1997 Ford E-350 TSBs

SOME VEHICLES MAY EXHIBIT A FUEL FILL VALVE SEALING CONDITION.

SUBJECT REGARDING ENGINE DIAGNOSTIC GUIDE FOR WARRANTY REIMBURSEMENT.

THIS BULLETIN STATES THAT REPLACEMENT UNDER WARRANTY OF CERTAIN SPECIFIED COMPONENTS ON ANY 7.3L DIT DIESEL VEHICLE,...

INFORMATION ON SUPER DUTY 7.3 DIT DIESEL ENGINE VEHICLES EXHIBITI LACK OF POWER.

INFORMATION ON SUPER DUTY MODELS WITH 7.3L DIESEL ENGINES EXHIBITING ROUGH IDLE / MISS CONDITION.

BRIEF INFORMATION CONCERN VEHICLES EXHBITING EXTERNAL OIL LEAKS.

INFORMATION ON VEHICLES EXHIBITING ROUGH IDLE / MISS.

SUBJECT REGARDING EXTERNAL OIL LEAKS - REPEAT MESSAGE.

REPEAT MESSAGE REGARDING VEHICLES EXHIBITING ROUGH IDLE / MISS CONDITION.

LACK OF POWER DUE TO FAILURE OF ENGINE TURBO BOOST

REPEAT MESSAGE, NO CHANGE- ROUGH IDLE/MISS.

COLD ENGINE UPPER KNOCK/TICK.

CONCERNS WITH EXTERNAL OIL LEAKS.

LOW RPM- 7.3L DIT ENGINE FAILS TO START- CODE 340 STORED IN MEMORY AND/OR ENGINE FAILS TO ACHIEVE RATED SPEED FOR 2-3...

LEAK - OIL LEAKAT ENGINE VALLEY PAN AND/OR HIGH PRESSURE OIL PUMP - VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE.

ENGINE - 7.3L DIT - GLOW PLUG START-UP ON-TIME DURING COLD TEMPERATURE - SERVICE TIP.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - GASEOUS FUEL PREP (GFP) VEHICLES - POWERTRAIN CONTROL MODULE (PCM)...

A RUNNING CHANGE FOR THE 7.3L TO ALLOW BETTER DEFINITION ON CYLINDER CONTRIBUTION TESTS IN PROCESS.

INVESTIGATING 7.3L IRREGULAR IDLE.

FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES.

VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS.

CONCERNS OF CHECK ENGINE LIGHT 'ON'.

CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES.

INVESTIGATING 7.3L IRREGULAR IDLE.

LOW RPM, NO START, RUNS POORLY, STALL.

A HIGH NUMBER OF HIGH PRESSURE REXROTH PUMPS AND INJECTION PRESSURE REGULATORS (IPR) ARE BEING REPLACED DUE TO OIL...

SPECIAL FIELD ACTION REGARDING REVISED WARANTY INFORMATION.

BRIEF INFORMATION ON VEHICLES EXHIBITING A STALL ON DECELERATION CONDITION.

BRIEF INFORMATION ON VEHICLES EXHIBITING LACK OF POWER CONDITION.

BRIEF INFORMATION VEHICLES EXHIBITING HARD START / NO START CONDITION.

REPEAT MESSAGE REGARDING A STALL ON DECEL CONDITION.

REPEAT MESSAGE REGARDING A HARD START / NO START CONDITION.

REPEAT MESSAGE REGARDING VEHICLES EXHIBITING A LACK OF POWER.

DTC'S P1211/1212 ICP PRESSURE HIGHER/LOWER THAN EXPECTED.

VEHICLE STALLS/QUITS WHILE DRIVING.

VEHICLE STALLS UPON ACCELERATION.

REPEAT MESSAGE, NO CHANGE: HARD START/ NO START.

SUBJECT REGARDING ON-BOARD DIAGNOSTIC (OBD) SYSTEM UPGRADES.

EXCESSIVE WHITE SMOKE.

WHEN THE AIR CLEANER IS BEING REPLACED, THE DRAIN MECHANISM ON THE BOTTOM OF THE AIR CLEANER CASE IS TO BE CLEANED OF OBSTRUCTIONS.

INCORRECT INFORMATION IN 1997 EVTM MANUAL.

SOME CUT-AWAY VEHICLES MAY EXHIBIT ANTI-SKID BRAKE SYSTEM DIAGNOSTIC TROUBLE CODE C1229, C1230 AND C1237.

SOME VEHICLES MAY EXHIBIT BRAKE ROTOR CHECKING OR SIGNS OF EXCESSIVE HEAT BUILD-UP.

SOME VEHICLES MAY EXHIBIT BRAKE ROTOR CHECKING OR SIGNS OF EXCESSIVE HEAT BUILD-UP.

EXPERIENCING VIBRATION DURING LIGHT BRAKE APPLICATIONS AT HIGHWAY SPEEDS.

IF AN E350 REQUIRES ROTOR AND HUB REPLACEMENT, A REVISED THICKER PLATE ROTOR IS NOW AVAILABLE.

SPADE TERMINAL BETWEEN SENDER & FUEL PUMP HAS BEEN CHANGED TO A EYELET TERMINAL.

BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES.

SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A VIBRATION / ROUGHNESS ON ACCELERATION...

SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A DRIVELINE VIBRATION / ROUGHNESS ON...

SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL.

E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM.

SUBJECT REGARDING TIRE BALANCE HINT.

ADDRESSING TIRE BALANCE HINTS.

FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH.

VIBRATION/HARSHNESS ABOVE 45 MPH (72 KM/H) AFTER TIRE BALANCE.

CONCERNS WITH BUMP STEER STEERING FEELING NOTED WHEN FRONT WHEELS / TIRES CONTACT ROAD SURFACE IRREGULARITIES.

This SKU is a front upper ball joint.

A BUMP STEER STEERING FEELING, NOTED WHEN THE VEHICLE'S FRONT WHEELS/TIRES CONTACT ROAD SURFACE IRREGULARITIES.

SERVICE INFORMATION FOR VEHICLES EXHIBITING STALL ON DECELERATION CONDITION.

DIAGNOSTIC GUIDES FOR OUT-OF-WARRANTY VEHICLES TO BE USED AS A MASTER COPY - DIAGNOSTIC GUIDES NO LONGER AVAILABLE FROM ADISTRA.

7.3L DIT GLOW PLUG START-UP ON-TIME DURING COLD TEMPERATURE - SERVICE TIP.

AIRBAG LIGHT ON & CODE 21, MAY BE CAUSED BY AN ELECTROMAGNETIC INTERFERENCE GENERATED WITHIN THE ELECTRICAL SYSTEM.