2001 Dodge Caravan TSBs

SUBJECT REGARDING REMOTE KEYLESS ENTRY PROGRAMMING PROCEDURES.

SUBJECT REGARDING ASSIST FEATURE INOPERATIVE ON QUAD OR SPLIT REAR BENCH SEATS.

SUBJECT REGARDING QUAD SEAT RELEASE HANDLE SCREW SHEARED OFF IN SHAFT.

SUBJECT REGARDING COOLING FAN SOUND/VIBRATION.

THIS BULLETIN INVOLVES INSTALLING A REVISED POWER SEAT ADJUSTER DRIVE BLOCK SCREW TO THE INBOARD SIDE OF THE POWER SEAT TRACK(S).

ON SOME VEHICLES, THE QUAD SEAT CUPHOLDER COMPENSATION FLAP IS BROKEN.

SOME CUSTOMERS MAY COMPLAIN OF A HOWL/ DRONE/ MOAN/ HUMMING/CYCLIC SOUND WHEN DRIVING AT SPEEDS BETWEEN 45 AND 70 MPH.

SOME VEHICLES MAY EXHIBIT MODERATE TO SEVERE HIGH WAY SPEED 45-60 MPH VEHICLE SURGE.

SOME VEHICLE OPERATORS MAY COMPLAIN OF A HOWL / DRONE / MOAN / HUMMING / CYCLIC SOUND WHEN DRIVING AT SPEEDS BETWEEN 45...

A CONDITION MAY EXIST WHERE THE REAR WIPER MAY BE INOPERATIVE OR INTERMITTENTLY INOPERATIVE.

SOME VEHICLES MAY EXHIBIT A POWER MODE THAT CLOSES THE LEFT GATE BUT WILL NOT OPEN THE LIFT GATE.

SOME VEHICLES MAY EXHIBIT A POWER MODE THAT CLOSES THE LIFT GATE, BUT DOES OPEN THE LIFT GATE.

SUBJECT REGARDING REMOTE KEYLESS ENTRY TRANSMITTER PROGRAMMING.

SUBJECT REGARDING WIRE SPLICE REPAIRS.

SUBJECT REGARDING SAFETY SYSTEMS - VEHICLE MODIFICATIONS / REPAIR.

SOME MINIVANS MAY EXHIBIT A HOWL SOUND WHEN DRIVING AT SPEEDS BETWEEN 45 AND 70 MPH AND THAT MAY BE MOST NOTICEABLE AT 58 - 60 MPH.

SUBJECT REGARDING QUAD SEAT CUPHOLDER TO FLOORMAT INTERFERENCE.

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry...

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to...

Disinfectant Solution Recommended for COVID-19

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry...

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to...

82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states ...

SUBJECT REGARDING STUCK OIL PRESSURE RELIEF VALVE FOR VEHICLES BUILT PRIOR TO JANUARY 1, 2002 EQUIPPED WITH A 3.3 L OR 3.8 L ENGINE.

SUBJECT REGARDING CAMSHAFT / BEARING SERVICE.

EXHIBITING ENGINE SAG / HESITATION AND/OR CLOSED THROTTLE START STALL, DIAGNOSTIC TROUBLE CODE P0123.

SUBJECT REGARDING BELT LIKE SQUEAL SOUND AT HIGH ENGINE RPM.

A CONDITION MAY EXIST AT IDLE, WITH THE COOLING FANS ON, A SOUND MAY BE HEARD AND / OR A VIBRATION MAY BE FELT INSIDE THE VEHICLE.

INFORMATION ON BELT-LIKE SQUEAL SOUND AT HIGH ENGINE RPM.

INFORMATION ON REPORTED INCIDENTS OF STUCK OIL PRESSURE RELIEF VALVE ASSEMBLIES.

SOME VEHICLES WERE BUILT AND SHIPPED TO DEALERS WITH CAMSHAFTS THAT MAY HAVE AN IMPROPERLY MACHINED OIL GROOVE.

THIS BULLETIN REINFORCES A REQUIREMENT TO CEASE THE CURRENT PRACTICE OF USING SUPPLEMENTAL OIL ADDITIVE TREATMENTS IN ALL DAIMLERCHRYSLER ENGINES.

THIS BULLETIN REINFORCES A REQUIREMENT TO CEASE THE CURRENT PRACTICE OF USING SUPPLEMENTAL OIL ADDITIVE TREATMENTS IN ALL DIAMLER CHRYSLER ENGINES.

OWNERS MAY COMPLAIN THAT THE ENGINE COOLING FANS RUNNING CONSTANTLY, COMING ON AS THE VEHICLE COMES TO A STOP, OR THAT...

RAPID RESPONSE TRANSMITTAL REGARDING INOPERATIVE REAR WIPER MOTOR.

INFORMATION ON DIAGNOSING ENGINE SAG / HESITATION AND / OR CLOSED THROTTLE START STALL CONDITION.

Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four...

Valve Body. These may cause over drive cycling.

Part Description: Insulator in Lever Assembly - Valve Body - Trans Issue Description: The manual valve insulator,...

CLEANING PROCEDURE FOR THE MECHANICAL THROTTLE BODY.

LONG CRANK OR IDLE FLUCATION IN COLD TEMPERATURE WITH E20 - E30 ETHANOL FUEL BLENDS.

RATTLE/KNOCKING SOUND FROM THE FRONT SUSPENSION.

IRREGULAR ENGINE SNAPPING SOUND.

PROCEDURE TO REMOVE THE HVAC ASSEMBLY WHEN SERVICING THE FRONT BLOWER MOTOR.

ENGINE SPARK KNOCK. *TT

SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT.

SUBJECT REGARDING QUARTER WINDOW WEATHERSTRIP LOOSE.

SUBJECT REGARDING SLIDING DOOR WHICH IS DIFFICULT TO OPEN OR CLOSE, B-PILLAR WEATHERSTRIP MISSING, DEFORMED, OR LOOSE.

SUBJECT REGARDING POWER SLIDING DOOR REVERSES DIRECTION DURING THE POWER CLOSE CYCLE, FALSE OBSTACLE DETECTION.

SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT.

VEHICLES MAY EXPERIENCE WIND NOISE, POSSIBLY DESCRIBED AS HOWL SOUND, MAY BE HEARD WHEN DRIVING AT HIGHWAY SPEEDS.

THIS BULLETIN INVOLVES REPLACING LOOSE OR MISSING SLIDING DOOR B PILLAR WEATHERSTRIP.

SOME VEHICLE OPERATORS MAY COMPLAIN OF NO HEAT IN ANY MODE, FROM THE FRONT RIGHT SIDE OF THE VEHICLE.

THIS BULLETIN STATES THAT ALL FACTORY INSTALLED EQUIPMENT, SUCH AS A SUNROOF, MEET THE UPPER INTERIOR HEAD PROTECTION REQUIREMENTS OF FMVSS 201.

ADVANCE SERVICE INFORMATION REGARDING ROOF RACK CROSS RAIL INSTALLATION.

A CONDITION MAY EXIST WHERE THE CHILD SEAT ANCHOR AND TETHER WIRES HAVE SURFACE RUST ON THEM.

INFORMATION REGARDING ROOF RACK NOISE / HOWL.

ON SOME VEHICLES THE INSTRUMENT PANEL / HOOD HINGE RATTLES.

SUBJECT REGARDING OUTSIDE MIRROR GLASS REPLACEMENT.

SUBJECT REGARDING POWER MODE CLOSES LIFTGATE BUT WILL NOT OPEN THE LIFTGATE.

SOME VEHICLES MAY EXHIBIT A GROWLING SOUND WHEN BEING SLID AND / OR A RATCHETING / CREAKING SOUND WHEN THE POWER SLIDING DOOR IS CINCHING CLOSED.

POWER SLIDING DOOR ADJUSTMENT AND DIAGNOSIS AID.

PASSENGER COMPARTMENT FLOOR WATER LEAK.

INSTRUMENT PANEL ILLUMINATION.

SOME VEHICLES NOT EQUIPPED WITH ANTI-SKID BRAKE SYSTEM (ABS) MAY HAVE THE ABS, BRAKE AND TRAC OFF LAMPS ILLUMINATED ON THE INSTRUMENT CLUSTER.

CONCERNS WITH THE ABS, BRAKE AND TRAC OFF CLUSTER LAMPS ILLUMINATED ON VEHICLES NOT EQUIPPED WITH ABS BRAKES.

SUBJECT REGARDING REAR BRAKE CYCLIC RUBBING SOUND FROM REAR OF VEHICLE DURING MEDIUM TO LIGHT BRAKE APPLICATION ON VEHICLES WITH REAR DRUM BRAKES.

SNOW/WATER INGESTION INTO REAR BRAKE DRUM.

ON SOME VEHCLES, THE POWER SEAT HAS SLIGHT FORE/AFT MOVEMENT MOST NOTICEABLE DURING ACCELERATION OR BRAKING.

A CONDITION MAY EXIST WHERE A LOW FREQUENCY HOWL / MOAN NOISE IS HEARD FROM THE REAR BRAKE AREA DURING LOW SPEED AND /...

ON SOME VEHICLES, WHILE DRIVING THROUGH DEEP OR BLOWING SNOW / WATER, THE SNOW / WATER MAY ENTER THE REAR BRAKE DRUMS...

A CONDITION MAY EXIST WHERE THE INSTRUMENT CLUSTER, OVERHEAD CONSOLE DISPLAY, HVAC CONTROL AND RADIO BUTTONS DO NOT...

SOME LOW MILEAGE VEHICLES MAY EXHIBIT A LOUD SQUEAL SOUND FROM THE REAR DISC BRAKES THAT IS MOST NOTICEABLE WHEN THE...

SNOW/WATER INGESTION INTO REAR BRAKE DRUM.

SNOW/WATER INGESTION INTO REAR BRAKE DRUM.

ANTI-LOCK BRAKE REAR WHEEL SPEED SENSOR REPLACEMENT.

SNOW/WATER INGESTION INTO REAR BRAKE DRUM.

ANTI-LOCK BRAKE REAR WHEEL SPEED SENSOR REPLACEMENT.

VEHICLES NOT EQUIPPED WITH ANTI-LOCK BRAKE SYSTEM (ABS) BRAKES MAY HAVE THE ABS, BRAKE, AND TRAC OFF LAMPS ILLUMINATED...

INFORMATION ON REMOVABLE FLOOR CONSOLE ELECTRICAL CONNECTOR.

ON SOME VEHICLES, THE ACCESSORY DRIVE BELT MAY SQUEAL OR THE BELT HAS JUMPED OFF THE PULLEYS.

A CONDITION MAY EXIST WHERE THE HEATED SEAT MAY BE INOPERATIVE DUE TO AN OPEN CIRCUIT IN THE HEATING ELEMENT.

SOME VEHICLES MAY EXPERIENCE AN INTERFERENCE CONDITION BETWEEN THE (CRS) COOLANT RECOVERY SYSTEM HOSE AND THE POWERTRAIN...

THIS BULLETIN PROVIDES INFORMATION RELATED TO THE ELECTRICAL SYSTEM TO CLARIFY SYSTEM OPERATION / FEATURES / DIAGNOSTIC...

SOME VEHICLES MAY EXPERIENCE A NO START CONDITION IN COLD TEMPERATURES DUE TO 5 VOLT REGULATOR FAILURE IN THE SBEC PCM MODULE.

SERVICE ACTION REGARDING VEHICLES SHIPPED WITH IGNITION OFF DRAW (IOD) FUSE INSTALLED.

SUBJECT REGARDING CIRCUITS EFFECTED BY IGNITION OFF DRAW (IOD) FUSE.

Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test...

POWERTRAIN CONTROL MODULE INITIALIZATION.

POWERTRAIN CONTROL MODULE INITIALIZATION.

POWERTRAIN WIRING HARNESS BRACKET PACKAGE.

BATTERY LIGHT ILLUMINATION, ERRONEOUS DIAGNOSTIC TROUBLE CODE (DTC) P1594.

SUBJECT REGARDING STEERING SHUDDER.

SUBJECT REGARDING POWER STEERING MOAN/GROAN SOUND.

INFORMATION ON POWER STEERING MOANING/GROANING SOUND.

EXPERIENCING A SHUDDER (VIBRATION) FELT INSIDE THE VEHICLE WHILE TURNING THE STEERING WHEEL.

EXPERIENCING A POP/TICK SOUND HEARD COMING FROM THE STEERING WHEEL AREA WHILE THE VEHICLE IS IN MOTION.

INFORMATION ON NEW POWER STEERING FLUID.*SLC

INFORMATION ON VEHICLES EXHIBITING A STEERING HISS OR SWOOSH SOUND.

REVISED POWER STEERING SYSTEM BLEEDING PROCEDURES.

STEERING SHUDDER. *TT

POP/TICK SOUND IN STEERING WHEEL AREA.

CONCERN WITH TAIL LAMP EXPERIENCING A LOOSE CONDITION.

SOME VEHICLES MAY EXHIBIT A RATTLE SOUND FROM THE QUAD SEAT(S) AND / OR 50 / 50 REAR BENCH SEAT(S) AND / OR A GROAN...

SOME VEHICLES MAY EXHIBIT A RATTLE SOUND FROM THE QUAD SEAT(S) AND / OR 50 / 50 REAR BENCH SEAT(S) AND / OR A GROAN...

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair...

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair...

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION, DIAGNOSTIC TROUBLE CODE (DTC) P0442, P0455, OR P0456 - LEAK DETECTION PUMP (LDP), LEAK DETECTED.

ERRONEOUS ACTUATION OF HORNS, HEADLAMPS, AND PARKING LAMPS WHILE VEHICLE IS PARKED.

AUTOMATIC TRANSMISSION FLUID USAGE ATF+4.

SUBJECT REGARDING GEAR SHIFT LEVER AND BRAKE TRANSMISSION SHIFT INTERLOCK (BTSI) SERVICE.

INFORMATION REGARDING TRANSAXLE COOLER LINE SPLICE KIT.

SURGE WITH TRANSMISSION AT FULL LOCK-UP.

AUTOMATIC TRANSMISSION DIAGNOSTIC TEARDOWN PROCEDURE.

SUBJECT REGARDING AIR CONDITIONER TEMPERATURE DIFFERENTIAL (STRATIFICATION) BETWEEN LEFT AND RIGHT FRONT PANEL OUTLETS.

CUSTOMER MAY COMPLAIN THAT THE HVAC DRAIN WATER LEAKS UNDER PASSENGER SIDE CARPET.

SUBJECT REGARDING POOR REAR AIR CONDITIONER PERFORMANCE - LOW OUTPUT FROM HEADLINER VENTS.

ADVANCE SERVICE INFORMATION REGARDING VEHICLES EXHIBITING WATER LEAKAGE FROM THE HEATER - A/C UNIT AIR FLITER ACCESS...

EXPERIENCING A SQUAWK / CREAK / GROAN SOUND FROM FRONT SUSPENSION WHILE DRIVING OVER ROUGH / BUMPY ROADS.

SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY.

ON SOME VEHICLES THE HOOD HINGE BUSHINGS MAY HAVE EXCESSIVE CLEARANCE THAT CREATES A RATTLE SOUND WHEN A SUBJECT VEHICLE IS DRIVEN OVER A ROUGH ROAD.

CREAKING/SQUAWKING SOUND FROM FRONT STRUT AREA.

SUBJECT REGARDING SERVICE / DIAGNOSTIC MANUAL REVISIONS.

SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO.

KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number.

KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number.

FLASH PROGRAMMING FAILURE RECOVERY.

THIS TECHNICAL SERVICE BULLETIN CONTAINS BOTH UPDATED SELF-ADHESIVE SERVICE AND / OR DIAGNOSTIC MANUAL PAGES AND UPDATE...

THIS TECHNICAL SERVICE BULLETIN CONTAINS BOTH UPDATED SELF-ADHESIVE SERVICE AND / OR DIAGNOSTIC MANUAL PAGES AND UPDATE PAGES.

SUBJECT REGARDING MALFUNCTION INDICATOR LAMP ILLUMINATION, ERRONOUS DIAGNOSTIC TROUBLE CODE (DTC) P0456, EVAP LEAK MONITOR 0.020 LEAK DETECTED.

A CONDITION MAY EXIST WHERE THE FUEL GAUGE INDICATOR VISIBLY DROPS 1/4 TO 1/2 TANK WHILE DRIVING.

VEHICLE WITH PROPERLY FUNCTIONING EVAPORATIVE EMISSIONS SYSTEM REPEATEDLY SETS DIAGNOSTIC TROUBLE CODE P0456 WHEN...

CHROME WHEEL CARE. *SLC

SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES.