1995 Ford E-350 TSBs

SUBJECT REGARDING ENGINE DIAGNOSTIC GUIDE FOR WARRANTY REIMBURSEMENT.

THIS BULLETIN STATES THAT REPLACEMENT UNDER WARRANTY OF CERTAIN SPECIFIED COMPONENTS ON ANY 7.3L DIT DIESEL VEHICLE,...

INFORMATION ON SUPER DUTY 7.3 DIT DIESEL ENGINE VEHICLES EXHIBITI LACK OF POWER.

SOME SUPER DUTY VEHICLES WITH 7.3L DIT DIESEL ENGINES MAY EXHIBIT 4X4 LIGHTS ON, 4X4 INOPERATIVE AND / OR MULTIPLE GEM CODES.

INFORMATION ON SUPER DUTY MODELS WITH 7.3L DIESEL ENGINES EXHIBITING ROUGH IDLE / MISS CONDITION.

BRIEF INFORMATION CONCERN VEHICLES EXHBITING EXTERNAL OIL LEAKS.

INFORMATION ON VEHICLES EXHIBITING ROUGH IDLE / MISS.

SUBJECT REGARDING EXTERNAL OIL LEAKS - REPEAT MESSAGE.

REPEAT MESSAGE REGARDING VEHICLES EXHIBITING ROUGH IDLE / MISS CONDITION.

EXHAUST LEAK AT EXHAUST MANIFOLDS--VEHICLE EQUIPPED WITH 7.0L 0R 7.5L ENGINE.

LACK OF POWER DUE TO FAILURE OF ENGINE TURBO BOOST

REPEAT MESSAGE, NO CHANGE- ROUGH IDLE/MISS.

COLD ENGINE UPPER KNOCK/TICK.

CONCERNS WITH EXTERNAL OIL LEAKS.

LOW RPM- 7.3L DIT ENGINE FAILS TO START- CODE 340 STORED IN MEMORY AND/OR ENGINE FAILS TO ACHIEVE RATED SPEED FOR 2-3...

LEAK - OIL LEAKAT ENGINE VALLEY PAN AND/OR HIGH PRESSURE OIL PUMP - VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE.

VIBRATION- DRIVELINE RESONANCE/VIBRATION BETWEEN 1400 AND 2000 RPM WITH CONVERTER CLUTCH ENGAGED DURING MEDIUM TO HEAVY...

EXHAUST - EXHAUST LEAK AT EXHAUST MANIFOLDS - VEHICLES EQUIPPED WITH 7.0L OR 7.5L ENGINE.

VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS.

REVISED EEC CALIBRATION HAS BEEN INCORPORATED IN PCM CALIBRATIONS FOR VEHICLES WHICH DISPLAY LACK OF POWER DUE TO TORQUE...

AIR CONDITIONING-LACK OF COOLING AT IDLE-A/C SYSTEM SHUTS OFF DUE TO HIGH SYSTEM PRESSURES-7.3L DI TURBO F-SERIES BUILT...

ROUGH IDLE OR MISS MAY BE DUE TO LOOSE INJECTOR HOLD DOWN BOLT.

LACK OF ACCELERATOR CONTROL WHEN MOVING OFF THE IDLE POSITION.

VEHICLES MAY EXHIBIT A POOR IDLE QUALITY AND/OR LOW OUTPUT AFTER THE ENGINE RETURNS TO IDLE SPEED.

LOW RPM, NO START, RUNS POORLY, STALL.

A HIGH NUMBER OF HIGH PRESSURE REXROTH PUMPS AND INJECTION PRESSURE REGULATORS (IPR) ARE BEING REPLACED DUE TO OIL...

ON VEHICLES WITH TRANSMISSION BUILD DATES PRIOR TO 9/20/95, THE OVERDRIVE CANCEL LAMP MAY BE ILLUMINATING AND DIAGNOSTIC...

HARD OR NO START, HESITATION, IDLE ROUGH, LOW POWER, MISSES, STALLS.

A LACK OF ACCELERATOR CONTROL WHEN MOVING OFF OF THE IDLE POSITION.

POOR IDLE QUALITY AND/OR LOW OUTPUT AFTER THE ENGINE RETURNS TO IDLE SPEED.

BRIEF INFORMATION ON VEHICLES EXHIBITING A STALL ON DECELERATION CONDITION.

BRIEF INFORMATION ON VEHICLES EXHIBITING LACK OF POWER CONDITION.

BRIEF INFORMATION VEHICLES EXHIBITING HARD START / NO START CONDITION.

REPEAT MESSAGE REGARDING A STALL ON DECEL CONDITION.

REPEAT MESSAGE REGARDING A HARD START / NO START CONDITION.

REPEAT MESSAGE REGARDING VEHICLES EXHIBITING A LACK OF POWER.

DTC'S P1211/1212 ICP PRESSURE HIGHER/LOWER THAN EXPECTED.

VEHICLE STALLS/QUITS WHILE DRIVING.

VEHICLE STALLS UPON ACCELERATION.

REPEAT MESSAGE, NO CHANGE: HARD START/ NO START.

EXCESSIVE WHITE SMOKE.

RECOMMENDED GUIDELINES FOR TOWING BEHIND RECREATIONAL VEHICLES.

WHEN THE AIR CLEANER IS BEING REPLACED, THE DRAIN MECHANISM ON THE BOTTOM OF THE AIR CLEANER CASE IS TO BE CLEANED OF OBSTRUCTIONS.

UNKNOWN

NEW AUXILLARY POWERTRAIN KIT.

UNKNOWN

THE FRONT END ACCESSORY DRIVE (FEAD) BELT MAY WEAR, SHRED AND/OR COME OFF DURING DECELERATION.

SOME VEHICLES MAY EXHIBIT BRAKE ROTOR CHECKING OR SIGNS OF EXCESSIVE HEAT BUILD-UP.

SOME VEHICLES MAY EXHIBIT BRAKE ROTOR CHECKING OR SIGNS OF EXCESSIVE HEAT BUILD-UP.

SUBJECT REGARDING ON-VEHICLE CALIPER-MOUNTED BRAKE ROTOR MACHINING ACCESSORIES FROM ROTUNDA, FOR CERTAIN VEHICLES, ARE NOW AVAILABLE FOR SERVICE USE.

PROCEDURES ON CALIPER-MOUNT LATHE MACHINING SETUP.

IF AN E350 REQUIRES ROTOR AND HUB REPLACEMENT, A REVISED THICKER PLATE ROTOR IS NOW AVAILABLE.

CONCERNS WITH BUMP STEER STEERING FEELING NOTED WHEN FRONT WHEELS / TIRES CONTACT ROAD SURFACE IRREGULARITIES.

This SKU is a front upper ball joint.

A BUMP STEER STEERING FEELING, NOTED WHEN THE VEHICLE'S FRONT WHEELS/TIRES CONTACT ROAD SURFACE IRREGULARITIES.

E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM.

INFORMATION ON AODE/4R7W TRANSMISSION MAIN CONTROL & CASE REPLACEMENT.

DRIVELINE RESONANCE/VIBRATION BETWEEN 1400 AND 2000 RPM WITH THE TORQUE CONVERTER CLUTCH ENGAGED ON VEHICLES WITH...

VEHICLES MAY BE HARD TO START AFTER THE FUEL INJECTORS HAVE BEEN REPLACED.

LACK OF POWER AND/OR LOW PERFORMANCE CONDITION CAUSED BY NO RETURN FUEL FLOW TO THE FUEL TANK.

HARD STARTING AFTER THE FUEL INJECTORS HAVE BEEN REPLACED.

SERVICE INFORMATION FOR VEHICLES EXHIBITING STALL ON DECELERATION CONDITION.

DIAGNOSTIC GUIDES FOR OUT-OF-WARRANTY VEHICLES TO BE USED AS A MASTER COPY - DIAGNOSTIC GUIDES NO LONGER AVAILABLE FROM ADISTRA.

SUBJECT REGARDING TIRE BALANCE HINT.

ADDRESSING TIRE BALANCE HINTS.