2001 Dodge Neon TSBs
47 Technical Service Bulletins across 14 categories
Categories
Other
10 bulletinsSUBJECT REGARDING WIRE SPLICE REPAIRS.
Read full bulletin
*SB
A CONDITION MAY EXIST WHERE THE FRONT SEAT BACK MAY RATTLE DUE TO EXTRA SHOULDER LENGTH ON THE SEAT BACK PIVOT BOLT.
Read full bulletin
*TT
SUBJECT REGARDING SAFETY SYSTEMS - VEHICLE MODIFICATIONS / REPAIR.
Read full bulletin
*TT
SUBJECT REGARDING ANTENNA MAST INSTALLATION FOR 2000 - 2001 MODEL YEAR VEHICLES.
Read full bulletin
*TT
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry...
Read full bulletin
awareness regarding the use of aftermarket parts.
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to...
Read full bulletin
structural repair parts usage.
Disinfectant Solution Recommended for COVID-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry...
Read full bulletin
awareness regarding the use of aftermarket parts.
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to...
Read full bulletin
structural repair parts usage.
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states ...
Read full bulletin
(Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~
Engine
9 bulletinsSOME VEHICLES MAY EXHIBIT ENGINE IDLE UNDERSHOOT/PERFORMANCE.
Read full bulletin
*TT
THIS BULLETIN REINFORCES A REQUIREMENT TO CEASE THE CURRENT PRACTICE OF USING SUPPLEMENTAL OIL ADDITIVE TREATMENTS IN ALL DAIMLERCHRYSLER ENGINES.
Read full bulletin
*TT
SOME VEHICLES MAY EXHIBIT POOR A/C PERFORMANCE AND / OR A/C EXPANSION VALVE NOISE.
Read full bulletin
THIS BULLETIN INVOLVES PROGRAMMING THE POWERTRAIN CONTROL MODULE (PCM) WITH NEW SOFTWARE AND REDUCING THE AMOUNT OF R134A REFRIGERANT IN THE SYSTEM TO 765 GRAMS (27 OZ OR 1.69 LBS). *TT
ON SOME VEHICLES, THE ENGINE MAY UNDERSHOOT THE NORMAL IDLE SPEED WHEN BRAKING THE VEHICLE TO A STOP WITH THE CLUTCH...
Read full bulletin
DEPRESS AND / OR EXHIBIT ENGINE ROUGHNESS IMMEDIATELY AFTER MANUALLY SWITCHING THE A/C SYSTEM OFF. *TT
INFORMATION REGARDING COMPRESSOR NOISE AT INITIAL ENGINE START-UP.
Read full bulletin
*JB
SUBJECT REGARDING AN A/C CLUNK TYPE SOUND AT INITIAL ENGINE STARTUP.
Read full bulletin
*TT
SOME VEHICLES MAY EXHIBIT POOR A/C OR ENGINE PERFORMANCE.
Read full bulletin
*TT
Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four...
Read full bulletin
piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T-joints.~ 2. Fill the T-joint between the pan rail/gear housing and pan rail/rear seal retainer with sealant. Use Mopar Silicone Rubber Adhesive Sealant or equivalent. 3. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the oil pan flange.~ 4. The four piece gasket will need to be assembled to make a complete oil pan gasket. 5. Lay the oil pan gasket(s) onto the oil pan flange.~ 6. Ensure the oil pan gasket segment joints are properly aligned. 7. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the top of the oil pan gasket.~ 8. Install the oil pan. Starting from the center and working outward, tighten the oil pan bolts to 28 Nm [21 ft. lbs.].
Valve Body. These may cause over drive cycling.
Steering
5 bulletinsINFORMATION ON NEW POWER STEERING FLUID.*SLC
DUE TO A DELAMINATION PROBLEM, THE ACCESSORY DRIVE BELT FOR THE POWER STEERING PUMP AND A/C COMPRESSOR MAY REQUIRE REPLACEMENT.
Read full bulletin
*TT
REVISED POWER STEERING SYSTEM BLEEDING PROCEDURES.
Read full bulletin
*SC
STEERING COLUMN CLICK SOUND.
Read full bulletin
*TT
LOWER STEERING COLUMN CLICK SOUND.
Read full bulletin
*TT
Electrical
5 bulletinsSOME VEHICLES MAY EXPERIENCE A NO START CONDITION IN COLD TEMPERATURES DUE TO 5 VOLT REGULATOR FAILURE IN THE SBEC PCM MODULE.
Read full bulletin
*JB
SUBJECT REGARDING CIRCUITS EFFECTED BY IGNITION OFF DRAW (IOD) FUSE.
Read full bulletin
*TT
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test...
Read full bulletin
equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
POWERTRAIN CONTROL MODULE INITIALIZATION.
Read full bulletin
*KB
POWERTRAIN CONTROL MODULE INITIALIZATION.
Read full bulletin
*SC
Body & Paint
4 bulletinsSUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT.
Read full bulletin
*SLC
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT.
Read full bulletin
*TT
A CONDITION MAY EXIST WHERE THE REAR WINDOW WILL NOT GO ALLTHE WAY DOWN.
Read full bulletin
*TT
THIS BULLETIN STATES THAT ALL FACTORY INSTALLED EQUIPMENT, SUCH AS A SUNROOF, MEET THE UPPER INTERIOR HEAD PROTECTION REQUIREMENTS OF FMVSS 201.
Read full bulletin
*TT
Transmission
2 bulletinsAUTOMATIC TRANSMISSION FLUID USAGE ATF+4.
Read full bulletin
*TT *MJ
INFORMATION REGARDING TRANSAXLE COOLER LINE SPLICE KIT.
Read full bulletin
*JB
Air Bags & Safety
2 bulletinsSUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES.
Read full bulletin
*TT
SEAT BELT CINCH BAR SERVICE FOR VARIOUS MODELS INCLUDING 2004 MODELS.
Read full bulletin
*TT
Suspension
2 bulletinsON SOME VEHICLES, THE FRONT SEAT BACK MAY RATTLE, OR HAVE A TORN PIVOT BOLT BUSHING.
Read full bulletin
*TT
FRONT HUB/HALF SHAFT CLICK/POP SOUND.
Read full bulletin
*TT
Pre-Delivery & Maintenance
2 bulletinsKEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number.
Read full bulletin
The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number.
Read full bulletin
The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
Lighting
2 bulletinsUse of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair...
Read full bulletin
industry awareness regarding the use of recycled or salvage parts.
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair...
Read full bulletin
industry awareness regarding the use of recycled or salvage parts.
HVAC & Climate
1 bulletinSOME VEHICLES MAY EXPERIENCE AN AUDIBLE A/C NOISE.
Read full bulletin
*SLC
Software & Calibration
1 bulletinTHIS TECHNICAL SERVICE BULLETIN CONTAINS BOTH UPDATED SELF-ADHESIVE SERVICE AND / OR DIAGNOSTIC MANUAL PAGES AND UPDATE...
Read full bulletin
PAGES REQUIRING HAND WRITTEN CHANGES TO EXISTING PAGES. *TT
Tires & Wheels
1 bulletinEXPERIENCING RATTLE NOISE COMING FROM THE WHEEL COVER OVER BUMPS.
Read full bulletin
*TT
Fuel System
1 bulletinSOME VEHICLES MAY EXHIBIT A COLD START TIP IN HESITATION WHEN ACCELERATING FROM A STOP IN AMBIENT TEMPERATURES BETWEEN...
Read full bulletin
10 DEGREES C AND 27 DEGREES C (50 DEGREES C AND 80 DEGREES F). *TT