2002 Chevrolet Trailblazer Ext TSBs

conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.

conductive finish.

conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.

location.

and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.

personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.

issue.

issue.

and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.

engine is started while diagnosing for noise from the engine or transmission.

and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.

GM does not endorse any repairs that involve welding, bending, straightening o re-machining. Only cosmetic refinishing of the wheel's coatings, using recommended procedures, is allowed. Evaluating Damage In evaluating damage, it is the GM Dealer's responsibility to inspect the wheel for corrosion, scrapes, gouges, etc. The Dealer must insure that such damage is not deeper than what can be sanded or polished off. The wheel must be inspected for cracks. If cracks are found, discard the wheel. Any wheels with bent rim flanges must not be repaired or refinished. Wheels that have been refinished by an outside company must be returned to the same vehicle. The Dealer must record the wheel ID stamp or the cast date on the wheel in order to assure this requirement. Refer to Refinisher's Responsibility Outside Company later in this bulletin.

GM does not endorse any repairs that involve welding, bending, straightening o re-machining. Only cosmetic refinishing of the wheel's coatings, using recommended procedures, is allowed. Evaluating Damage In evaluating damage, it is the GM Dealer's responsibility to inspect the wheel for corrosion, scrapes, gouges, etc. The Dealer must insure that such damage is not deeper than what can be sanded or polished off. The wheel must be inspected for cracks. If cracks are found, discard the wheel. Any wheels with bent rim flanges must not be repaired or refinished. Wheels that have been refinished by an outside company must be returned to the same vehicle. The Dealer must record the wheel ID stamp or the cast date on the wheel in order to assure this requirement. Refer to Refinisher's Responsibility Outside Company later in this bulletin.

A/C comes on.

correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.

GENERAL MOTORS WILL ONLY SUPPORT A TIRE CALIBRATION FOR TIRES THAT HAVE BEEN SIZED, TESTED AND DESIGNED FOR THE VEHICLE IN QUESTION AND ITS APPLICATIONS. TECHNICIAN SHOULD NOT USE THE INFORMATION THAT IS PROVIDED BY THE ANTILOCK BRAKING SYSTEM TIRE SIZE SELECTION.

SOME VEHICLES CONTAIN A FUEL TANK INLET CHECK VALVE (ICV) THAT COULD FRACTURE. THE ICV IS LOCATED ABOVE THE FULL FUEL LEVEL. A FRACTURED ICV COULD ALLOW FUEL VAPORS TO PASS THROUGH AND DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK AS IT PASSES OVER THE FRACTURE DURING REFUELING. IF THE ICV FRACTURES, THE VEHICLES SERVICE ENGINE SOON (SES) LIGHT MAY ILLUMINATE, AND THE OWNER MAY NOTICE A FUEL ODOR AND/OR A FEW DROPS OF FUEL ON THE GROUND WHEN REFUELING THE VEHICLE. DEALERS ARE TO REPLACE THE FUEL TANK.

SOME 2004 MODEL YEAR BUICK RAINIER, 2003-2004 MODEL YEAR CHEVROLET SSR, 2002-2004 MODEL YEAR CHEVROLET TRAILBLAZER, CHEVROLET TRAILBLAZER EXT, GMC ENVOY, GMC ENVOY XL, AND OLDSMOBILE BRAVADA, AND 2004 MODEL YEAR GMC ENVOY XUV VEHICLES CONTAIN A FUEL TANK INLET CHECK VALVE (ICV) THAT COULD FRACTURE. THE ICV IS LOCATED ABOVE THE FULL FUEL LEVEL. A FRACTURED ICV COULD ALLOW FUEL VAPORS TO PASS THROUGH AND DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK AS IT PASSES OVER THE FRACTURE DURING REFUELING. IF THE ICV FRACTURES, THE VEHICLES SERVICE ENGINE SOON (SES) LIGHT MAY ILLUMINATE, AND THE OWNER MAY NOTICE A FUEL ODOR AND/OR A FEW DROPS OF FUEL ON THE GROUND WHEN REFUELING THE VEHICLE. DEALERS ARE TO REPLACE THE FUEL TANK.

A CUSTOMER MAY IDENTIFY A CONCERN OF UNABLE TO REACTIVATE A VEHICLE'S ONSTAR THAT HAS BEEN PREVIOUSLY DISABLED BY ONSTAR. DEALER IS TO CALL GENERAL MOTORS TECHNICAL ASSISTANCE CENTER FOR FURTHER ASSISTANCE IF THE CONCERN IS STILL PRESENT.

GASKET SEALING SURFACES.

A FUEL TANK INLET CHECK VALVE (ICV) COULD FRACTURE. THE ICV IS LOCATED ABOVE THE FULL FUEL LEVEL. A FRACTURED ICV COULD ALLOW FUEL VAPORS TO PASS THROUGH AND DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK AS IT PASSES OVER THE FRACTURE DURING REFUELING. IF THE ICV FRACTURES, THE VEHICLES SERVICE ENGINE SOON (SES) LIGHT MAY ILLUMINATE, AND THE OWNER MAY NOTICE A FUEL ODOR AND/OR A FEW DROPS OF FUEL ON THE GROUND WHEN REFUELING THE VEHICLE. IF THE CONDITION OCCURS WITHIN THE STATED TERMS, THE FUEL TANK WILL BE REPLACED.

A FUEL TANK INLET CHECK VALVE (ICV) COULD FRACTURE. THE ICV IS LOCATED ABOVE THE FULL FUEL LEVEL. A FRACTURED ICV COULD ALLOW FUEL VAPORS TO PASS THROUGH AND DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK AS IT PASSES OVER THE FRACTURE DURING REFUELING. IF THE ICV FRACTURES, THE VEHICLES SERVICE ENGINE SOON (SES) LIGHT MAY ILLUMINATE, AND THE OWNER MAY NOTICE A FUEL ODOR AND/OR A FEW DROPS OF FUEL ON THE GROUND WHEN REFUELING THE VEHICLE. IF THE CONDITION OCCURS WITHIN THE STATED TERMS, THE FUEL TANK WILL BE REPLACED.

A CUSTOMER MAY IDENTIFY A CONCERN OF UNABLE TO REACTIVATE A VEHICLE'S ONSTAR THAT HAS BEEN PREVIOUSLY DISABLED BY ONSTAR. DEALER IS TO CALL GENERAL MOTORS TECHNICAL ASSISTANCE CENTER FOR FURTHER ASSISTANCE IF THE CONCERN IS STILL PRESENT.

REGARDING THE ADJUSTABLE COMFORT AND CUSTOM UPHOLSTERY OF THE DRIVER AND THE PASSENGER HEAD RESTRAINT. *PE

*PE UPDATED 2/17/09. *PE

INOPERATIVE, RADIO INOPERATIVE, FLASHER INOPERATIVE. *TT

*SC UPDATE. *TT

SECURITY LIGHT MAY BE ON OR OFF. 4.2 LL8 ENGINE. *NM

*MR

It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is completed in parallel instead of the technician needing to update one module at a time. This allows a more streamlined approach for dealers and customers.

condition of MIL Illuminated with Multiple Fuel Trim and/or Oxygen Sensor Codes Set.

tried to provide a software update to the OnStar hardware in your vehicle. However, your system could not be updated remotely. As a result, some of your OnStar system functions may not be working as expected." The customer is further instructed in this letter to "Please contact your dealer or any dealer near you as soon as possible to schedule an appointment for this no-cost software update. Your dealer will reprogram your OnStar module with an update. This is for vehicles that have previously received the Canada upgrade as described in Service Bulletin #15-08-44-001F."

MODE AFTER THE ONSTAR CANADA UPGRADE TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE.

MODE AFTER THE ONSTAR CANADA UPGRADE, TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE.

DRAIN TEST FOR THE ONSTAR MODULE. WHEN PERFORMING BATTERY PARASITIC DRAIN TEST, THERE MAY BE SOME CONFUSION AS TO WHAT THE NORMAL POWER CONSUMPTION READING SHOULD BE FROM THE ONSTAR SYSTEM.

DRAIN TEST FOR THE ONSTAR MODULE. WHEN PERFORMING BATTERY PARASITIC DRAIN TEST, THERE MAY BE SOME CONFUSION AS TO WHAT THE NORMAL POWER CONSUMPTION READING SHOULD BE FROM THE ONSTAR SYSTEM.

ALSO INCLUDING BUICK RAINIER 2002, 2003. *MR

E4398, E4399, E4401, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491, E4492, or E6961 and resolution information.

Only).

Spin-On Oil Filters.

Only).

and Canada.

Spin-On Oil Filters.

Spin-On Oil Filters.

Spin-On Oil Filters.

operations to claim when the concern cannot be duplicated. Also provides information on how to submit claims within the global warranty managment.

operations to claim when the concern cannot be duplicated. Also provides information on how to submit claims within the global warranty managment.

Allegation Resolution (PAR) claim.

Allegation Resolution (PAR) claim.

THE VEHICLE MAY BE UNABLE TO CONNECT TO ONSTAR USING THE WHITE, BLUE OR RED ONSTAR BUTTONS.

Fog/Driving Lamp Damage.

Accessories.

*AK FB2

*SC

GM ADMINISTRATIVE MESSAGE. *NM

Replacement Guidelines.

Some customers may comment that one or more of their vehicle's underbody components are showing some form of corrosion. This corrosion may be red in appearance (rust) if the component is steel, forged iron or cast iron. This corrosion may also be grey or white in color if the component is constructed of an aluminum alloy.

Some customers may comment that one or more of their vehicle's underbody components are showing some form of corrosion. This corrosion may be red in appearance (rust) if the component is steel, forged iron or cast iron. This corrosion may also be grey or white in color if the component is constructed of an aluminum alloy.

MAY BE CAUSED BY BROKEN WELDS OR CRACKS FORMED AROUND THE TWO INNER WELDS. *KB

*TT

THE VEHICLE'S XM RADIO ONLY HAS XM PREVEIW CHANNELS.

*TC

*TC UPDATE. *TT

(REGROUND EBCM GROUND). *KB

*EH

*TT UPDATE. *TT

The damage is being caused either in the removal process by the technician, or inadequate packaging or shipping. This bulletin advises the dealers to be more careful not to damage the transmissions during removal and to package the core properly for return.

the throttle plate is opened rapidly and advises the customer that it is normal for the delay.

repairs requiring balance and Road Force measurement.

repairs requiring balance and Road Force measurement.

customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.

SPECIAL COVERAGE ADJUSTMENT - FUEL TANK MODULAR RESERVOIR ASSEMBLY CORROSION. CSC LETTER WAS RECEIVED. UPDATED 11/6/08. *PE UPDATED 5/5/09. CSC LETTER WAS RECEIVED. *PE

A CONDITION OF THE REAR ENTERTAINMENT SYSTEM NOT OPERATING AS INTENDED IN COLDER AMBIENT TEMPERATURE AREAS DUE TO CALIBRATION CONCERNS.