2004 Dodge Ram TSBs

DODGE: ELECTRONIC FUEL CONTROL ACTUATOR (FCA) AVAILABLE FOR SERVICE/NEW DIAGNOSTICS AVAILABLE FOR DTC P0251.

ENGINE OFF-IDLE SPEED LIMIT FEATURE TO PROTECT TURBOCHARGER WHEN VEHICLE IS NOT MOVING.

5.9L TURBO - DIESEL ENGINE SYSTEM ENHANCEMENTS.

5.9L TURBO-DIESEL ENGINE SYSTEM ENHANCEMENTS.

ALL VEHICLES - EVAPORATIVE LEAK DETECTION MONITOR ENHANCEMENT; RAM QUAD CABS VEHICLES HAVE COLD START ROUGH IDLE AND...

NEW WATER PUMP FOR 3.7L ENGINE - NO LONGER COMMON WITH 4.7L.

THROTTLE BODY COKING.

IDLE FLUCTUATION/DIAGNOSTIC TROUBLE CODES.

INACTIVE THROTTLE BODY IN COLD AMBIENT TEMPERATURES.

5.7L ENGINE LONG BLOCK REPAIR / REPLACE PROCEDURES.

THE CAMSHAFT SPROCKET RETAINING BOLTS MAY NOT HAVE BEEN PROPERLY TIGHTENED.

SOME TRUCKS EQUIPPED WITH CUMMINS DIESEL ENGINES WERE BUILT WITH ENGINE BLOCK FREEZE PLUGS, WHICH MAY NOT HAVE...

ENGINE DATA LABEL INFORMATION.

ERRONEOUS DIAGNOSTIC TROUBLE CODES (DTC'S) P0335 OR P0340 CRANKSHAFT OR CAMSHAFT POSITION LOST.

POOR CAB HEAT AND/OR SLOW ENGINE WARM UP IN COLD AMBIENT TEMPERATURES.

WHITE SMOKE, ENGINE STUMBLE/MISFIRE, OR FLAT SPOT IN ENGINE PERFORMANCE.

SOME TRUCKS EQUIPPED WITH THE NEW HIGH OUTPUT DIESEL ENGINE MAY HAVE BEEN BUILT WITH EXHAUST CLAMPS WITH WELDS THAT COULD CRACK AND SEPARATE.

GENERIC CUMMINS ENGINE CONTROL MODULE (PCM) PROCEDURE.

POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM FREEZES IN EXTREME COLD AMBIENT TEMPERATURES -- INVOLVES INSTALLING REVISED PCV SYSTEM COMPONENTS.

AXLE FLUID LEVEL. *KB

FRONT END SHIMMY ON 4X4 VEHICLES WHEN TRAVELING OVER ROUGH SURFACES IN THE ROAD.

POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM FREEZES IN EXTREME COLD AMBIENT TEMPERATURES.

LONG CRANK TIMES IN AMBIENT TEMPERATURES BELOW FREEZING.

TRANSIT FILM REMOVAL.

ERRONEOUS DIAGNOSTIC TROUBLE CODES.

ELECTRONIC THROTTLE CONTROL DIAGNOSTICS.

AXLE WHINE. *TT

LAUNCH SHUDDER. *TT

BUG DEFLECTOR LOOSE/RATTLING.

CERTAIN 2004 TRUCKS EQUIPPED 8-1/4 IN.

CERTAIN 2004 TRUCKS EQUIPPED 8-1/4 IN.

THE AXLES ARE LOCATED CONSIDERABLY HIGHER THAT THE ACTUAL FLUID LEVEL.

GENERIC POWERTRAIN CONTROL MODULE (PCM) PROCEDURE.

POWERTRAIN CONTROL MODULE INITIALIZATION.

POWERTRAIN CONTROL MODULE INITIALIZATION.

GENERIC POWERTRAIN CONTROL MODULE (PCM) PROCEDURE.

POWERTRAIN CONTROL MODULE (PCM) ELECTRICAL CONNECTOR SEAL CUSTOMER SATISFACTION NOTIFICATION NO.

CUMMINS DIESEL DIAGNOSTICS.

ELECTRONIC FUEL CONTROL (EFC) ACTUATOR AVAILABLE FOR SERVICE.

EMISSIONS RECALL E09 - NEW VECI LABELS.

POOR AIR CONDITIONER PERFORMANCE, SLOW FUEL GAUGE RESPONSE, AND DIAGNOSTIC TROUBLE CODES (DTC'S) P0341 AND P1757.

TRAILER TOWING MIRROR - NEW MIRROR GLASS LOCKING TAB - NEW REMOVAL PROCEDURE.

MUD OR DIRT MAY ACCUMULATE ON THE ROCKER PANEL CAUSING CUSTOMERS TO COMPLAIN THAT THEIR CLOTHING GETS DIRTY WHEN THEY ENTER OR EXIT THE VEHICLE.

FRONT POWER WINDOW BINDS.

REAR SUSPENSION VIBRATION WHILE DRIVING AT HIGHWAY SPEEDS.

STABILIZER BAR LINK NUT TORQUE SPECS CHANGED.

FRONT WHEEL BEARING HUB MIS-MACHINED.

45RFE/545RFE TRANS - DELAYED ENGAGEMENT DUE TO COOLER RETURN FILTER REPLACEMENT.

CUSTOMER SATISFACTION NO.

TRANSMISSION SOLENOID REPLACEMENT.

MALFUNCTION INDICATOR LAMP DIAGNOSTIC TROUBLE CODE P2097 P2099.

MALFUNCTION INDICATOR LAMP (MIL) ILLLUMINATION DIAGNOSTIC TROUBLE CODES P0401, P0403, P0404, P0405, P0406.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION DIAGNOSTIC TROUBLE CODES (DTC'S) P0403, P0404, P0405, P0406.

THE CERTIFICATION LABEL ON CERTAIN VEHICLES COMPLIES WITH FEDERAL REGULATIONS, BUT DOES NOT LIST THE MINIMUM TIRE/RIM...

TIRE, RIM AND INFLATION PRESSURE INFORMATION.

MINIMUN REAR ROTOR THICKNESS.

STEERING COLUMN SNAPPING OR TICKING SOUND.

DRIVEABILITY AND OBD II MONITOR IMPROVEMENTS.

RECOMMENDED 12V SWITCHED ACCESSORY SOURCES.