2002 Dodge Durango TSBs
51 Technical Service Bulletins across 15 categories
Categories
Other
10 bulletinsSUBJECT REGARDING REMOTE KEYLESS ENTRY PROGRAMMING PROCEDURES.
Read full bulletin
*SLC
A CONDITION MAY EXIST WHERE THE SEAT LUMBAR ADJUSTER IS INOPERATIVE.
Read full bulletin
*TT
SUBJECT REGARDING SAFETY SYSTEMS - VEHICLE MODIFICATIONS / REPAIR.
Read full bulletin
*TT
Plate - Planetary
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry...
Read full bulletin
awareness regarding the use of aftermarket parts.
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to...
Read full bulletin
structural repair parts usage.
Disinfectant Solution Recommended for COVID-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry...
Read full bulletin
awareness regarding the use of aftermarket parts.
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to...
Read full bulletin
structural repair parts usage.
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states ...
Read full bulletin
(Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~
Engine
6 bulletinsService - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four...
Read full bulletin
piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T-joints.~ 2. Fill the T-joint between the pan rail/gear housing and pan rail/rear seal retainer with sealant. Use Mopar Silicone Rubber Adhesive Sealant or equivalent. 3. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the oil pan flange.~ 4. The four piece gasket will need to be assembled to make a complete oil pan gasket. 5. Lay the oil pan gasket(s) onto the oil pan flange.~ 6. Ensure the oil pan gasket segment joints are properly aligned. 7. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the top of the oil pan gasket.~ 8. Install the oil pan. Starting from the center and working outward, tighten the oil pan bolts to 28 Nm [21 ft. lbs.].
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual...
Read full bulletin
valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement please order kit 68253161AA. Insulator only used on Auto-RWD transmission Note: The color of the insulator is not relevant for service.
Part Description: Insulator in Lever Assembly - Valve Body - Trans Issue Description: The manual valve insulator,...
Read full bulletin
attaching rivet and an instruction sheet are now available as a kit. If the insulator requires replacement please order 68253099AA. Note: Insulator color is not relevant for service
Valve Body. These may cause over drive cycling.
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual...
Read full bulletin
valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement please order kit 68253161AA. Insulator only used on Auto-RWD transmission Note: The color of the insulator is not relevant for service.
Part Description: Insulator in Lever Assembly - Valve Body - Trans Issue Description: The manual valve insulator,...
Read full bulletin
attaching rivet and an instruction sheet are now available as a kit. If the insulator requires replacement lease order 68253099AA. Note: Insulator color is not relevant for service
Transmission
5 bulletinsSUBJECT REGARDING REVISION IN DIAGNOSTIC PROCEDURES AND LABOR OPERATION TIMES FOR RE TRANSMISSIONS.
Read full bulletin
*TT
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4.
Read full bulletin
*TT *MJ
Part Description: Seal - Shift Shaft on RFE transmissions Issue Description: This seal (04799346) is replaceable with...
Read full bulletin
Seal Kit (68235551AA), which includes a seal and retainer. The Seal Kit is applicable to all (5)45RFE transmissions.
56045489A$ - Neutral Safety Switch - Trans Assy 06036369AA Screw and Washer is now available as a service part , 2...
Read full bulletin
required to attach Neutral Start Switch
56045489A$ - Neutral Safety Switch - Trans Assy 06036369AA Screw and Washer is now available as a service part , 2...
Read full bulletin
required to attach Neutral Start Switch
Fuel System
4 bulletinsSUBJECT REGARDING FUEL CAP DIFFICULT TO REMOVE.
Read full bulletin
*SLC
SUBJECT REGARDING FLASH: MALFUNCTION INDICATOR LAMP ILLUMINATION FOR ERRONEOUS DIAGNOSTIC TROUBLE CODE P0456, EVAP MONITOR SMALL LEAK DETECTED.
Read full bulletin
*SLC
THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE DUE TO ERRONEOUS DETECTION OF A SMALL LEAK IN THE VEHICLE'S EVAPORATIVE SYSTEM.
Read full bulletin
*TT
FUEL CAP DIFFICULT TO REMOVE.
Read full bulletin
*TT
Body & Paint
4 bulletinsSUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT.
Read full bulletin
*SLC
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT.
Read full bulletin
*TT
PASSENGER COMPARTMENT FLOOR WATER LEAK.
Read full bulletin
*TT THIS BULLETIN SUPERSEDES BULLETIN 23-010-04 DATED 04-29-04. *TT
INTERMITTENT LOCKING/UNLOCKING OF DOORS WITHOUT ACTIVATING THE POWER DOOR LOCK SWITCH.
Read full bulletin
*TT
Pre-Delivery & Maintenance
4 bulletinsSUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO.
Read full bulletin
81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
Verify Reman part number availability.
Read full bulletin
Order the "R" part number for all orders: Warranty, Mopar, customer pay and service contract. Order "68" part number for New unsold units only.
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number.
Read full bulletin
The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number.
Read full bulletin
The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
Electrical
4 bulletinsCharging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test...
Read full bulletin
equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
POWERTRAIN CONTROL MODULE INITIALIZATION.
Read full bulletin
*KB
AIR CONDITIONING (A/C) COOLING COIL ODOR.
Read full bulletin
*TT
POWERTRAIN CONTROL MODULE INITIALIZATION.
Read full bulletin
*SC
Steering
3 bulletinsSUBJECT REGARDING CLICKING SOUND IN THE STEERING COLUMN / INTERMEDIATE SHAFT.
Read full bulletin
*TT
INFORMATION ON NEW POWER STEERING FLUID.*SLC
STEERING COLUMN SERVICE.
Read full bulletin
INFORMATION. SERVICE INFORMATION TUNEUPS. *TT
Brakes
2 bulletinsSUBJECT REGARDING DISCOLORED BRAKE FLUID.
Read full bulletin
*TT
DISCONNECTING THE PARK BRAKE RELEASE HANDLE WHEN SERVICING THE STEERING COLUMN OPENING COVER.
Read full bulletin
*TT
Suspension
2 bulletinsSUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY.
Read full bulletin
*TT
UPPER BALL JOINT EXTENDED WARRANTY.
Read full bulletin
*TT
Lighting
2 bulletinsUse of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair...
Read full bulletin
industry awareness regarding the use of recycled or salvage parts.
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair...
Read full bulletin
industry awareness regarding the use of recycled or salvage parts.
Air Bags & Safety
2 bulletinsPROCEDURES FOR SERVICING THE SEAT BELT LATCH PLATE CINCH BAR.
Read full bulletin
*TT
SEAT BELT CINCH BAR SERVICE FOR VARIOUS MODELS INCLUDING 2004 MODELS.
Read full bulletin
*TT
Software & Calibration
1 bulletinFLASH PROGRAMMING FAILURE RECOVERY.
Read full bulletin
*SLC
Tires & Wheels
1 bulletinCHROME WHEEL CARE. *SLC
Infotainment
1 bulletinINFORMATION REGARDING VEHICLES EQUIPPED WITH RADIOS WILL HAVE A NEW LOCKING RADIO ANTENNA CONNECTOR.
Read full bulletin
*SLC