2000 Chevrolet T Series TSBs
54 Technical Service Bulletins across 12 categories
Categories
Engine
24 bulletinsTHIS MESSAGE ANNOUNCES RECALL 02006 REGARDING A CONDITION IN WHICH THE CLUTCH MASTER CYLINDER PUSH ROD END THAT ATTCHES...
Read full bulletin
TO THE CLUTCH PEDAL PIN MAY WEAR TO THE POINT OF NOT PERFORMING AS INTENDED. *TT
SUBJECT REGARDING POWER STEERING PUMP NOISE ON F MODEL MEDIUM DUTY TILT CAB MODELS WITH ISUZU 7.8L DIESEL ENGINE.
Read full bulletin
*TT
SOME CUSTOMERS AND DEALERS MAY COMMENT ON ACCELERATED UNEVEN BRAKE PAD WEAR ON SOME VEHICLE WITH FOUR-PISTON FIXED CALIPER REAR DISC BRAKES.
Read full bulletin
*TT
ON CERTAIN VEHICLES, SUCH AS THE CHEVROLET AND GMC WT 5500 MEDIUM DUTY TILT CAB MODELS, THE ENGINES MAY EXPERIENCE...
Read full bulletin
ROCKER ARM DAMAGE OR ROCKER BRIDGE DAMAGE FOLLOWING OVERHAUL OF THE CYLINDER HEAD IF THE VALVE BRIDGE STUD INSTALLED DEPTH IS INCORRECT. *TT
SUBJECT REGARDING RECALL 02006A REVISION - CLUTCH MASTER CYLINDER PUSHROD WEAROUT.
Read full bulletin
*TT
CUSTOMERS MAY COMPLAIN THAT THE ENGINE WILL NOT START.
Read full bulletin
*JG
CUSTOMERS MAY COMPLAIN THAT THE ENGINE WILL NOT START.
Read full bulletin
*SLC
SOME CUSTOMERS MAY COMMENT ON SERVICE ENGINE SOON LAMP ON, MALFUNCTION INDICATOR LAMP ILLUMINATIONS INTERMITTENTLY,...
Read full bulletin
DIAGNOSTIC TROUBLE CODE SET, BLOWN FUSES, AND ENGINE WILL NOT START. *TT
INFORMATION USED WHEN DIAGNOSING NOISE CONDITIONS SUCH AS ENGINE RATTLE NOISE, SPARK KNOCK AT 2000 - 2500 RPM RANGE,...
Read full bulletin
UNDER A MODERATE TO HEAVY LOAD WITH A WARMED UP ENGINE. *TT
SOME OWNERS MAY EXPERIENCE A SERVICE ENGINE SOON LIGHT, MISFIRE, ROUGH IDLE ORHARD START DUE TO A DEPOSIT BUILD-UP ON...
Read full bulletin
THE SEQUENTIAL CENTRAL PORT FUEL INUJECTOR (SCPI) POPPET VALVE(S). *TT
SOME CUSTOMERS MAY COMMENT ON ROUGH IDLE AFTER START UP, ESPECIALLY AFTER SETTING OVERNIGHT.
Read full bulletin
*TT
INFORMATION REGARDING CHEVROLET AND GMC 6-7F MEDIUM DUTY TILT CAB MODELS WITH ISUZU DIESEL ENGINE, ENGINE OVERHEATS,...
Read full bulletin
TEMPERATURE GAUGE READS HOT, AUDIBLE WARNING ALARM SOUNDS, AND CHECK GAUGE LAMP ON. *YH
SOME VEHICLES MAY EXHIBIT A SERVICE ENGINE SOON LAMP ON, MALFUNCTION INDICATOR LAMP ILLUMINATES INTERMITTENTLY,...
Read full bulletin
ANTI-LOCK BRAKE SYSTEM WARNING LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODES SET, AND / OR BLOWN FUSES. *TT
THIS MESSAGE CONCERNS CERTAIN 1997 THROUGH 2001 MEDIUM DUTY TRUCKS WITH SPICER SEVEN SPEED MANUAL TRANSMISSIONS...
Read full bulletin
EXHIBITING HEAVY VIBRATION THAT INCREASES WITH SPEED AND / OR AN OIL LEAK AND / OR A CRACKED ENGINE BLOCK. *TT
ON CERTAIN MODELS INCLUDING MY2000 - 2001 CHEVROLET AND GMC WT5500 SERIES, THE SERVICE ENGINE SOON (SES) INDICATOR IS...
Read full bulletin
ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE 0226 SET. *TT
CUSTOMERS OR DEALERS MAY COMPLAIN ABOUT POWER STEERING PUMP NOISE OR WHINE WHEN ENGINE IS COLD.
Read full bulletin
*TT
SOME VEHICLES MAY EXHIBIT HIGH OIL CONSUMPTION AND / OR POSSIBLE SMOKE FROM EXHAUST.
Read full bulletin
*TT
SOME CUSTOMERS MAY COMMENT ON ROUGH IDLE AFTER START UP, AND / OR A SERVICE ENGINE SOON (SES) LIGHT ILLUMINATED.
Read full bulletin
*TT
This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar...
Read full bulletin
system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Technical Assistance Center with the scan tool data from the OnStar system.
This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar...
Read full bulletin
system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Technical Assistance Center with the scan tool data from the OnStar system.
This Preliminary Information communication provides information to the technician about engine block of possible...
Read full bulletin
cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blow by. Technician will need to inspect the engine for Cylinder damage or scoring, An out of round cylinder bore, Dirt intrusion, and Catalytic Converter failure.
GENERAL MOTORS: INFORMATION PROVIDED BY BULLETIN FOR ALL 2012 AND PRIOR GENERAL MOTOR TRUCKS AND PASSENGER VEHICLES...
Read full bulletin
REGARDING THE ADJUSTABLE COMFORT AND CUSTOM UPHOLSTERY OF THE DRIVER AND THE PASSENGER HEAD RESTRAINT. *PE
OIL PRESENT AROUND TURBO AREA, OIL LEVEL LOW, OIL PRESSURE GAUGE MAY DROP.
Read full bulletin
*TT
AUTOMATIC ENGINE SHUTDOWN FEATURE.
Read full bulletin
*TT
Fuel System
5 bulletinsCUSTOMERS MAY COMMENT ON WHITE EXHAUST SMOKE DURING START-UP IN COLD AMBIENT TEMPERATURES.
Read full bulletin
*TT
DIAGNOSTIC HINTS / TROUBLESHOOTING GUIDE FOR DENSO COMMON RAIL FUEL SYSTEM FOR CERTAIN MEDIUM DUTY TILT CAB AND COMMERCIAL MODELS.
Read full bulletin
*TT
INFORMATION REGARDING FUEL TRANSFER PUMP INOPERATIVE.
Read full bulletin
*YH
SOME CUSTOMERS MAY COMMENT ON INOPERATIVE SECONDARY FUEL TANK TRANSFER PUMPS.
Read full bulletin
*TT
TECHNICAL SERVICE BULLETIN REGARDING FUEL TRANSFER PUMP INOPERATIVE.
Read full bulletin
*TT
Other
5 bulletinsSUBJECT REGARDING WHITE SMOKE DURING START UP,INCLUDES 1998-2002 CHEVROLET AND GMC WT 5500 SERIES MEDIUM DUTY TILT CAB MODELS.
Read full bulletin
*SLC
INFORMATION REGARDING CORRECT VEHICLE APPLICATION FOR EATON.
Read full bulletin
1990-2002 CHEVROLET AND GMC C-SERIES CONVENTIONAL AND T-SERIES TILT CAB MEDIUM DUTY MODELS. *YH
SOME CUSTOMERS MAY COMMENT ON HARD, NO, OR SLOW START, BACKFIRE OR KICKBACK DURING CRANK / START, GRINDING OR UNUSUAL...
Read full bulletin
NOISES DURING CRANK, DIAGNOSTIC TROUBLE CODE P0338. *TT
This Preliminary Information communication provides information to the technician about connectivity concerns when...
Read full bulletin
connecting an Apple device via USB cord. Technician should insure the customer is using an original equipment manufacturer Apple USB cable.
This Preliminary Information communication provides information to the technician that fluid contamination may be...
Read full bulletin
directed to one of the following testing centers according to the type of fluid needing testing. Dealer should send the correct fluid to the proper testing center.
Brakes
5 bulletinsSOME CUSTOMERS AND DEALERS MAY COMMENT ON ACCELERATED UNEVEN BRAKE PAD WEAR ON F6-7 MEDIUM DUTY TILT CAB MODELS AND H6-7...
Read full bulletin
CONVENTIONAL MEDIUM DUTY MODELS. *TT
SOME VEHICLES EQUIPPED WITH BENDIX ABS AIR BRAKES HAVE A CONDITION IN WHICH THE VEHICLE MAY HAVE UNWANTED TEMPORARY ABS ACTIVATION AT LOW SPEEDS.
Read full bulletin
*TT
This Preliminary Information communication provides information to the technician the steps needed to diagnose and...
Read full bulletin
repair the vehicles that may have unwanted or phantom phone calls. Technician will need to determine what type of call the customer is having that is unwanted. The vehicle may receive an incoming call just like any other phone. Typically the customer will hear the phone ringing in the vehicle. This scenario also includes incoming Bluetooth calls. One type of unwanted call can be made if the key pad is faulty the OnStar system will try to make a blue button call for shorted voltage in the circuits. The OnStar module could have an internal fault and produce a "Phone Unavailable" audio message also it may have a Diagnostic Trouble Code U1500 or B1000. Refer to diagnostics for the Diagnostic Trouble Code making sure to follow any applicable Bulletins or Preliminary Information sheets. A "Ready" or "OnStar ready" audio message heard while driving. In some cases it has been found that the customer is inadvertently pressing the ?push to talk? button on the steering wheel controls. On rare occasions, other issues in the steering column or Steering Wheel Control system may induce this concern.
INFORMATION ON AIR BRAKE PARK BRAKE CHAMBER VENT HOLES TO AVOID WATER INTRUSION.
Read full bulletin
*TT
RELEASE OF NEW PARK BRAKE CABLE ASSEMBLIES AND LUBRICATION MAINTENANCE INFORMATION FOR CERTAIN MEDIUM DUTY TILT CAB MODELS.
Read full bulletin
*TT
Transmission
3 bulletinsCONCERN WITH NO SHIFT, HARSH SHIFT, NO ENGAGEMENT, TRANSMISSION IN DEFAULT, CHECK TRANSMISSION WARNING INDICATOR...
Read full bulletin
ILLUMINATED, RANGE INHIBITED INDICATOR ILLUMINATED, TRANSMISSION DIAGNOSTIC TROUBLE CODES SET ON F-MODEL MEDIUM DUTY TILT CAB MODELS. *TT
SUBJECT REGARDING STEERING GEAR GREASE SEEPAGE FROM AROUND SECTOR (OUTPUT) SHAFT (INSTALL NEW SECTOR (OUTPUT) SHAFT...
Read full bulletin
SEALS).*JG
CONCERNS ABOUT A SLIPPING CLUTCH OR EARLY CLUTCH FAILURE.
Read full bulletin
*TT
Body & Paint
3 bulletinsSUBJECT ON HOOD HINGE RATTLE COMING FROM EITHER OR BOTH FRONT CORNERS OF THE INSTRUMENT PANEL NEAR THE HOOD HINGE AREAS...
Read full bulletin
FOR 1995 - 2002 PICKUP AND UTILITY MODELS. *ET
INFORMATION REGARDING BODY SIDE MOLDING OMITTED.
Read full bulletin
**MR
PASSENGER DOOR OUTSIDE REARVIEW MIRROR VIBRATION ON CERTAIN VEHICLES INCLUDING THE 2000 - 2001 WT500 SERIES MEDIUM DUTY TILT CAB MODELS.
Read full bulletin
*TT
Infotainment
3 bulletinsThis Preliminary Information communication provides information to the technician about vehicles that may have an issue...
Read full bulletin
when using Bluetooth voice recognition with an iPhone. Technician should work with the customer to insure the phone contacts to not have any Emojis loaded to any contact.
This Preliminary Information communication provides information to the technician about vehicles that are travelling from Canada to the United States.
Read full bulletin
While in the United States they are unable to receive Turn-by-Turn directions. Due to the existing cellular provider not having roaming agreements in areas outside of Canada to support transmitting of the packet data required for Turn-By-Turn feature to operate. The customer has 3 options while traveling through the United Sates. First if the vehicle is equipped with a navigation radio they can request a "Destination Download" to the vehicle. Second if the customer uses the OnStar RemoteLink app they can send the directions to the vehicle. The third option would be to have the vehicle loaded with a "500 phone number" The customer will no longer be able to use their Hands Free Calling minutes when the new 500 phone number is loaded. If a customer chooses to restore Hands Free Calling in the future a new phone number will be assigned to the vehicle; previous phone numbers are not available.
This Preliminary Information communication provides information to the technician about vehicles that may have an issue...
Read full bulletin
when using Bluetooth voice recognition with an iPhone. Technician should work with the customer to insure the phone contacts to not have any Emojis loaded to any contact.
HVAC & Climate
2 bulletinsSOME CUSTOMERS MAY COMMENT ABOUT INSTABILITY OF THE A/C CONDENSER OR THAT THE A/C SYSTEM IS INOPERATIVE.
Read full bulletin
*TT
SUBJECT REGARDING SERVICE DIAGNOSIS/RECOMMENDATIONS FOR INOPERATIVE AIR CONDITIONING SYSTEMS.
Read full bulletin
*TT
Tires & Wheels
1 bulletinSUBJECT REGARDING MISALIGNMENT OF AIR INTAKE DUCT WHEN CLOSING CAB.
Read full bulletin
*TT
Electrical
1 bulletinThis Preliminary Information communication provides information to the technician about vehicles may have a no power or no connect concern.
Read full bulletin
Technician will find that the OnStar led is red and Diagnostic Trouble Code U1500 is set. Technician will need to replace the Vehicle Communication Interface Module if the Station Identification number falls in the ranges 14,000,000 - 16,000,000 or 22,000,000 - 23,200,000.
Lighting
1 bulletinIPC, INTERIOR LIGHTS AND/OR HEADLAMPS FLICKER.
Read full bulletin
*AK FB2
Steering
1 bulletinEFFECT OF STEERING BOX LIMITER ADJUSTMENT ON TURNING RADIUS AND POSSIBILITY OF POWER STEERING SYSTEM DAMAGE DUE TO IMPROPER ADJUSTMENT.
Read full bulletin
VARIOUS 1990-2004 MODELS. *TT