2006 Dodge Caravan TSBs
42 Technical Service Bulletins across 12 categories
Categories
Engine
10 bulletinsPart Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications.
Read full bulletin
An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a Non-EGR application. Unless, the EGR Block-Off Plate is being transferred from the old engine.
Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four...
Read full bulletin
piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T-joints.~ 2. Fill the T-joint between the pan rail/gear housing and pan rail/rear seal retainer with sealant. Use Mopar Silicone Rubber Adhesive Sealant or equivalent. 3. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the oil pan flange.~ 4. The four piece gasket will need to be assembled to make a complete oil pan gasket. 5. Lay the oil pan gasket(s) onto the oil pan flange.~ 6. Ensure the oil pan gasket segment joints are properly aligned. 7. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the top of the oil pan gasket.~ 8. Install the oil pan. Starting from the center and working outward, tighten the oil pan bolts to 28 Nm [21 ft. lbs.].
Part Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications.
Read full bulletin
An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a Non-EGR application. Unless, the EGR Block-Off Plate is being transferred from the old engine.
Part Description: Valve Body Assembly Issue Description: Valve body design was changed between 2010MY and 2011MY applications.
Read full bulletin
To prevent mix matching valve bodies and solenoid packs the connectors are color coded.~ Valve bodies with a white connector can be used on 2010, 2009, 2008..., model years. Valve bodies with a gray connector can only be used on 2011, 2012, 2013..., model years.~ Solenoid packs with a white connector are used with 2010, 2009, 2008..., model years. Solenoid packs with a gray connector are used with 2011, 2012, 2013..., model years.
Transmission Kit with Torque Converter 1.
Read full bulletin
All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time usage. Vehicles built prior to 10/23/2015 requires Service Kit PN 68461214AA; includes Transmission Isolator PN 68264483AA, and Adaptation Bracket 68264479AA and Fastener Service Kit PN 68329056AA Vehicles built after on or after 10/23/2015 will require only the Fastener Service Kit PN 68329056AA. 2. All 3.6L/62TE equipped vehicles. If the vehicle you are repairing has a crack in the flex plate or failed pump bushing inspect and confirm that both (2) dowel pins are present in the engine block, which align the transmission center line to the crank shaft centerline and visually inspect the dowel alignment holes in the transmission case. If the holes are damaged or elongated the transmission should be replaced to prevent further damage to the transmission/flexplate or pump bushing due to the inability to properly align the engine to the transmission during the repair. 3. All 62TE equipped vehicles. If pump bushing is scored or damaged and the dowel pin alignment holes are ok, replace the pump assembly as opposed to complete transmission. 4. All 62TE equipped vehicles. If vehicle is jerking/slipping with MIL code(s) P0740 or P2764, check TCC Solenoid operation. If TCC Solenoid is ok, the codes are indicative of a torque converter failure. Replace the torque converter.
Valve Body. These may cause over drive cycling.
Part Description: Insulator in Lever Assembly - Valve Body - Trans Issue Description: The manual valve insulator,...
Read full bulletin
attaching rivet and an instruction sheet are now available as a kit. If the insulator requires replacement lease order 68253099AA. Note: Insulator color is not relevant for service
NAG1 (5A580) Valve Body As per Warranty Bulletin D-13-22, please use R2108213A$ valve body for all Warranty (W), Mopar...
Read full bulletin
(M) and Mopar Vehicle Protection (F) claims.~ Assembly also includes Filter (52108325AA) and Gasket (52108332AA).~
DODGE/CHRYSLER: BEHAVIOR OF HEADLAMP SWITCH FUNCTION MAY IMPACT LIGHTING SYSTEMS SUCH AS OVERLOAD SPIKE OF ELECTRICAL...
Read full bulletin
SYSTEMS, TURNING OFF OR UNANTICIPATED ILLUMINATION, FLICKERING OR DIMMING OF EXTERIOR AND/OR INTERIOR LIGHT WITH ENGINE IS AT IDLE SPEED, OR SINGLE LAMP IN EITHER INTERIOR OR EXTERIOR LIGHTING SYSTEM. MODELS 2005-2006 TOWN & COUNTRY, VOYAGER, CARAVAN AND GRAND CARAVAN. *PE
CLEANING PROCEDURE FOR THE MECHANICAL THROTTLE BODY.
Read full bulletin
*KB
Other
7 bulletinsUse of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry...
Read full bulletin
awareness regarding the use of aftermarket parts.
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to...
Read full bulletin
structural repair parts usage.
Disinfectant Solution Recommended for COVID-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry...
Read full bulletin
awareness regarding the use of aftermarket parts.
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to...
Read full bulletin
structural repair parts usage.
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states ...
Read full bulletin
(Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~
3RD ROW SEAT FRONT LEG WILL NOT RETRACT.
Read full bulletin
*TT
Electrical
6 bulletinsCharging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test...
Read full bulletin
equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
DODGE/CHRYSLER: SUPPLEMENTAL FRONT AIRBAG SENSORS ON ABOUT 310,000 CERTAIN VEHICLES MAY CRACK UNDER CERTAIN CONDITIONS...
Read full bulletin
AND ALLOW WATER TO ENTER INTO THE SENSOR. THESE SENSORS WERE ADDED TO ENHANCE THE PERFORMANCE OF THE VEHICLE'S AIRBAG SYSTEM; HOWEVER, A CRACKED SENSOR MAY NOT OPERATE PROPERLY IN A FRONTAL CRASH. A CRACKED SENSOR CAN ALSO ILLUMINATE THE AIRBAG WARNING LIGHT. RIGHT AND LEFT SUPPLEMENTAL FRONT AIRBAG SENSORS MUST BE REPLACED AND THE SENSOR WIRING HARNESS CONNECTORS MUST BE INSPECTED AND REPLACED, IF NECESSARY. CSC LETTER WAS REC'D. *PE
MIL ILLUMINATION - P0461 FUEL LEVEL SWITCH SENSOR #1 PERFORMANCE.
Read full bulletin
*KB
POWERTRAIN CONTROL MODULE INITIALIZATION.
Read full bulletin
*KB
OIL PRESSURE INDICATOR ILLUMINATED AND DTC P0522 STORED IN PCM.
Read full bulletin
THE CONSUMER MAY DESCRIBE THAT THE OIL PRESSURE INDICATOR IS ON WHILE DRIVING. *SC
DAIMLERCHRYSLER CORPORATION IS NOW OFFERING A PASSENGER AIRBAG DEACTIVATION WIRING PACKAGE.
Read full bulletin
TO INCLUDE 2006 CHRYSLER TOWN AND COUNTRY AND 300/TOURING. *TT
Lighting
4 bulletinsUse of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair...
Read full bulletin
industry awareness regarding the use of recycled or salvage parts.
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair...
Read full bulletin
industry awareness regarding the use of recycled or salvage parts.
CHRYSLER: THE PARK LAMPS REMAIN ILLUMINATED WHEN BOTH HEADLAMPS ARE ON AND THEN OFF, OR BOTH HEADLIGHTS FAIL TO...
Read full bulletin
ILLUMINATE WHILE PARK LAMPS REMAIN ILLUMNATED AFTER SWITCHING ON. MODELS 2005-2006 TOWN & COUNTRY, VOYAGER, GRAND CARAVAN, CARAVAN, GRAND VOYAGER. *PE
EXTERIOR LAMP - LENS FOGGING.
Read full bulletin
*NJ
Pre-Delivery & Maintenance
2 bulletinsKEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number.
Read full bulletin
The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number.
Read full bulletin
The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
Air Bags & Safety
2 bulletinsPart Description: Seat Belt - Retaining Button Kits.
Read full bulletin
Issue Description: Do not replace the entire seat belt if the seat belt web stop button is missing or damaged.~Belt Web Button:~ 1D1 - Light Graystone - 05093280AB Belt Web Button~1D5 - Medium Slate Gray - 05093280AB Belt Web Button~1DA - Pastel Slate Gray - 05093280AB Belt Web Button~1J3 - Medium Khaki - 05093283AB Belt Web Button~ZJ3 - Medium Khaki - 05093283AB Belt Web Button~1L2 - Light Natural Beige - 05114207AA Belt Web Button~BD1 - Light Graystone - 05093280AB Belt Web Button~ BD5 - Medium Slate Grey - 05093280AB Belt Web Button~ BDA - Pastel Slate Gray - 05093280AB Belt Web Button~ ZP7 - Deep Seamist Green - 05093280AB Belt Web Button~ 5JB571D1A$, 5JB571D5A$, 5JB571J3A$, 5JX141D1A$, 5JX141D5A$, 5JX141DVA$, 5JX141J3A$, 5JX14ZJ3A$, 1EY841D1A$, 1EY841D5A$, 1EY841J3A$, 1EY851D1A$, EY851D5A$, 1EY851J3A$ use the following mini Belt Web Buttons:~1D1 - Light Graystone - 05093285AB Mini Belt Web Button~1D5 - Medium Slate Gray - 05093285AB Mini Belt Web Button~1DV - Slate Gray - 05093285AB Mini Belt Web Button~1J3 - Medium Khaki - 05093286AB Mini Belt Web Button~ZJ3 - Medium Khaki - 05093286AB Mini Belt Web Button~ Position the button as originally installed, or use the opposite side as reference.~ Web Button Location CS:~Front Driver O/B: 690 +/- 10 mm~Front Passenger O/B: 435 +/- 10 mm~Rear O/B: 435 +/- 10 mm~Rear Center: 290 +/- 10 mm~Rear Center Mini: 854 +/- 10 mm~ Web Button Location RG/RS SWB:~Front O/B: 550 +/- 6 mm~2nd Row O/B: 558 +/- 6 mm~ 3rd Row O/B: 584 +/- 6 mm~Web Button Location RG/RS LWB:~Front O/B: 550 +/- 6 mm~ 2nd Row O/B: 518 +/- 6 mm (Exception 52029368A$, 04680197A$: 690 +/- 6 mm)~ 3rd Row O/B: 585 +/- 6 mm (Exception 1CK35BD1A$, 1CK35BD5A$, 1CK35ZJ3A$, 52029369A$, 52029370A$: 434 +/-6 mm)~ Apply a small dot of Bond-All Gel, p/n 04467709, around the backside hole of the female button. Press the female button over the post of the male that is sticking through the rearwar
PASSENGER AIR BAG DEACTIVATION.
Read full bulletin
*KB
Transmission
2 bulletins1-2 AND/OR 2-3 SHIFT HARNESS.
Read full bulletin
ERASING AND REPROGRAMMING THE POWERTRAIN CONTROL MODULE WITH NEW SOFTWARE IS NECESSARY. *KB
AUTOMATIC TRANSMISSION DIAGNOSTIC TEARDOWN PROCEDURE.
Read full bulletin
VARIOUS MODELS INCLUDING THE 2004 RAM TRUCK, DURANGO, SEBRING CONVERTIBLE, CHEROKEE, VISION, NEON, AND VOYAGER. *TT *SC
Body & Paint
2 bulletinsPOWER SLIDING DOOR ADJUSTMENT AND DIAGNOSIS AID.
Read full bulletin
*KB UPDATED 10/26/07. *NJ
CRACKED WINDSHIELD DUE TO BEING HIT BY A FOREIGN OBJECT LIKE A STONE.
Read full bulletin
*KB
Tires & Wheels
2 bulletinsTIRE PRESSURE MONITOR SYSTEM INFORMATION.
Read full bulletin
*KB
TIRE PRESSURE MONITOR - SYSTEM INFORMATION.
Read full bulletin
*TT
Brakes
2 bulletinsSNOW/WATER INGESTION INTO REAR BRAKE DRUM.
Read full bulletin
*KB
SNOW/WATER INGESTION INTO REAR BRAKE DRUM.
Read full bulletin
*TT
Steering
2 bulletinsREVISED POWER STEERING SYSTEM BLEEDING PROCEDURES.
Read full bulletin
*SC
RATTLE SOUND FROM STEERING WHEEL AREA.
Read full bulletin
*TT *SC
Fuel System
1 bulletinLOOSE FUEL CAP MESSAGE OR MALFUNCTION INDICATOR LAMP ILLUMINATION FOR DIAGNOSTIC TROUBLE CODE P0457 - EVAP SYSTEM - LOOSE FUEL CAP.
Read full bulletin
*TT