1990 Ford Aerostar TSBs

INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS.

SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM.

INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP.

INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART.

FLUID- TRANSMISSION FLUID USAGE CHARTS.

TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP.

TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP.

HIGH ALTITUDE TRANSMISSION AVAILABLE.

SOME VEHICLES EQUIPPED WITH THE 4.0L OHV ENGINE MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A...

ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED.

SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK.

SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK.

FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR.

FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS.

SUBJECT REGARDING A NEW SERVICE CENTER SUPPORT THAT USES A THRUST BEARING (#3 AND #4) IN PLACE OF THRUST WASHERS HAS BEEN RELEASED.

FRONT AND REAR BUMPERS MADE OF XENOY PLASTIC HAVE HAD THE CONDUCTIVE PRIMER REMOVED FROM SERVICE PARTS.

WINDSHIELD AND INTERIOR GLASS - FOG/FILM.

DOOR-REPLACEMENT SLIDING - SERVICE TIP.

SHEET METAL-ROOF PANEL AND DRIP RAIL REPLACEMENT- SEAM SEALER APPLICATION PROCEDURE.*SD

FRONT DOOR GLASS TIPPING AND BINDING DURING DOWNWARD TRAVEL.

INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA.

CONCERNS WITH FRONT DRIVE AXLE FLUID MAY LEAK OUT OF THE VENT UNDER SOME DRIVING MODES ON SOME VEHICLES.

RECOMMENDED GUIDELINES FOR TOWING BEHIND RECREATIONAL VEHICLES.

TEMPERATURE GAUGE - FLUCTUATING AND /OR INACCURATE HIGH READINGS.

VEHICLE MAY EXHIBIT A MOAN WHEN TURNING - TO CORRECT THIS CONDITION, REPLACE THE HIGH PRESSURE HOSE WITH A TUNED HOSE.

SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS.

INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS.

ANNOUNCING THE FORD OEM AIR CONDITIONING RETROFIT KIT AVAILABILITY.

AIR CONDITIONING-POOR PERFORMANCE EVEN THOUGH A/C SYSTEM IS FUNCTIONING PROPERLY SERVICE TIPS.

OWNER NOTIFICATION PROGRAM INVOLVING THE FUEL TANK ON AFFECTED VEHICLES WHICH CAN DEVELOP CRACKS AT THE UPPER PORTION OF...

EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP.

INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM.

FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE.

THIS BULLETIN CONTAINS SERVICE TIPS WHEN SERVICING ANY BRAKE RELATED ROUGHNESS / PULL CONCERNS.

THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE.

BRAKES - BRAKE SERVICE - SERVICE TIPS.

THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE...

SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES.

MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP.

WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS.

VEHICLES MAY HAVE A DISCONNECT OF THE IGNITION CONTROL MODULE (ICM) CONNECTOR OR MOISTURE BUILDUP WITHIN THE CONNECTOR.

SERVICE TIP INFORMATION ON REVISED OIL PAN GASKET REPLACEMENT PROCEDURE.

FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS.

EXPERIENCING A RAPPING OR CLANGING NOISE WHEN THE STEERING WHEEL IS TURNED RAPIDLY OR WHEN TURNING ON A BUMPY ROAD SURFACE.

EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO.

INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE.