1996 Ford E-350 TSBs

SOME VEHICLES MAY EXHIBIT A FUEL FILL VALVE SEALING CONDITION.

SUBJECT REGARDING ENGINE DIAGNOSTIC GUIDE FOR WARRANTY REIMBURSEMENT.

THIS BULLETIN STATES THAT REPLACEMENT UNDER WARRANTY OF CERTAIN SPECIFIED COMPONENTS ON ANY 7.3L DIT DIESEL VEHICLE,...

INFORMATION ON SUPER DUTY 7.3 DIT DIESEL ENGINE VEHICLES EXHIBITI LACK OF POWER.

SOME SUPER DUTY VEHICLES WITH 7.3L DIT DIESEL ENGINES MAY EXHIBIT 4X4 LIGHTS ON, 4X4 INOPERATIVE AND / OR MULTIPLE GEM CODES.

INFORMATION ON SUPER DUTY MODELS WITH 7.3L DIESEL ENGINES EXHIBITING ROUGH IDLE / MISS CONDITION.

BRIEF INFORMATION CONCERN VEHICLES EXHBITING EXTERNAL OIL LEAKS.

INFORMATION ON VEHICLES EXHIBITING ROUGH IDLE / MISS.

SUBJECT REGARDING EXTERNAL OIL LEAKS - REPEAT MESSAGE.

REPEAT MESSAGE REGARDING VEHICLES EXHIBITING ROUGH IDLE / MISS CONDITION.

EXHAUST LEAK AT EXHAUST MANIFOLDS--VEHICLE EQUIPPED WITH 7.0L 0R 7.5L ENGINE.

SOME VEHICLES MAY EXPERIENCE AN INTERMITTENT STALL CONDITION AFTER A LONG DECELERATION WHEN USING THE M1 OR M2 GEAR ON...

LACK OF POWER DUE TO FAILURE OF ENGINE TURBO BOOST

REPEAT MESSAGE, NO CHANGE- ROUGH IDLE/MISS.

COLD ENGINE UPPER KNOCK/TICK.

CONCERNS WITH EXTERNAL OIL LEAKS.

LOW RPM- 7.3L DIT ENGINE FAILS TO START- CODE 340 STORED IN MEMORY AND/OR ENGINE FAILS TO ACHIEVE RATED SPEED FOR 2-3...

LEAK - OIL LEAKAT ENGINE VALLEY PAN AND/OR HIGH PRESSURE OIL PUMP - VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE.

A RUNNING CHANGE FOR THE 7.3L TO ALLOW BETTER DEFINITION ON CYLINDER CONTRIBUTION TESTS IN PROCESS.

VIBRATION- DRIVELINE RESONANCE/VIBRATION BETWEEN 1400 AND 2000 RPM WITH CONVERTER CLUTCH ENGAGED DURING MEDIUM TO HEAVY...

EXHAUST - EXHAUST LEAK AT EXHAUST MANIFOLDS - VEHICLES EQUIPPED WITH 7.0L OR 7.5L ENGINE.

CHECK ENGINE LIGHT, CODE P030X, WITH NO DRIVEABILITY COMPLAINT.

VEHICLES W/ AN ABS CODE 1095, MAY BE CAUSED BY WATER INTRUSION INTO THE HCU/ECU MOTOR.

INVESTIGATING 7.3L IRREGULAR IDLE.

VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS.

INVESTIGATING 7.3L IRREGULAR IDLE.

LOW RPM, NO START, RUNS POORLY, STALL.

A HIGH NUMBER OF HIGH PRESSURE REXROTH PUMPS AND INJECTION PRESSURE REGULATORS (IPR) ARE BEING REPLACED DUE TO OIL...

ENGINE NOISE SIMILAR T A ROD KNOCK.

ON VEHICLES WITH TRANSMISSION BUILD DATES PRIOR TO 9/20/95, THE OVERDRIVE CANCEL LAMP MAY BE ILLUMINATING AND DIAGNOSTIC...

BRIEF INFORMATION ON VEHICLES EXHIBITING A STALL ON DECELERATION CONDITION.

BRIEF INFORMATION ON VEHICLES EXHIBITING LACK OF POWER CONDITION.

BRIEF INFORMATION VEHICLES EXHIBITING HARD START / NO START CONDITION.

REPEAT MESSAGE REGARDING A STALL ON DECEL CONDITION.

REPEAT MESSAGE REGARDING A HARD START / NO START CONDITION.

REPEAT MESSAGE REGARDING VEHICLES EXHIBITING A LACK OF POWER.

DTC'S P1211/1212 ICP PRESSURE HIGHER/LOWER THAN EXPECTED.

VEHICLE STALLS/QUITS WHILE DRIVING.

VEHICLE STALLS UPON ACCELERATION.

REPEAT MESSAGE, NO CHANGE: HARD START/ NO START.

EXCESSIVE WHITE SMOKE.

RECOMMENDED GUIDELINES FOR TOWING BEHIND RECREATIONAL VEHICLES.

WHEN THE AIR CLEANER IS BEING REPLACED, THE DRAIN MECHANISM ON THE BOTTOM OF THE AIR CLEANER CASE IS TO BE CLEANED OF OBSTRUCTIONS.

THE FRONT END ACCESSORY DRIVE (FEAD) BELT MAY WEAR, SHRED AND/OR COME OFF DURING DECELERATION.

SOME VEHICLES MAY EXHIBIT BRAKE ROTOR CHECKING OR SIGNS OF EXCESSIVE HEAT BUILD-UP.

SOME VEHICLES MAY EXHIBIT BRAKE ROTOR CHECKING OR SIGNS OF EXCESSIVE HEAT BUILD-UP.

SUBJECT REGARDING ON-VEHICLE CALIPER-MOUNTED BRAKE ROTOR MACHINING ACCESSORIES FROM ROTUNDA, FOR CERTAIN VEHICLES, ARE NOW AVAILABLE FOR SERVICE USE.

PROCEDURES ON CALIPER-MOUNT LATHE MACHINING SETUP.

IF AN E350 REQUIRES ROTOR AND HUB REPLACEMENT, A REVISED THICKER PLATE ROTOR IS NOW AVAILABLE.

TRANSMISSION- E4OD- HARSH/DELAYED 2-3 UPSHIFTS- VEHICLES WITH 7.3L DIESEL AND 49-STATE CALIBRATION- F-SERIES BUILT THROUGH 2/3/97 AND ALL 1996 E-350.

E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM.

DRIVELINE RESONANCE/VIBRATION BETWEEN 1400 AND 2000 RPM WITH THE TORQUE CONVERTER CLUTCH ENGAGED ON VEHICLES WITH...

SOME 7.3L DIESEL E40D EQUIPPED VEHICLES BUILT BETWEEN 5/15/96 AND 7/8/96 MAY EXHIBIT HARSH UPSHIFTS.

CONCERNS WITH BUMP STEER STEERING FEELING NOTED WHEN FRONT WHEELS / TIRES CONTACT ROAD SURFACE IRREGULARITIES.

This SKU is a front upper ball joint.

A BUMP STEER STEERING FEELING, NOTED WHEN THE VEHICLE'S FRONT WHEELS/TIRES CONTACT ROAD SURFACE IRREGULARITIES.

SUBJECT REGARDING TIRE BALANCE HINT.

ADDRESSING TIRE BALANCE HINTS.

FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH.

SERVICE INFORMATION FOR VEHICLES EXHIBITING STALL ON DECELERATION CONDITION.

DIAGNOSTIC GUIDES FOR OUT-OF-WARRANTY VEHICLES TO BE USED AS A MASTER COPY - DIAGNOSTIC GUIDES NO LONGER AVAILABLE FROM ADISTRA.

FOR CONCERNS OF STALLING, REFLASH PCM W/ 1996 CALIBRATION (R11 LEVEL).