQUE FEATURE OF THE VEHICLE THAT COMBINE TO...

INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA.

REVISED OIL PAN GASKET.

HARSH REVERSE ENGAGEMENT CONCERNS.

UNKNOWN

A HARD START OR NO START CONDITION IN EXTREME COLD WEATHER.

SOME VEHICLES THAT ARE LOADED TO THE UPPER END OF GVW, WITH THE MAJORITY OF THE LOAD BETWEEN THE AXLES, MAY EXHIBIT...

VEHICLES THAT ARE LOADED TO THE UPPER END OF FVW, WITH THE MAJORITY OF THE LOAD BETWEEN THE AXLES, MAY EXHIBIT INNER...

SUBJECT REGARDING TIRE BALANCE HINT.

ADDRESSING TIRE BALANCE HINTS.

INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE.

SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS.

INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS.

ANNOUNCING THE FORD OEM AIR CONDITIONING RETROFIT KIT AVAILABILITY.

SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES.

WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS.

CORROSION BETWEEN THE TAMPER SENSOR AND THE IGNITION SWITCH CASTING MAY CAUSE FALSE ACTIVATION OF THE ANTI-THEFT ALARM SYSTEM.

FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS.

IMPROVED PARTS FOR SERVICE OF DRIVE BELT TRACKING.

UPPER BALL JOINTS MAY HAVE EARLY WEAR ON SOME VEHICLES.

VEHICLES MAY EXHIBIT MORE BODY ROLL DUE TO REDUCTION IN THE AMOUNT OF LEAF SPRINGS IN THE ASSEMBLY.

EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO.

WINDSHIELD AND INTERIOR GLASS - FOG/FILM.