2003 Ford Crown Victoria TSBs

SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT...

WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING.

IDLE VIBRATION VEHICLES EQUIPPED WITH SINGLE EXHAUST.

ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS.

ENGINE VIBRATION AT IDLE ON VEHICLES EQUIPPED WITH SINGLE EXHAUST.

IGNITION LOCK CYLINDER BINDING ON POLICE INTERCEPTORS BUILT BEFORE 10/31/2003.

SERVICE CYLINDER HEAD GASKET FOR 4.6L APPLICATIONS.

FUEL PRESSURE RELIEF VALVE (SCHRADER VALVE) DISCONTINUED.

ENGINE-ROMEO BUILT 4.6L 2V-TICK NOISE FROM ENGINE-ENGINES BUILT BEFORE 9/17/2003.

REDUCTION IN POWER AT WIDE OPEN THROTTLE (WOT) AFTER EXTENDED IDLE.

LACKS POWER AT WIDE OPEN THROTTLE (WOT) AFTER EXTENDED IDLE.

LOW CHARGING SYSTEM VOLTAGE AFTER EXTENDED IDLE.

ENGINE KNOCK DURING INITIAL COLD START, THE KNOCK WILL CEASE AFTER THE ENGINE IS FULLY WARMED UP.

SOME DEDICATED CNG VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS DUE TO A LOSS OF INJECTOR PERFORMANCE, RESULTING FROM FUEL QUALITY.

DEDICATED COMPRESSED NATURAL GAS (CNG) ROUGH IDLE OR NO START WHEN COLD VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY.

POLICE INTERCEPTOR MAY EXHIBIT LOW CHARGING SYSTEM VOLTAGE AT IDLE.

ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED...

GRINDING TYPE NOISE FROM THE TIMING CHAIN AREA.

SOME VEHICLES, EQUIPPED WITH THE 4.6L 2V ENGINE, WITH AN ENGINE BUILD DATE PRIOR TO 8/29/03 MAY EXHIBIT AN ENGINE TICK...

POSSIBLE FUEL LEAK AT FILL VALVE - FILL VALVE SERVICE PART REVISIONS - CNG VEHICLES ONLY.

A POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE ON SOME CNG (COMPRESSED NATURAL GAS) VEHICLES.

OVERSPEED WARNING CHIME ACTIVATION WHEN TRAVELLING ABOVE 70 M PH / 110 KPH.

DEDICATED CNG REGULATOR BOWL KIT AVAILABLE.

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

REDUCTION IN POWER AT WIDE OPEN THROTTLE.

SAFETY BELT RETRACTION SPEED.

LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS.

AM FM AND CELLULAR PHONE RECEPTION INTERFERENCE .

DIAGNOSTIC TROUBLE CODE (DTC) P0442.

A NO CRANK/NO START. CONNECTOR C192 OR C146 NOT FULLY CONNECTED.

DIAGNOSTIC TROUBLE CODE (DTC) P1233 WITH POSSILE DRIVEABILITY OR NO START CONDITION.

INTERMITTENT HORN SELF-ACTIVATION.

INTERMITTENT HORN SELF-ACTIVATION.

COSMETIC CRACKING OF THE CENTER FLOOR PAN.

REAR AXLE SHAFT AND/OR AXLE BEARING PREMATURE WEAR.

SOME RETAIL CUSTOMERS MAY PERCEIVE THE OPERATION OF THE DASH LIGHT DIMMING FEATURE AS BEING FAULTY.

ON SOME VEHICLES THE HEADLAMPS REMAIN ILLUMINATED WHEN WIPERS ARE ACTIVATED AND THEN DEACTIVATED.

MALFUNCTION INDICATOR LAMPAND P0460 DTC IN MEMORY.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS.

MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0460 IN CONTINUOUS MEMORY.

MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0442 OR P0456.

INTERMITTENT RAPID FLASHING OF THE TURN SIGNALS.

MALFUNCTION INDICATOR LAMP (MIL) LIGHT ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P1405 OR P1406 WITH NO OTHER DTCS.

EXCESSIVE MOISTURE IN THE HEADLAMP ASSEMBLY.

HESITATION, BUCK OR SURGE DURING STEADY STATE DRIVING OR LIGHT ACCELERATION AT 30-60 MPH.

MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P0316 (ONLY) STORED IN MEMORY.

ERRATIC HEADLAMP OPERATION IN AUTOLAMP MODE.

A SERVICE PROCEDURE FOR POOR ADHESION OF THE DOOR TRIM PANEL CARPET INSERTS ON CERTAIN VEHICLES INCLUDING THE 2003 MARAUDER.

SOME VEHICLES INCLUDING THE 2003 MARAUDER BUILT FROM JOB1 THROUGH JUNE 11, 2002 MAY HAVE POOR ADHESION OF THE DOOR TRIM...

This article supersedes TSB 19-2026 to update the vehicle model years affected.

Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns...

Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns...

UNCOMMANDED WINDSHIELD WIPER OPERATION.

ALUMINUM CORROSION - SERVICE TIP.

BODY-COLLISION REPAIR UPDATES.

PROCEDURE TO ENABLE/DISABLE COURTESY LAMPS, WHEN DOORS ARE OPENED (DARK MODE).

SLOW OR BINDING SIDE DOOR GLASS OPERATION.

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

EMISSION RELATED SERVICE ACTION 04E12.

INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS.

SULPHUR SMELL FROM EXHAUST UNDER INVESTIGATION (QSF).

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK...

FUEL GAUGE READING THAT FLUCTUATES OR READS LOWER THAN THE ACTUAL FUEL TANK LEVEL.

FUEL GAUGE THAT COMES OFF FULL TOO QUICKLY OR READS LOWER THAN THE ACTUAL FUEL TANK LEVEL (ELECTRONIC OR ANALOG CLUSTER).

EXHAUST AIR RUSH NOISE AND LOWER POWER.

NEW PUSH TYPE FUEL CLIP AND CONNECTOR REMOVAL INSTRUCTIONS.

SOME POLICE INTERCEPTORS BUILT BEFORE 5/23/2002 MAY HAVE THE TAN AND PINK WIRES INTO ELECTRICAL CONNECTOR C2232D IN THE INCORRECT PIN LOCATIONS.

FORD: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.

FORD: THE LIGHTING CONTROL MODULE HAS EXTENDED WARRANTY COVERAGE, ON CERTAIN VEHICLES, DUE TO A POSSIBLE CRACK ON...

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.

DIAGNOSTIC TROUBLE CODE B1342 (RESTRAINTS CONTROL MODULE (RCM) FAULT.

BATTERY LAMP ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P1246 UNDER INVESTIGATION (QSF).

IGNITION SWITCH BINDING.

BATTERY WARNING LAMP ON WITH A DIAGNOSTIC TROUBLE CODE P1246 (GENERATOR LOAD INPUT FAILED) IN THE POWERTRAIN CONTROL MODULE (PCM).

MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTC'S) P0113 (INTAKE AIR TEMPERATURE SENSOR 1 CIRCUIT...

SUBJECT REGARDING REAR PARK BRAKE CLICKING NOISE.

NUMEROUS ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR (WSS) DTCS, SUCH AS C1145, C1155, C1165, C1175, C1296, C1297, C1298, C1299 AND C1222.

NUMEROUS ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR (WSS) DIAGNOSTIC TROUBLE CODES (DTCS).

BRAKE BOOSTER PUSH ROD ADJUSTMENT.

ACCELERATED WEAR OF FRONT BRAKE PADS UNDER INVESTIGATION (QSF).

UNEVEN REAR BRAKE PAD WEAR ON LONG WHEELBASE VEHICLES.

POLICE INTERCEPTOR VEHICLES MAY EXHIBIT ACCELERATED WEAR OF THE FRONT BRAKE LININGS.

ACCELERATED WEAR OF THE FRONT BRAKE PADS.

SOME VEHICLES EQUIPPED WITH A PASSIVE ANTI-THEFT SYSTEM (PATS) MAY EXHIBIT STEERING WHEEL LOCK AND TRANSMISSION SHIFT...

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK.

TRANSMISSION FAILURE WHERE THERE IS A LARGE AMOUNT OF METAL OR DEBRIS IN THE PAN.

LOSS OF 4TH GEAR (OVERDRIVE).

NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP.

SOME VEHICLES MAY EXHIBIT A CLICK OR RATTLE NOISE COMING FROM THE FRONT WHEEL AREA.

CUSTOMER SATISFACTION PROGRAM 04M05.

RADIATOR ALIGNMENT PIN GROUND CLEARANCE.

CUSTOMER SATISFACTION PROGRAM 03M03 - STEEL WHEEL ADDITIONAL COVERAGE.

THE GOODYEAR P225/60R16 EAGLE RS-A PLUS IS A NEW AND IMPROVED TIRE AVAILABLE FOR POLICE APPLICATIONS.

SQUEAK OR RUBBING NOISE FROM FRONT SUSPENSION - FRONT SPRING INSULATOR REVISED.

REAR AIR SUSPENSION HEIGHT ADJUSTMENT / SERVICE TIPS.

COSMETIC CRACKING OF LOWER CONTROL ARM BUSHING SLEEVE.

HARSH RIDE/SUSPENSION SITS LOW IN FRONT.

VEHICLES EQUIPPED WITH STEEL WHEELS BUILT BETWEEN APRIL 25, 2003 THOUGH MAY 11, 2003 MAY EXHIBIT HARSH RIDE CHARACTERISTICS DUE TO THE FRONT SPRINGS.

POWER STEERING PUMP NOISE THAT MAY DIFFER DEPENDING UPON BODY STYLE.

STEERING NIBBLE - SERVICE TIP.

PASSIVE ANTI-THEFT SYSTEM (PATS) DO NOT COME WITH A STEERING WHEEL LOCK.

EXCESSIVE POWER STEERING PUMP NOISE AT COLD START.

POWER STEERING LOWER ASSIST AT LOW SPEEDS / STEERING LIGHT FEEL AT HIGHER SPEEDS.

AM/FM AND CELLULAR PHONE RECEPTION INTERFERENCE - SERVICE TIP.

SAFETY BELT WEB STOP BUTTON SERVICE.

REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS.

SPEED CONTROL DEACTIVATION SWITCH ADJUSTMENT SERVICE PROCEDURE.

HIGH SIDE PRESSURE FLUCTUATIONS ON VEHICLES EQUIPPED WITH A FIXED SCROLL A/C COMPRESSOR.

CLIMATE CONTROL A/C SERVICE TECH TIPS.

NOISE-CLIMATE CONTROL-REGISTER VENT RATTLE WITH A/C BLOWER ON.

LACK OF AIR CONDITIONER (A/C) COOLING AND RESTRICTED/REDUCED AIR FLOW THROUGH THE A/C VENTS TYPICALLY DURING EXTENDED IDLING CONDITIONS.

GUIDANCE FOR CNG TANK INSPECTION FOR VEHICLES PRODUCED AFTER DECEMBER 2, 1996.

INSTALLATION OF OPTIONAL POLICE INTERCEPTOR PACKAGE UPGRADE KIT.

RADIO SUPPRESSION PKG (53M) REVISION.

FLICKERING ELECTRONIC INSTRUMENT CLUSTER DISPLAY, ELECTRONIC AUTOMATIC TEMPERATURE CONTROL DISPLAY, RADIO DISPLAY, AND/OR OVERHEAD CONSOLE DISPLAY.

SUBJECT REGARDING SEAT BELT BELTMINDER DEACTIVATING / ACTIVATING CLARIFICATION.

CHARGING SYSTEM - HIGH OUTPUT GENERATOR NOW AVAILABLE FOR SERVICING 2003 POLICE INTERCEPTOR VEHICLES.