1996 Chrysler Sebring TSBs

EXHIBITING ROUGH IDLE, HARD START AND START & STALL.*CLS

INFORMATION ON NEW COMPONENTS AND A REPAIR PROCEDURE DEVELOPED TO REPLACE FAILED SEAT SLIDE MOTORS.

CUSTOMER MAY COMPLAIN OF POPPING/KNOCKING NOISE IN ENGINE COMPARTMENT.

CONCERNS ON ERRONEOUS MI; ILLUMINATION WITH HEX CODES $6A, ERRONEOUS PCM RESETS, SHIFT CYCLING, COLD ENGINE STUMBLE.

INFORMATION ON GASKET SURFACE PREPARATION ON ALUMINUM ENGINE COMPONENTS.

CONCERNS WITH ENGINE COOLANT USAGE.

TECHNICAL SERVICE BULLETIN REGARDING MULTI-LAYER STEEL (MLS) HEAD GASKET INSTALLATION PROCEDURES.

INFORMATION REGARDING 2.5L V-6 HEAD GASKET APPLICATION.

SUBJECT REGARDING OIL SEEPAGE AT CAM POSITION SENSOR / MISINTERPRETED HEAD GASKET LEAK.

A NEW MULTI-LAYER STEEL ( MLS ) HEAD GASKET HAS BEEN DEVELOPED AND IS BEING IMPLEMENTED INTO PRODUCTION VEHICLES.

SUBJECT ON LABOR OPERATION TIME CHANGE FOR DOMESTIC 2.OL DOHC AND 2.4L HEAD GASKET REPLACEMENT.

CONDITIONS WITH LIGHT KNOCKING OR TAPPING NOISE BEING HEARD FROM THE REAR SHOCK REAR WHILE TRAVELING OVER BUMPS.

VARIOUS INFORMATION REGARDING ENGINE COOLANT AND CORE PLUGS.

POWER STEERING SYSTEM NOISE FOLLOWING COLD ENGINE STARTS IN LOW AMBIENT TEMPERATURES.

UPSTREAM 02 SENSOR SHORTED TO VOLTAGE ALONG WITH POSSIBLE SYMPTOMS OF SAGGING/HESITATION OR ROUGH IDLE.

DISCUSSION: REGARDING IDLER AIR FLOW TEST FOR ABOVE MODELS LISTED MAY INDICATE AN ERRONEOUS FAILURE DUE TO INABILITY OF...

CONDITIONS WITH CONVERTIBLE TOP BINDS OR BECOME INOPERATIVE WHILE RAISING OR LOWERING AND/OR HYDRAULIC LEAKS FROM OR AROUND THE HYDRAULIC CYLINDER.

VARIOUS NOISES COMING FROM THE ENGINE COMPARTMENT.

VARIOUS CAR OWNER'S HAVE EXPRESSED INTEREST IN USING ENGINE COOLANTS MADE WITH PROPYLENE GLYCOL INSTEAD OF ETHYLENE GLYCOL.

INTERMITTENT SINGLE CYLINDER MISFIRE AND/OR MIL ILLUMINATED.

SAG/HESITATION ON ACCELERATION, OR ENGINE MISS.

2.4L CRANKSHAFT/CAMSHAFT TIMING.

BULLETIN APPLIES TO 1996 VEHICLES EQUIPPED W/ A 2.0L ENGINE (AVENGER/ SEBRING/TALON BUILT PRIOR TO NOV.

BULLETIN APPLIES TO '96 VEHICLES EQUIPPED W/ 2.5L ENGINE (AVENGER/SEBRING/ TALON BUILT PRIOR TO NOV.

NEW IN STOCK VEHICLES MAY EXHIBIT HARD STARTS, MISS-FIRE, OR ROUGH IDLE DUE TO SPARK PLUG FOULING.

Valve Body. These may cause over drive cycling.

Valve Body. These may cause over drive cycling.

Return: Wiring Assy - Engine You have been identified as either having stock, or have stock in transit to your dealership.

SUBJECT REGARDING WIRE SPLICE REPAIRS.

SUBJECT REGARDING CHILD SEAT TETHER ANCHORS.

SUBJECT ON THE CHILD SEAT TETHER ANCHORS.

SUBJECT REGARDING CHILD SEAT TETHER ANCHORS.

THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS.

VEHICLE MAY EXPERIENCE CONVERTIBLE TOP BEING PINCHED BETWEEN BOWS WHEN LOWERED.

CONCERNS THAT SEAT BACK CANNOT BE ADJUSTED BY LOWER RECLINER HANDLE.

CONCERNS WITH OBDII READINESS CODE RETENTION, FRDERAL PACKAGES.

INFORMATION ON CHILD SEAT TETHER ANCHORS.

CONDITIONS WITH INTERMITTENT LOSS OF SPEED CONTROL.

SOME VEHICLES EXHIBIT A WHISTLE ( WINDNOISE) COMING FROM THE " A " PILLAR AREA.

INTERMITTENT POPPING SOUND COMING FROM THE FRONT OF THE VEHICLE MAY BE HEARD FROM EITHER SIDE.

INFORMATION ON REMOTE KEYLESS ENTRY PROGRAMMING.

A SQUEAKING OR HARD RUBBING NOISE MAY BE HEARD FROM THE REAR OF THE VEHICLE WHEN TRAVELING OVER BUMPS.

KEYLESS ENTRY TRANSMITTER DIAGNOSTICS.

MIL ILLUMINATION WITH HEX CODE $3A.

MIL WITH VARIABLE DIAGNOSTIC TROUBLE CODES.

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry...

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to...

82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states ...

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to...

CBXDP361AA Return: Spacer Kit - Visor You have been identified as either having stock, or have stock in transit to your dealership.

SOME VEHICLES MAY EXHIBIT A CONDITION WHERE THE DOOR AJAR WARNING LIGHT AND DOME LIGHT MAY WORK INTERMITTENTLY OR MAY BECOME INOPERATIVE.

CONCERNS WITH TRUNK LID APPEARING UNEVEN WHEN OPENING.

CONSUMER MAY COMPLAIN THAT TOP DOES NOT FOLD PROPERLY AND/OR LINING PROTRUDES OUTSIDE WINDOW WITH TOP RAISED.

CONCERNS WITH SQUEAK IN MID SECTION OF BODY ON ROUGH ROADS.

CONCERNS WITH WIND NOISE/WATER LEAK AT TOP OF "A" PILLAR.

INFORMATION REGARDING GARAGE DOOR OPENER.

INFORMATION REGARDING HEADLINING SAGGING ABOVE REAR WINDOW DUE TO HOOK AND LOOP FASTENERSEPARATING FROM REAR WINDOW CURTAIN.

EXPERIENCING DOOR RATTLE WHEN GOING OVER BUMPSOR OTHER SIMILAR MOVEMENTS.

CONDITION WITH ROLLING CODE GARAGE DOOR OPENER.

PAINTED SURFACES OF THE VEHICLE MAY EXPERIENCE A "MILKY" OR "FOGGY" DISCOLORATION.

EXPERIENCING A WIND NOISE/WATER LEAK AT TOP OF

A SQUEAK FROM THE MID SECTION OF THE BODY MAY BE NOTICEABLE OVER ROUGH ROAD SURFACES OR OVER BUMPS.

SUBJECT PERTAINING TO WINDNOISE/WATERLEAK BETWEEN DOOR AND QUARTER GLASS.

DISCUSSING ROLLING CODE TECHNOLOGY AND IT'S FEATURES ON GARAGE DOOR OPENERS.

WINDNOISE AND/OR WATER LEAK COMING BETWEEN THE DOOR GLASS AND QUARTER GLASS.

SUNROOF SUNSHADE BINDING OR COMING OUT OF TRACK.

DIFFICULT TO CLEAN LIGHT COLORED "CHALKY" RESIDUE FROM PLASTIC BODY COMPONENTS THAT ARE MOLDED IN BLACK.

BULLETIN APPLIES TO TALON MODELS BUILT PRIOR TO JUN 1, 1995 (MDH 06-01-XX) AND AVENGER/SEBRING MODELS BUILT PRIOR TO AUGUST 2, 1995 (MDH 08-02-XX).

BULLETIN APPLIES TO VEHICLES BUILT BEFORE SEPT.

Inspect and Return: Trim Cover Assy - A-Pillar Rt/Lt You have been identified as either having stock, or have stock in transit to your dealership.

1NT30XDVAC - Inspect and Return: Panel - Instrument Panel You have been identified as either having stock, or have...

AUTOMATIC TRANSMISSION FLUID USAGE ATF+4.

CONCERNS WITH 41TE/42LE TRANSAXLE SHUDDER DURING AN EMCC (ELECTRONICALLY MODULATED CONVERTER CLUTCH) SHIFT.

THIS BULLETIN ANNOUNCES THE AVAILABILITY AND INSTALLATION OF A RESUABLE AUTOMATIC TRANSMISSION OIL PAN GASKET.

SUBJECT REGARDING REUSABLE AUTOMATIC TRANSMISSION OIL PAN GASKET.

SERVICE AND PARTS INFORMATION ON 1999 RUNNING CHANGES TO TRANSMISSION RANGE SENSOR (TRS) *TT

INFORMATION ON DIAGNOSTIC / DRIVEABILITY IMPROVEMENTS, TRANSAXLE THAT INCORPORATES A TRANSMISSION RANGE SENSOR (TRS) ONLY.

SUBJECT ON DELAYED TRANSAXLE ENGAGEMENT.

CONDITION WITH TRANAXLE SHUDDER DURING A 3RD GEAR TO 3RD GEAR PARTIAL EMCC ( ELECTRONICALLY MODULATED CONVERTER CLUTCH)...

VEHICLE SHUDDER DURING TORQUE CONVERTER EMCC (LOCK UP) OPERATION/DIAGNOSTIC TROUBLE CODE 38.

Inspect and Return: Solenoid Module - Transmission You have been identified as either having stock, or have stock in transit to your dealership.

SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES.

DAIMLERCHRYSLER CORPORATION IS NOW OFFERINB AIRBAG ON / OFF SWITCHES FOR SELECTED VEHICLES.

INFORMATION REGARDING NHTSA AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY.

SUBJECT REGARDING TWISTED SEAT BELTS.

SUBJECT REGARDING AIRBAG ON - OFF SWITCHES.

SUBJECT REGARDING THE AIRBAG ON-OFF SWITCHES.

AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY.

SEAT TRIM MATERIAL PULLS AWAY FROM SEAT BELT BEZEL.

SEAT BELT APPEARS TWISTED.

VEHICLES EXHIBITING FRONT COIL SPRING CREAKING, POPPING, OR SQUEAKING.

SUBJECT ON REPROGRAM POWERTRAIN CONTROL MODULE.

Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test...

Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test...

P/N CBSZR068AA: Inspect & Return: Module Kit - Occupant Restraint You have been identified as either having stock, or...

SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO.

INFORMATION ON 41TE/42LE SERVICE INFORMATION.

SUBJECT REGARDING I/M ( INSPECTION MAINTENANCE ) TESTING - OBD II "CARB" READINESS MONITOR INFORMATION.

BULLETIN SUPERSEDES TECHNICAL SERVICE BULLETIN 08-16-95, DATED APR.

CONCERNS WITH A/C EVAPORATOR ODOR.

INFORMATION ON POOR DRIVABILITY WITH HIGH DI (DRIVABILITY INDEX) FUEL.

SOME VEHICLES MAY EXHIBIT A WHINE OR MOAN NOISE COMING FROAM THE FUEL TANK AREA.

RATTLE FROM FUEL FILLER CREATED WHEN FUEL DOOR BUMPER FALLS OUT OF FUEL DOOR HOUSING.

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair...

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair...

05182535AD - Lamp Assy ?Tail Light LT You have been identified as either having stock, or have stock in transit to your dealership.

Return: Lamp Assy - CHMSL& Cargo Light You have been identified as either having stock, or have stock in transit to your dealership.

CONCERNS WITH POWER STEERING BELT ALIGNMENT.

PROCEDURES ON ALIGNING THE POWER STEERING BELT.

CONDITION WITH CLUNKING OR RATTLING IN STEERING/WHEEL COLUMN.

SUBJECT ON FLASH PROGRAMMING FAILURE RECOVERY.

Warranty Operations Newsletter Updates from Warranty Operations

Warranty Operations Newsletter Updates from Warranty Operations

SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY.

A LIGHT THUMP, CHUCKLE, OR CREAK NOISE MAY BE HEARD FORM THE REAR OF THE VEHICLE WHILE DRIVING OVER SMALL TO MEDIUM...

INFORMATION ON MICHELIN P215/55R 16 XGT 4 91S TIRE.

INFORMATION ON TIRE AND WHEEL RUNOUT.

CONDITION WITH THE A/C SYSTEM PERFORMANCE.

DOOR TRIM DEFROSTER GARNISH SERVICE.

EXHIBITTING A CONDITON WHERE THE STEERING WHEEL SHAKES OR THE BRAKE PEDAL PULSATES DUE TO PREMATURE WEAR OF FRONT BRAKE ROTORS AND PADS.

INFORMATION ON INSTALLATION OF RADIO TRANSMITTING EQUIPMENT.