2004 Dodge Neon TSBs
36 Technical Service Bulletins across 9 categories
Categories
Electrical
10 bulletinsSecurity Module Lock Out After Entering the PIN to Unlock The Wireless Control Module (WCM)
Security Module Lock Out After Entering the PIN to Unlock The Wireless Control Module (WCM)
Generic Powertrain Control Module (PCM) Procedure This bulletin involves programming a generic PCM with software.
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test...
Read full bulletin
equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
Generic Powertrain Control Module (PCM) Procedure This bulletin involves programming a generic PCM with software.
GENERIC POWERTRAIN CONTROL MODULE (PCM) PROCEDURE.
Read full bulletin
*KB
POWERTRAIN CONTROL MODULE INITIALIZATION.
Read full bulletin
*KB
POWERTRAIN CONTROL MODULE INITIALIZATION.
Read full bulletin
*SC
MOPAR ACCESSORY REMOTE STARTER INOPERATIVE DUE TO HOOD SWITCH.
Read full bulletin
*TT
WOT ACCELERATION STUMBLE/NUMBER 4 SPARK PLUG WIRE APPEARANCE.
Read full bulletin
*TT
Engine
8 bulletinsPart Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications.
Read full bulletin
An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a Non-EGR application. Unless, the EGR Block-Off Plate is being transferred from the old engine.
Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four...
Read full bulletin
piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T-joints.~ 2. Fill the T-joint between the pan rail/gear housing and pan rail/rear seal retainer with sealant. Use Mopar Silicone Rubber Adhesive Sealant or equivalent. 3. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the oil pan flange.~ 4. The four piece gasket will need to be assembled to make a complete oil pan gasket. 5. Lay the oil pan gasket(s) onto the oil pan flange.~ 6. Ensure the oil pan gasket segment joints are properly aligned. 7. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the top of the oil pan gasket.~ 8. Install the oil pan. Starting from the center and working outward, tighten the oil pan bolts to 28 Nm [21 ft. lbs.].
Part Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications.
Read full bulletin
An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a Non-EGR application. Unless, the EGR Block-Off Plate is being transferred from the old engine.
Valve Body. These may cause over drive cycling.
MIL Illumination - DTC P1776 Solenoid Switch Valve Latched in LR Position
IDLE FLUCTUATION AND OR MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION DIAGNOSTIC TROUBLE CODES P0300, P0301, P0302, P0303 OR P0304.
Read full bulletin
*TT
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION -DIAGNOSTIC TROUBLE CODE (DTC) P1776 SOLENOID SWITCH VALVE LATCHED IN LR POSITION.
Read full bulletin
*MJ THIS BULLETIN REPLACES 21-008-04 DATED JUNE 1, 2004. *TT
IRREGULAR ENGINE SNAPPING SOUND.
Read full bulletin
*TT
Other
6 bulletinsUse of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry...
Read full bulletin
awareness regarding the use of aftermarket parts.
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to...
Read full bulletin
structural repair parts usage.
Disinfectant Solution Recommended for COVID-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry...
Read full bulletin
awareness regarding the use of aftermarket parts.
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to...
Read full bulletin
structural repair parts usage.
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states ...
Read full bulletin
(Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~
Steering
4 bulletinsREVISED POWER STEERING SYSTEM BLEEDING PROCEDURES.
Read full bulletin
*SC
POWER STEERING FLUID CONTAMINATION.
Read full bulletin
*TT
STEERING COLUMN CLICK SOUND.
Read full bulletin
*TT
LOWER STEERING COLUMN CLICK SOUND.
Read full bulletin
*TT
Lighting
3 bulletinsMOISTURE ACCUMULATION INSIDE A VENTED HEADLAMP ASSEMBLY CONDITION.
Read full bulletin
*TT
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair...
Read full bulletin
industry awareness regarding the use of recycled or salvage parts.
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair...
Read full bulletin
industry awareness regarding the use of recycled or salvage parts.
Pre-Delivery & Maintenance
2 bulletinsKEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number.
Read full bulletin
The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number.
Read full bulletin
The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
Fuel System
1 bulletinDUAL EXHAUST TIPS ARE NOT IN EQUAL FORE/AFT ALIGNMENT.
Read full bulletin
*EH
Suspension
1 bulletinFRONT HUB/HALF SHAFT CLICK/POP SOUND.
Read full bulletin
*TT
Software & Calibration
1 bulletinFLASH: DRIVEABILITY IMPROVEMENTS.
Read full bulletin
*TT THIS BULLETIN REPLACES PREVIOUS DATED 06-15-04. *TT