1996 Dodge Caravan TSBs

SUBJECT REGARDING WIRE SPLICE REPAIRS.

SUBJECT REGARDING CHILD SEAT TETHER ANCHORS.

SUBJECT ON THE CHILD SEAT TETHER ANCHORS.

SUBJECT REGARDING CHILD SEAT TETHER ANCHORS.

THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS.

TEST

CONCERNS WITH HIGH EFFORT REQUIRED TO U NLATCH REAR BENCH SEATS FROM THE FLOOR.

THIS BULLETIN INVOLVES INTERMITTENT POPPING ON FRONT END.

CONCERNS WITH "HONK" NOISE DURING PARKING LOT MANEUVERS.

CONCERNS WITH "HONK" NOISE DURING PARKING LOT MANEUVERS.

CONCERNS WITH SERPENTINE BELT COMING OFF OR OUTBOARD RIBS OF BELT ARE FRAYED.

CONCERNS WITH THUMPING NOISE AT REAR OF VEHICLE DURING COLD OPERATION.

INFORMATION ON CHILD SEAT TETHER ANCHORS.

CONCERNS WITH SPEED CONTROL WHICH DOES NOT MAINTAIN SET SPEED WHILE CLIMBING A GRADE.

THIS BULLETIN EXPLAINS THE OPERATION AND APPLICATION OF THE LEAK DETECTION PUMP (LDP) MONITOR TEST.

EXPERIENCING TICK TYPE NOISE AT TOP OF LEFT B-PILLAR.

CONDITIONS WITH INTERMITTENT LOSS OF SPEED CONTROL.

SUBJECT PERTAINING TO SMOOTH ROAD HIGH-SPEED VIBRATION OR SHAKE CONDITION.

SUBJECT PERTAINING TO A TICKING TYPE NOISE AT TOP OF LEFT B-PILLAR.

SUBJECT REGARDING SAGS / HESITATION / STUMBLE / START & STALL.

RATTLE NOISE FROM REAR OF THE VEHICLE WHEN DRIVING OVER ROAD BUMPS.

A "HONK" OR SQUEAL NOISE DURING PARKING LOT MANEUVERS.

*DURING LOW SPEED VEHICLE EXPERIENCES SIDE TO SIDE OSCILLATION/WOBBLE WHILE DRIVING BETWEEN 10-45MPH.

35 MPH CYCLIC VIBRATION.

CREAK SOUND HEARD UPON ACCELERATION AND/OR DECELERATION- SOUND SEEMS TO COME FROM FLOORPAN/DASH AREA.

UNKNOWN

UNKNOWN

UNKNOWN

UNKNOWN

CRUISE CONTROL OVERSHOOT/UNDERSHOOT DURING INITIAL SET SPEED SELECTION.

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry...

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to...

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to...

SUBJECT REGARDING CAMSHAFT / BEARING SERVICE.

CONCERNS WITH THE PCV VALVE FREEZING UNDER EXTREMELY COLD CONDITIONS.

INFORMATION ON GASKET SURFACE PREPARATION ON ALUMINUM ENGINE COMPONENTS.

CONCERNS WITH ENGINE COOLANT USAGE.

CONCERNS WITH SERPENTINE BELT SLIPPING OFF IDLER PULLEY.

CONCERNS WITH FRONT AND / OR SLIDING DOOR POWER LOCK MOTORS MAKING A WHIRLING NOISE.

SUBJECT REGARDING OIL SEEPAGE AT CAM POSITION SENSOR / MISINTERPRETED HEAD GASKET LEAK.

A NEW MULTI-LAYER STEEL ( MLS ) HEAD GASKET HAS BEEN DEVELOPED AND IS BEING IMPLEMENTED INTO PRODUCTION VEHICLES.

SUBJECT ON LABOR OPERATION TIME CHANGE FOR DOMESTIC 2.OL DOHC AND 2.4L HEAD GASKET REPLACEMENT.

SUBJECT ON TIP-IN SAGS/HESITATIONS OR ROUGH IDLE AFTER A HOT SOAK RESTART.

CONDITION WITH UNDERHOOD NOISE DUE TO SERPENTINE BELT OUTBOARD RIBS FRAYING OR SPLITTING FROM THE MAIN PORTION OF THE...

VARIOUS CAR OWNER'S HAVE EXPRESSED INTEREST IN USING ENGINE COOLANTS MADE WITH PROPYLENE GLYCOL INSTEAD OF ETHYLENE GLYCOL.

VEHICLES WITH 3.0L ENGINES - INTAKE VALVE DEPOSITS - DRIVEWAY DIE OUT, ROUGH IDLE, LACK OF POWER, SAGS OR HESITATION.

2.4L CRANKSHAFT/CAMSHAFT TIMING.

FRONT HVAC BLOWER MOTOR RESISTOR CONNECTOR SERVICE.

ENGINES BUILT FROM MARCH 8, 1996 THROUGH MARCH 13, 1996- THE CAMSHAFT TIMING BELT TENSIONER AND BRACKET ASSEMBLY AND/OR...

BULLETIN SUPERSEDES TSB 08-36-95, DATED AUG.

BULLETIN APPLIES TO VEHICLES EQUIPPED W/ 2.4L ENGINE AND 41TE TRANSAXLE BUILT BEFORE NOV.

VEHICLES EQUIPPED WITH OPTIONAL VEHICLE THEFT SECURITY SYSTEM/VEHICLE THEFT ALARM (VTSS/VTA) MUST HAVE HAD THE ENGINE...

SOME VEHICLES EQUIPPED WITH A 3.3L OR 3.8L ENGINE MAY EXPERIENCE A RARE SINGLE ENGINE MISS, TYPICALLY AT HIGHWAY...

Valve Body. These may cause over drive cycling.

SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT.

SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT.

SUBJECT REGARDING OUTSIDE MIRROR GLASS REPLACEMENT.

EXPERIENCING A CHATTER SOUND COMING FROM THE SLIDING DOOR POWER LOCK ACTUATOR(S) WHEN THE POWER LOCK FEATURE IS REPEATEDLY ACTIVATED.

A CONDITION EXIST WHERE THE ROOF PANEL SURFACE EXHIBITS WAVINESS OR DEPRESSION(S) NEAR THE FRONT OF THE CHARACTER...

WINDNOISE AROUND FRON DOOR GLASS, ESPECIALLY AT TOP OF THE B PILLAR.

FRONT WINDSHIELD WIPERS SELF-ACTIVATE WHILE DRIVING OR WILL NOT TURN OFF.

WINDSHIELD WIPERS SELF-ACTUATE WHILE DRIVING OR WILL NOT TURN OFF.

SYMPTOMS WITH ROOF RACK RATTLES AT HIGHWAY SPEEDS.

WINDSHIELD WIPERS DO NOT PARK PROPERLY AND/OR WIPE IN THE INTERMITTENT MODE PROPERLY.

WINDSHIELD WIPERS DO NOT PARK PROPERLY AND/OR WIPE IN THE INTERMITTENT MODE PROPERLY.

DIFFICULT TO CLEAN LIGHT COLORED "CHALKY" RESIDUE FROM PLASTIC BODY COMPONENTS THAT ARE MOLDED IN BLACK.

BULLETIN SUPERSEDES TSB 23-65-95, DATED NOV.

THE COWL COVER END(S) ARE UNSNAPPED AT THE FRONT FENDERS(S).

SUBJECT REGARDING TRANSMISSION OIL COOLER LINE HOSE CLAMP SERVICE.

THIS BULLETIN INVOLVES TRANSMISSION FLUID AUXILIARY COOLER.

CONCERNS WITH 41TE/42LE TRANSAXLE SHUDDER DURING AN EMCC (ELECTRONICALLY MODULATED CONVERTER CLUTCH) SHIFT.

THIS BULLETIN INVOLVES TRANSAXLE KICKDOWN, LINKAGE WEARS THE WIRING HARNESS.

THIS BULLETIN ANNOUNCES THE AVAILABILITY AND INSTALLATION OF A RESUABLE AUTOMATIC TRANSMISSION OIL PAN GASKET.

SUBJECT REGARDING REUSABLE AUTOMATIC TRANSMISSION OIL PAN GASKET.

SERVICE AND PARTS INFORMATION ON 1999 RUNNING CHANGES TO TRANSMISSION RANGE SENSOR (TRS) *TT

INFORMATION ON DIAGNOSTIC / DRIVEABILITY IMPROVEMENTS, TRANSAXLE THAT INCORPORATES A TRANSMISSION RANGE SENSOR (TRS) ONLY.

SUBJECT ON DELAYED TRANSAXLE ENGAGEMENT.

CONDITION WITH TRANAXLE SHUDDER DURING A 3RD GEAR TO 3RD GEAR PARTIAL EMCC ( ELECTRONICALLY MODULATED CONVERTER CLUTCH)...

VEHICLE SHUDDER DURING TORQUE CONVERTER EMCC (LOCK UP) OPERATION/DIAGNOSTIC TROUBLE CODE 38.

CONCERN WITH WATER LEAK ONTO THE PASSENGER SIDE FLOOR FROM THE HVAC HOUSING.

EXHIBITING A PERIODIC BUMP IN POWER TRAIN WHEN THE A/C IS OPERATING

SUBJECT REGARDING A/C SUCTION AND / OR DISCHARGE LINE REQUIRES REPLACEMENT DUE TO CRACKING AT OR NEAR COMPRESSOR.

EXHIBITING A MOANING AND GROANING SOUND ACCOCIATED WITH A/C COMPRESSOR OPERATION.

SOME VEHICLES MAY EXPERIENCE A BUMP FEELING DURING A/C COMPRESSOR ENGAGEMENT.

WATER LEAKS ONTO THE PASSENGER SIDE FLOOR FROM THE HVAC HOUSING.

EXHIBITING A PERIODIC ''BUMP'' IN POWER TRAIN WHEN THE A/C IS OPERATING.

A/C SUCTION AND/OR DISCHARGE LINE SERVICE.

COOLANT SEEPAGE AT UNDERBODY AUXILLARY REAR HEATER LINE HOSE CONNECTION.

A/C BLOWS HOT AIR. AIR BLOWS THROUGH DEFROST OR PANEL OUTLETS ONLY.

SERVICE ACTION APPLIES TO VEHICLES BUILT AT WINDSOR PRIOR TO SEPT.

SNOW/WATER INGESTION INTO REAR BRAKE DRUM.

ON SOME VEHICLES, WHILE DRIVING THROUGH DEEP OR BLOWING SNOW / WATER, THE SNOW / WATER MAY ENTER THE REAR BRAKE DRUMS...

INFORMATION REGARDING SNOW / WATER ENTERING THE REAR BRAKE DRUMS.

REAR BRAKE MOAN/HOWL NOISE.

REAR BRAKE CYCLIC RUBBING NOISE.

BULLETIN APPLIES TO VEHICLES BUILT PRIOR TO DEC.

SNOW/WATER INGESTION INTO REAR BRAKE DRUM.

SNOW/WATER INGESTION INTO REAR BRAKE DRUM.

SNOW/WATER INGESTION INTO REAR BRAKE DRUM.

THIS BULLETIN CONTAINS PROCECURES TO REMOVE WAVINESS OR DEPRESSIONS FROM THE ROOF PANEL SURFACE.

EMISSIONS RECALL STATING THAT THE RADIATOR FAN RELAY MAY NOT TURN ON THE RADIATOR COOLING FANS.

INFORMATION REGARDING THE IGNITION SWITCH HOUSING SERVICE.

SOME VEHICLES MAY EXHIBIT A CONDITION WHERE THE POWERTRAIN CONTROL MODULE (PCM) RESETS WHILE THE CUSTOMERS IS DRIVING THE VEHICLE.

INFORMATION ON BODY CONTROL MODULE (BCM) REPLACEMENT.

BULLETIN APPLIES TO NS VEHICLES BUILT AT ST.

VEHICLE THEFT SECURITY SYSTEM VEHICLE THEFT ALARM (VTSS/VTA) ALARM ACTIVATION OR DEAD BATTERY WITH NO CHARGING SYSTEM MALFUNCTION.

Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test...

CONCERNS WITH THE AIR BAG WARNING INDICATOR LAMP ON INTERMITTENTLY OR CONSTANTLY.

SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES.

DAIMLERCHRYSLER CORPORATION IS NOW OFFERINB AIRBAG ON / OFF SWITCHES FOR SELECTED VEHICLES.

SUBJECT REGARDING AIRBAG ON - OFF SWITCHES.

SUBJECT REGARDING THE AIRBAG ON-OFF SWITCHES.

EXPERIENCING A POP/TICK SOUND HEARD COMING FROM THE STEERING WHEEL AREA WHILE THE VEHICLE IS IN MOTION.

A CONDITION WHERE A CLICK / RATTLE SOUND MAY BE HEARD COMING FROM THE AREA OF THE STEERING WHEEL WHILE THE VHICLE IS IN MOTION.

SOME VEHICLES EXPERIENCE A MOMENTARY LOSS OF POWER ASSIST FOR THE STEERING WHEN TURNING CORNERS WITH THE A/C OR...

DURING HIGH HUMIDITY CLIMATE CONDITIONS, SOME VEHICLES MAY EXPERIENCE A MOMENTARY LOSS OF POWER ASSIST FOR THE STEERING...

POP/TICK SOUND IN STEERING WHEEL AREA.

SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO.

INFORMATION ON 41TE/42LE SERVICE INFORMATION.

THIS TSB CONTAINS REVISED SERVICE AND/OR DIAGNOSTIC MANUAL PAGES.

BULLETIN SUPERSEDES TECHNICAL SERVICE BULLETIN 08-16-95, DATED APR.

Child Seat Tether Anchor Installation This bulletin describes procedures to install Child Seat Tether Anchors based on Customer Request.

EXPERIENCING A SQUAWK / CREAK / GROAN SOUND FROM FRONT SUSPENSION WHILE DRIVING OVER ROUGH / BUMPY ROADS.

SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY.

BULLETIN SUPERSEDES TECHNICAL SERVICE BULLETIN 23-54-95, DATED AUG.

COSMETIC CORROSION OR PERFORATION AT UPPER STRUT TOWER/S USUALLY BETWEEN THE STRUT AND UPPER LOAD PATH BEAM INNER PANEL (INNER FENDER).

FLASH PROGRAMMING FAILURE RECOVERY.

INFORMATION ON SERVICE PUBLICATION UPDATES.

SUBJECT ON FLASH PROGRAMMING FAILURE RECOVERY.

CONCERNS WITH A/C EVAPORATOR ODOR.

INFORMATION ON POOR DRIVABILITY WITH HIGH DI (DRIVABILITY INDEX) FUEL.

BULLETIN APPLIES TO VEHICLES BUILT PRIOR TO NOV.

VEHICLE OPERATOR MAY COMPLAIN OF POOR AM RADIO RECEPTION.

INFORMATION ON INSTALLATION OF RADIO TRANSMITTING EQUIPMENT.

INFORMATION ON TIRE AND WHEEL RUNOUT.

CUSTOMER MAY COMPLAIN OF LOW SPEED TIRE WOBBLE.

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair...

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair...