1999 Ford E Series TSBs

SOME VEHICLES EQUIPPED WITH THE 5.4L 2V ENGINE MAY EXHIBIT A WHISTLING NOISE FROMTHE FORMED NYLON TUBE INTHE IDLE-AIR BYPASS FLOW CIRCUIT.

ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE.

SOME VEHICLES MAY RUN ROUGH AT CRUISE OR MOMENTARILY AFTER STOPPING, A CHECK ENGINE LIGHT,AND P030X CODES.

SOME DEDICATED AND BI-FUEL CNG VEHICLES MAY EXHIBIT A CONDITION OF FUEL LEAK OR FUEL ODOR AT THE CNG FUEL FILL VALVE AREA.

SOME COMPRESSED NATURAL GAS (CNG) VEHICLES MAY EXHIBIT ROUGH IDLE OR NO START WHEN COLD.

SOME DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES MAY EXHIBIT A ROUGH IDLE, OR NO START IN COLD CONDITIONS.

SOME VEHICLES EQUIPPED WITH 7.3L DI ENGINE MAY EXHIBIT FALSE DIAGNOSTIC TROUBLE CODES P1105, P1106 (UPPER AND LOWER ALTERNATOR FAULTS).

SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA.

SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174.

SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY...

SOME VEHICLES EQUIPPED WITH THE ROMEO BUILT 4.6L 2V ENGINE MAY EXHIBIT AN ENGINE OIL LEAK OR OIL WEEPAGE FROM THE...

INFORMATION TO AID IN DIAGNOSIS FOR CLARIFICATION OF LOCK-OFF SOLENOID AND SOLENOID TANK VALVE COIL RSISTANCES FOR BI-FUEL VEHICLES.

INFORMATION ON A REINFORCEMENT KIT FOR VEHICLES EXHIBITING FAILURE OF THE POWER SEAT PEDESTAL MOTOR.

SOME E-SERIES EQUIPPED WITH AN RV MODIFIED POWER SEAT MAY EXHIBIT FAILURE OF THE POWER PEDESTAL MOTOR.

SOME VEHICLES MAY EXHIBIT A FUEL LEAK AT CNG FILL VALVE.

SOME VEHICLES MAY EXHIBIT A CLUNK THAT CAN BE FELT OR HEARD THROUGH THE STEERING WHEEL.

SOME VEHICLES EQUPPED WITH A 5.4L OR 6.8L ENGINE MAY EXHIBIT A ROLLING / ROUGH IDLE.

SOME VEHICLES BUILT 7/1998 TO 6/1999 EQUIPPED WITH A 4.6 / 5.4L WINSOR BUILT ENGINES MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAT GASKET AREA.

SUBJECT REGARDING CERTAIN VEHICLES WITH 4.6L ROMEO ENGINES EXHIBITING AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA.

SOME VEHICLES EQUIPPED WITH 4.6L ROMEO ENGINE MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA.

OIL LEAK FROM THE FRONT OR REAR CYLINDER HEAD OIL SUPPLY RAIL END PLUGS.

SOME VEHICLES WITH GAS ENGINES AND FACTORY INSTALLE DAUXILIARY BATTERY OPTION MAY EXPERIENCE CHARGING TROUBLES WITH THE AUXILIARY BATTERY.

SOME VEHICLES WITH GAS ENGINES AND FACTORY INSTALLED AUXILIARY BATTERY OPTION MAY EXPERIENCE CHARGING TROUBLES WITH THE AUXILIARY BATTERY.

SOME VEHICLES WITH 7.3L DIT ENGINES MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME.

SOME VEHICLES WITH 7.3L DIT ENGINE MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME.

SOME VEHICLES WITH 7.3L DIT ENGINE MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME.

SOME VEHICLES EQUIPPED WITH 6.8L ENGINES, MAY EXHIBIT A CUSTOMER CONCERN OR ENGINE ROAR OR ENGINE NOISE FOR THE FIRST...

SOME VEHICLES EQUIPPED WITH 6.8L ENGINE, MAY EXHIBIT A CUSTOMER CONCERN OF ENGINE ROAR OR ENGINE NOISE FOR THE FIRST FEW...

CONCERNS WITH A NO START CONDITION AFTER INSTALLATION OF A NEW 6.8L ENGINE ASSEMBLY.

SOME VEHICLES BUILT 7/1998 TO 6/1999 EQUIPPED WITH A 4.6 / 5.4L WINDSOR BUILT ENGINES MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA.

SOME VEHICLES MAY EXHIBIT A NO START CONDITION AFTER INSTALLATION OF A NEW 6.8L ENGINE ASSEMBLY.

SOME VEHICLES BUILT 7/1998 TO 6/1999 EQUIPPED WITH A 4.6 / 5.4L WINDSOR BUILT ENGINE MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA.

SOME VEHICLES WITH 5.4L ENGINES AND 9VZA-AH OR 9VZA-BL CALIBRATIONS MAY SET A MALFUNCTION INDICATOR LIGHT ON WITH A...

SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP.

SOME VEHICLES MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP.

SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP.

EXPERIENCING ENGINE KNOCK AT INITIAL COLD STARTUP.

VEHICLES WITH 5.4L ENGINES AND 9VZA-AH OR 9VZA-BL CALIBRATIONS MAY SET A MIL LIGHT WITH A DIAGNOSTIC TROUBLE CODE OF...

SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP.

FORD: THE BLOWER MOTOR ON SOME VEHICLES ARE OPERATING EITHER INCORRECTLY OR NOT OPERATING OR JUST FUNCTIONING ON ONE SPEED.

SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT...

WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING.

USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE.

INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW.

ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS.

ENGINE-LIGHT TICK OR RATTLE TYPE NOISE FROM ENGINE AFTER COLD START.

ENGINE-CYLINDER HEAD DECK LEAK-4.6 AND 5.4L ENGINES-NEW SERVICE-ONLY GASKET AND CYLINDER HEAD KITS AVAILABILITY.

ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION.

BROKEN EXHAUST MANIFOLD STUDS.

OIL LEAK AT HIGH PRESSURE PUMP FITTINGS AND/OR PLUG.

SOME DEDICATED CNG VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS DUE TO A LOSS OF INJECTOR PERFORMANCE, RESULTING FROM FUEL QUALITY.

7.3L DIT TURBOCHARGER REPLACEMENT UNDER WARRANTY.

SOME 7.3L DIESEL TURBOCHARGER PEDESTALS MAY LEAK OIL AROUND THE EXHAUST BACK PRESSURE ACTUATOR (EBP).

HIGH PRESSURE OIL PUMP LEAK ON VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE.

A LOSS OF POWER, OIL LEAKS AROUND THE TURBO, AND/OR EXCESSIVE EXHAUST NOISE FROM THE TURBO.

ENGINE OIL PAN CORROSION ON VEHICLES EQUIPPED WITH THE 7.3L DIESEL ENGINE.

EXTERNAL OIL LEAK DIAGNOSIS FOR 7.3L DIT ENGINES.

7.3L POWERSTROKE DIESEL ENGINE WITH ENGINE SERIAL NUMBER 661894 THROUGH 1311240 MAY EXHIBIT A KNOCK NOISE ABOVE THE...

SIGNIFICANT 1999 7.3L DIESEL ENGINE CONTENT REVISIONS.

LEAK OIL AROUND THE EXHAUST BACKPRESSURE ACTUATOR (EBP) - 7.3L DIESEL TURBOCHARGER PEDESTALS.

DEDICATED COMPRESSED NATURAL GAS (CNG) ROUGH IDLE OR NO START WHEN COLD VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY.

TURBO PEDESTAL SEAL OIL LEAK AROUND THE EXHAUST BACK PRESSURE (EBP) ACTUATOR.

A LOSS OF POWER, OIL LEAKS AROUND THE TURBO, AND/OR EXCESSIVE EXHAUST NOISE FROM THE TURBO.

ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED...

COMPRESSED NATURAL GAS (CNG).

ON SOME DEDICATED CNG VEHICLES, A POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE.

POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE, ON SOME DEDICATED CNG VEHICLES.

INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER,...

SOME DEDICATED CNG VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS OF HARD START / NO START / ROUGH RUNNING.

REPORTS THAT CERTAIN VEHICLES APPEAR TO BE DOGTRACKING.

SOME VEHICLES MAY EXHIBIT A CONDITION OF OIL CONTAMINATION IN COOLING SYSTEM.

SOME VEHICLES MAY EXHIBIT DRIVELINE CLUNK / THUMP NOISE CONDITION ON INITIAL ACCELERATION FROM A STOP.

SOME VEHICLES MANUFACTURED AS INCOMPLETE VEHICLES (1FD IN THE FIRST THREE POSITIONS OF VIN) EQUIPPED WITH A POWER SEAT...

CONCERNS WITH VEHICLES EXHIBITING THE OIL PRESSURE GAUGE REGISTERING LOW OR NO OIL PRESSURE USUALLY ON INITIAL START-UP...

INFORMATION ON VEHICLES EXHIBITING A HARD TO DIAGNOSE SQUEAK / RATTLE NOISE CONCERN.

EFFECTIVE NOVEMBER 2, 1998 CERTAIN VEHICLES OF THE 4R100 ARE ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM.

SOME VEHICLES MAY EXHIBIT A HARD TO DIAGNOSE SQUEAK/RATTLE NOISE CONCERN.

INFORMATION REGARDING VEHICLES MODELS OF THE 4R100 THAT ARE ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM.

SOME VEHICLES WITH MODEL 80 REAR AXLES ONLY MAY EXHIBIT A CONCERN WITH THE AMOUNT OF SOUND, WHINE PRODUCED ABOVE 35 MPH.

SOME VEHICLES UNDER SEVERE DUTY CYCLES MAY EXHIBIT CRACKS ON THE LOWER RADIATOR SUPPORT.

INFORMATION REGARDING THE IMPROVED RADIATOR SUPPORT.

CONCERNS WITH CRACKS ON THE RIGHT REAR SIDE OF THE #1 FRAME CROSSMEMBER.

CONDITIONS WITH PRESSURE BEING HIGHER/LOWER THAN EXPECTED.

A DRIVELINE CLUNK OR BUMP WHEN STARTING FROM A STOP.

A COLD WEATHER REVERSE ENGAGEMENT STALL.

VEHICLES WITHOUT THE COOLANT LOCK-OFF MAY EXHIBIT A NO START CONDITION.

EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL.

EXPERIENCING A CLUNKING TYPE NOISE THAT CAN BE FELT OR HEAR THROUGH THE STEERING WHEEL.

SOME VEHICLES MAY EXHIBIT A CLUNK THAT CAN BE FELT OR HEARD THROUGH THE STEERING WHEEL.

SOME VEHICLES MAY EXHIBIT A STEERING PULL TO THE RIGHT OR LEFT.

VEHICLES MAY EXHIBIT A STEERING PULL TO THE RIGHT OR LEFT, DUE TO INCORRECT FRONT END ALIGNMENT SETTINGS.

SOME VEHICLES BUILT BEFORE APRIL 1, 1999 MAY HAVE A CUSTOMER CONCERN OF A CLUNK FELT / HEARD IN THE STEERING WHEEL.

SOME CUSTOMERS MAY COMMENT ON A CLUNK FELT / HEARD IN THE STEERING WHEEL.

CUSTOMER MAY COMPLAIN OF A CLUNK FELT / HEARD IN THE STEERING WHEEL.

CONCERNS OF A CLUNK FELT / HEARD IN THE STEERING WHEEL.

CLICKING/POPPING NOISE FROM UPPER STEERING COLUMN AREA WHEN TURNING.

BRAKE SHIFT INTERLOCK.*JB

INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS.

SOME VEHICLES EQUIPPED WITH A 4R70W AUTOMATIC TRANSMISSION MAY EXHIBIT A CLUNK NOISE DURING THE 2-1 DOWNSHIFT EVENT.

SOME VANS / WAGONS WITH 138 INCH WHEELBASE AND 4R70W TRANSMISSION (DRIVE SHAFT >70 INCH) MAY EXHIBIT A VIBRATION BOOM...

SOME VEHICLES MAY EXHIBIT A TRANSMISSION FLUID LEAK FROM THE TRANSMISSION COOLER HOSE AUXILLARY COOLER.

INFORMATION REGARDING THE 1999 SCHEDULED MAINTENANCE GUIDE FOR ANY LIGHT TRUCK, SPORT UTILITY OR VAN EQUIPPED WITH A...

SOME VEHICLES BUILT ON OR AFTER MARCH 1, 1999 MAY EXHIBIT A TRANSMISSION FLUID LEAK FROM THE TRANSMISSION COOLER HOSE TO AUXILIARY COOLER.

SOME TRUCKS BUILT ON OR AFTER MARCH 1, 1999 MAY EXHIBIT A TRANSMISSION FLUID LEAK FROM THE TRANSMISSION COOLER HOSE TO AUXILIARY COOLER.

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK.

NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP.

CONCERNS OF DIAGNOSTIC TROUBLE CODE P1280 RETRIVED FROMTHE POWER TRAIN CONTROL MODULE (PCM).

INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES.

SOME VEHICLES EQUIPPED WITH AFTERMARKET HIGH-CURRENT DEVICES MAY EXHIBIT DIAGNOSTIC TROUBLE CODES B1876, B1880, B1915...

SOME VEHICLES MAY RETREIEVE MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P0351 AND / OR P0357...

EXHIBITING MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTC(S) PO351 AND / OR P0356 (COIL PRIMARY CIRCUIT MALFUNCTION).

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.

DIAGNOSTIC TROUBLE CODE B1876, B1880, B1915 AND/OR B1920 IN THE ECS MODULE - VEHICLES EQUIPPED WITH AFTERMARKET HIGH CURRENT DEVICES.

DIAGNOSTIC TROUBLE CODES (DTC) B1876, B1880, B1915 AND/OR B1920 AIRBAG ELECTRONIC CRASH SENSOR (ECS) MODULE ON VEHICLES...

INFORMATION ON VEHICLES EXHIBITING A PERCEIVED POOR FUEL RANGE / ECONOMY, AND OR A FAULTY FUEL GAUGE.

SUBJECT REGARDING ALTERNATIVE FUEL VEHICLE COMPRESSED NATURAL GAS TANK INSPECTION.

SUBJECT REGARDING TECHNICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES.

FUEL CONDITIONER. LOW POWER, POOR FUEL ECONOMY, FUEL GELLING IN COLD WEATHER, EXCESSIVE WHITE SMOKE ON COLD START, HARD...

7.3L DIESEL HIGH PRESSURE OIL PUMP LEAK.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK...

BI-FUEL LPG VEHICLES (WITH COOLANT LOCK OFF) MAY EXHIBIT A NO START CONDITION.

SOME VEHICLES WITHOUT FRONT BRAKE DUST SHIELDS MAY EXHIBIT PREMATURE WEAR OF THE FRONT WHEEL BEARINGS DUE TO DAMAGED INNER WHEEL BEARING SEALS.

SUBJECT REGARDING A NEW ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR STRATEGY.

SOME VEHICLES WITHOUT FRONT BRAKE DUST SHIELDS MAY EXHIBIT PREMATURE WEAR OF THE FRONT WHEEL BEARINGS DUE TO DAMAGED INNER WHEEL BEARING SEALS.

SUBJECT REGARDING NEW ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR STRAGETY.

SUBJECT ON ANTI-LOCK BRAKE SYSTEM (ABS) LAMP STRATEGY CHANGE.

REPEATED BLOWN FUSES FOR REAR IN VEHICLE CIRCUITS WITH INOPERATIVE REAR BRAKE OR TAIL LAMPS.

SOME VEHICLES WITH HIGH ODOMETER READING OR SEVERE SERVICE MAY EXHIBIT A CREAKING NOISE WHEN TURNING WHEEL OR DRIVING...

VEHICLES THAT ARE LOADED TO THE UPPER END OF FVW, WITH THE MAJORITY OF THE LOAD BETWEEN THE AXLES, MAY EXHIBIT INNER...

SOME VEHICLES MAY EXHIBIT A CRACK ON THE RIGHT REAR SIDE OF THE #1 CROSSMEMBER RESULTING IN A CREAKING NOISE WHILE...

ADDRESSING TIRE BALANCE HINTS.

SOME VEHICLES MAY EXHIBIT FRONT DOOR (DRIVER AND / OR PASSENGER SIDE) DISENGAGEMENT OF THE OUTER DOOR PANEL FROMTHE...

SOME VEHICLES MAY EXHIBIT A-PILLAR SHEET METAL CRACKS AROUND FRONT DOOR HINGES; FRONT DOOR SKIN SEPARATES AND DOOR INNER...

SOME VEHICLES MAY EXHIBIT A-PILLAR SHEET METAL CRACKS AROUND FRONT DOOR HINGES; FRONT DOOR SKIN SEPARATES AND DOOR INNER...

SUBJECT REGARDING FRONT SUSPENSION INSPECTION PROCEDURES.

REAR LEAF SPRING NOISE.

CLUNK FROM FRONT SUSPENSION.

SOME VEHICLES WITH AN ILLUMINATED AIR BAG LAMP MAY HAVE MODIFIED SEAT CONFIGURATIONS.

SOME VEHICLES WITH AN ILLUMINATED AIR BAG LAMP MAY HAVE MODIFIED SEAT CONFIGURATIONS WHICH MAY HAVE BEEN CHANGED BY MODIFIERS OR THE CUSTOMER.

AIR BAG LAMP ILLUMINATED.

GRADUAL LOSS OF POWER AT CRUISE.

REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS.

GUIDANCE FOR CNG TANK INSPECTION FOR VEHICLES PRODUCED AFTER DECEMBER 2, 1996.

NO TURBINE SHAFT SPEED (TSS) DISPLAYED USING NGS OR WDS.