1998 Chevrolet S10 TSBs
91 Technical Service Bulletins across 13 categories
Categories
Engine
23 bulletinsSUBJECT REGARDING RUST IN COOLING SYSTEM, HEATER INOPERATIVE, BLOWS COLD AIR, ENGINE OVERHEATS (FLUSH COOLING SYSTEM).
Read full bulletin
NLM
CUSTOMERS MAY COMPLAIN OF EXCESSIVE OIL CONSUMPTION AND HAVING TO ADD OIL BETWEEN CHANGES.
Read full bulletin
*JG
SOME CUSTOMERS MAY COMMENT THAT THE HEATER IS INOPERATIVE, BLOWS COLD AIR, ENGINE MAY EXHIBIT AN OVERHEAT CONDITION OR...
Read full bulletin
THE COOLANT RESERVOIR HAS RUST IN IT. *TT
SOME CUSTOMERS MAY COMMENT THAT THE SECURITY LAMP ILLUMINATES WHILE DRIVING; ENGINE CRANKS BUT WILL NOT START; AND / OR...
Read full bulletin
THE ENGINE STARTS THEN STALLS AND THE SECURITY LAMP IS FLASHING. *TT
SOME CUSTOMERS MAY COMMENT THAT THE SECURITY LAMP ILLUMINATES WHILE DRIVING; THE SECURITY LAMP MAY BE ON OR OFF; THE...
Read full bulletin
SECURITY LAMP IS ILLUMINATED; THE ENGINE CRANKS BUT WILL NOT START AND THE SECURITY LAMP IS FLASHING; AND / OR THE ENGINE STARTS THEN STALLS AND THE SECURITY LAMP IS FLASHING. *TT
CUSTOMER SATISFACTION CAMPAIGN INVOLVING VEHICLES EXHIBITING INCREASED OIL CONSUMPTION.
Read full bulletin
*TT
SOME CUSTOMERS MAY EXPERIENCE ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT AND CODE P0300 (GENERAL MISFIRE), WITH...
Read full bulletin
DRIVEABILITY COMPLAINTS OF ENGINE MISFIRE, ROUGH IDLE AND HESITATION. **MR
SOME CUSTOMERS MAY COMMENT THAT THE HEATER IS INOPERATIVE, BLOWS COLD AIR, ENGINE MAY EXHIBIT AN OVERHEAT CONDITION OR...
Read full bulletin
THE COOLANT RESERVOIR HAS RUST IN IT. *TT
SOME CUSTOMERS MAY COMMENT THAT THE HEATER IS INOPERATIVE, BLOWS COLD AIR, ENGINE MAY EXHIBIT AN OVERHEAT CONDITION OR...
Read full bulletin
THE COOLANT RESERVOIR HAS RUST IN IT. *TT
VALVE ROCKER ARM COVER FAILED, CAUSING OIL CNSUMPTION TO INCREASE.
Read full bulletin
YD
EXHIBITING INCREASED OIL CONSUMPTION.
Read full bulletin
*YC
CONDITION WITH COOLANT LEAKING ONTO GROUND.
Read full bulletin
*YC
This preliminary informational bulletin provides information on High Oil Pressure on Startup After Engine Replacement...
Read full bulletin
Concern.
This Preliminary Information communication provides information to the technician about vehicle that after a...
Read full bulletin
transmission or torque converter replacement the vehicle may have a harsh 1-2 upshift and the Check Engine Light or Service Engine Soon indicator is illuminated. If you have duplicated the customer?s concern and found Diagnostic Trouble Code P0894 or P1870 set in the Transmission Control Module please contact General Motors Technical Assistance Center.
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLE THAT AFTER A...
Read full bulletin
TRANSMISSION OR TORQUE CONVERTER REPLACEMENT THE VEHICLE MAY HAVE A HARSH 1-2 UPSHIFT AND THE CHECK ENGINE LIGHT OR SERVICE ENGINE SOON INDICATOR IS ILLUMINATED. IF YOU HAVE DUPLICATED THE CUSTOMERS CONCERN AND FOUND DIAGNOSTIC TROUBLE CODE P0894 OR P1870 SET IN THE TRANSMISSION CONTROL MODULE PLEASE CONTACT GENERAL MOTORS TECHNICAL ASSISTANCE CENTER.
SERVICE ENGINE SOON (SES) LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODE P0420 SET.
Read full bulletin
*TT
SERVICE ENGINE SOON LIGHT AND P0300 WHEN TOWING, CRUISING UPHILL OR ON HARD ACCELERATION.
Read full bulletin
*TT
ENGINE COOLANT LEAK AT INTAKE GASKET.
Read full bulletin
* MJ
4.3 L35 LU3 RATTLE OR BUZZ NOISE FROM ENGINE.
Read full bulletin
SIT BULLETIN 1457619. *TT
MALFUNCTION INDICATOR LAMP ON WITH A P0300 SET AND A MISFIRE.
Read full bulletin
VARIOUS MODELS INCLUDING 1996 - 1999 P32 MODELS. SIT BULLETIN 1416475. *TT
RATTLE NOISE IN ENGINE.
Read full bulletin
*TT
RATTLE NOISE IN ENGINE.
Read full bulletin
*TT
MALFUNCTION INDICATOR LAMP ON WITH A P0300 SET AND A MISFIRE.
Read full bulletin
VARIOUS MODELS INCLUDING THE 1996-1999 P32 AND THE 1996-2002 GMC C/K TRUCK. *TT
Body & Paint
14 bulletinsSOME CUSTOMERS MAY COMMENT THAT THE THIRD DOOR IS HARD TO OPEN AND/OR THE DOOR HANDLE MAY BE BROKEN FOR 1996-2002...
Read full bulletin
CHEVROLET AND GMC S/T EXTENDED CAB PICKUP MODELS.. *SLC
CONCERNS WITH EXCESSIVE EFFORT OR BREAKING OF THE THIRD DOOR HANDLE ON EXTENDED CAB PICK UPS.
Read full bulletin
*TT
This Preliminary Information communication provides information to the technician about vehicles that may have slack in one of the tailgate cables.
Read full bulletin
Technician should not replace any parts for this concern. Please communicate to the customer this condition is a normal operating characteristic of their vehicle.
This Preliminary Information communication provides information to the technician about vehicles that may have slack in one of the tailgate cables.
Read full bulletin
Technician should not replace any parts for this concern. Please communicate to the customer this condition is a normal operating characteristic of their vehicle.
This Preliminary Information communication provides information to the technician about vehicles that may have slack in one of the tailgate cables.
Read full bulletin
Technician should not replace any parts for this concern. Please communicate to the customer this condition is a normal operating characteristic of their vehicle.
This Preliminary Information communication provides information to the technician about vehicles that may have slack in one of the tailgate cables.
Read full bulletin
Technician should not replace any parts for this concern. Please communicate to the customer this condition is a normal operating characteristic of their vehicle.
This Preliminary Information communication provides information to the technician about vehicles that may have slack in one of the tailgate cables.
Read full bulletin
Technician should not replace any parts for this concern. Please communicate to the customer this condition is a normal operating characteristic of their vehicle.
This Preliminary Information communication provides information to the technician about vehicles that may have slack in one of the tailgate cables.
Read full bulletin
Technician should not replace any parts for this concern. Please communicate to the customer this condition is a normal operating characteristic of their vehicle.
This Preliminary Information communication provides information to the technician about vehicles that may have slack in one of the tailgate cables.
Read full bulletin
Technician should not replace any parts for this concern. Please communicate to the customer this condition is a normal operating characteristic of their vehicle.
This Preliminary Information communication provides information to the technician about vehicles that may have slack in one of the tailgate cables.
Read full bulletin
Technician should not replace any parts for this concern. Please communicate to the customer this condition is a normal operating characteristic of their vehicle.
This Preliminary Information communication provides information to the technician about vehicles that may have slack in one of the tailgate cables.
Read full bulletin
Technician should not replace any parts for this concern. Please communicate to the customer this condition is a normal operating characteristic of their vehicle.
WATER LEAK IN FRONT FLOOR CARPET AREA.
Read full bulletin
GM TECH LINK. *TT
TAILGATE CABLE SLACK.
Read full bulletin
THIS INCLUDES 1998-2006 CHEVROLET AND GMC FULL AND MID SIZE TRUCKS. *EH UPDATED. *KB
PAINT CODE UNKNOWN FOR FRONT BUMPER AND WHEEL FLARE.
Read full bulletin
*EH
Other
10 bulletinsINFORMATION ON OVER TORQUING OR A REVERSE BEDRAIL INSTALLATION.
Read full bulletin
*TT
SUBJECT REGARDING GENERAL WATERLEAK GUIDE.
Read full bulletin
*TT
CUSTOMERS MAY COMMENT THAT THE SEAT RECLINER HANDLE IS STRIPPED.
Read full bulletin
*JG
INFORMATION REGARDING IMPROVED BUS SEAT DECLINER ASSEMBLIES, THE HANDLE ON THE RECLINER ASSEMBLY IS ATTACHED WITH A...
Read full bulletin
NUMBER 20 TORQUE WITH A SHANK LENGTH OF 20 MILLIMETERS. *SLC
SUBJECT REGARDING THE NEW RECLINCER ASSEMBLY.
Read full bulletin
*TT
SOME VEHICLES MAY EXHIBIT REDUCED VEHICLE RANGE WITH NO CHANGE IN DRIVING HABITS OR THE STATE OF CHARGE (SOC) GAUGE SWEEPS / SWINGS.
Read full bulletin
*TT
CLUNK NOISE FELT THROUGH THE FLOOR PAN.
Read full bulletin
*KB
4WD MODELS WITH NOISE, VIBRATION ON DRY PAVEMENT.
Read full bulletin
*EH
FRONT AXLE GRIND WHINE NOISE IN 2WD GONE IN 4WD.
Read full bulletin
*EH
CLUNK NOISE FELT THROUGH FLOOR PAN.
Read full bulletin
*TT
Electrical
9 bulletinsCERTAIN ELECTRIC TRUCKS WITH PANASONIC (TP-6) LEAD ACID BATTERY PACKS MAY HAVE A REDUCTION IN DRIVE RANGE, PARTICULARLY...
Read full bulletin
AFTER THE VEHICLE HAS BEEN CHARGING FOR EXTENDED PERIODS WITHOUT DRIVING. *TT
INFORMATION ON REPLACING CORRODED TRAILER PRE-WIRE HARNESS AT THE REAR BUMPER.
Read full bulletin
*TT
INFORMATION ON SPECIAL POLICY - PRODUCT ENHANCEMENT BATTERY PACK CONVERSION.
Read full bulletin
*TT
VEHICLE CHARGES WITH IGNITION KEY "ON" BUT NOT "OFF".
Read full bulletin
*YC
Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules
This Preliminary Information communication provides information to the technician about vehicles that have a...
Read full bulletin
Supplemental Inflatable Restraint lamp, Service Vehicle Soon lamp on and/or radio locked, possibly after module replacement. Technician will need to check for an incorrect or non-existent VIN number in modules that require them. Technician should ensure that all modules that are replaced are programmed per currently published Service Information. Technician should also check the Sensing and Diagnostic Module part number if it was replaced.
FUEL AND TEMPERATURE GAUGE INOPERATIVE, LOW FUEL AND BATTERY LIGHT ON, PRNDL INOPERATIVE.
Read full bulletin
*TT
INSTRUMENT CLUSTER PRNDL INOPERATIVE AND OR BATTERY LIGHT ON.
Read full bulletin
*SC
REVISED HEATER / VENT MODULE REPLACEMENT.
Read full bulletin
*TT
Transmission
7 bulletinsDIAGNOSIS OF CRACKED OR BROKEN TRANSMISSION CASE.
Read full bulletin
*TT 2006 AND PRIOR CARS AND LIGHT DUTY TRUCKS. *TT
SOME VEHICLES WILL NOT MOVE WHEN 4-WHEEL DRIVE IS REQUESTED, NOISE, SHUDDER, POOR PERFORMANCE, TRANSMISSION / TRANSFER...
Read full bulletin
CASE SLIPS, TRANSMISSION WILL NOT UPSHIFT, SLIPS IN 4-WHEEL DRIVE. *TT
THIS TECHNICAL SERVICE BULLETIN STATES THAT TECHNICIANS MAY EXPERIENCE DIFFICULTY IN REMOVING THE CONNECTORS FROM THE...
Read full bulletin
PARK / NEUTRAL POSITION SWITCH, USUALLY WHEN TRYING TO REMOVE THE SWITCH DURING TRANSMISSION SERVICE. *TT
MALFUNCTION INDICATOR LAMP (MIL) IS ON; THE TRANSMISSION IS STUCK IN THIRD GEAR; AND / OR THE INSTRUMENT CLUSTER IS INOPERATIVE.
Read full bulletin
*TT
DIAGNOSTIC INFORMATION FOR INTERMITTENT TRANSMISSION DOWNSHIFT, SLIP, BUSY/CYCLING TCC OR NOISY COOLING FAN.
Read full bulletin
*TT
4L60E, 4L65E FORWARD AND LOW REVERSE WAVED STEEL CLUTCH PLATE APPEARANCE CHANGE.
Read full bulletin
*TT
4L60-E AUTOMATIC TRANSMISSION OIL PUMP FIRST AND SECOND DESIGN IDENTIFICATION.
Read full bulletin
*TT
Fuel System
7 bulletinsSOME CUSTOMERS MAY COMMENT ON AN EXHAUST BOOM / GROAN NOISE IN THE PASSENGER COMPARTMENT.
Read full bulletin
*TT
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for...
Read full bulletin
the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for...
Read full bulletin
the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for...
Read full bulletin
the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.
This informational bulletin provides the technician with information on what E85 fuel may due to a non E85 vehicle.
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for...
Read full bulletin
the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.
FUEL GAUGE FLUCTUATION IN PARK OR NEUTRAL.
Read full bulletin
*TT
Infotainment
7 bulletinsCUSTOMERS MAY COMPLAIN THAT BATTERIES ARE NOT CHARGING AND A CHECK VEHICLE MESSAGE IS DISPLAYED ON THE CHARGER.
Read full bulletin
*NLM
SOME OWNERS MAY REPORT THAT THE VEHICLE WILL NOT CHARGE, AND CHECK VEHICLE DISPLAYED ON CHARGER ON VEHICLES BUILT PRIOR...
Read full bulletin
TO AND INCLUDING VIN BREAKPOINT W8138319. *TT
This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock.
Read full bulletin
Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code. The PI update to version D is to advise the unlock procedure is temporarily unavailable. E version update is to add administrative details.
This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock.
Read full bulletin
Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code. The PI update to version D is to advise the unlock procedure is temporarily unavailable.
This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock.
Read full bulletin
Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.
This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock.
Read full bulletin
Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.
This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock.
Read full bulletin
Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.
Pre-Delivery & Maintenance
5 bulletinsVehicle Recalls
This warranty administration bulletin provides information regarding the field action courtesy transportation policy.
This warranty administration bulletin provides information regarding the field action courtesy transportation policy.
This warranty administration bulletin provides information regarding the field action courtesy transportation policy.
This warranty administration bulletin provides policy information with the field action courtesy transportation policy.
Brakes
3 bulletinsSUBJECT REGARDING NECESSARY RESURFACING OF THE PARK BRAKE DRUM.
Read full bulletin
*JG
ANTILOCK BRAKE (ABS) ACTIVATION AT LOW SPEEDS ON VARIOUS MODELS INCLUDING THE 1995 AND 1996 ENVOY.
Read full bulletin
*TT
ANTILOCK BRAKE (ABS) ACTIVATION AT LOW SPEEDS.
Read full bulletin
*TT
HVAC & Climate
2 bulletinsSUBJECT REGARDING HEATER COOLANT RESERVOIR LEAKING.
Read full bulletin
*TT
HEAT COMING FROM VENTS WITH HVAC OFF.
Read full bulletin
*TT
Lighting
2 bulletinsSUBJECT ON REDUCED RANGE OR DISABLED CHARGING.
Read full bulletin
*YC
DRIVER INFORMATION CENTER (DIC) STAYS IN BULB CHECK.
Read full bulletin
*TT
Software & Calibration
1 bulletinTHIS TECHNICAL BULLETIN PROVIDES A PROCEDURE TO REPROGRAM THE MEDIA DISC PLAYER WITH THE LATEST CALIBRATIONS TO CORRECT...
Read full bulletin
A CONDITION OF THE REAR ENTERTAINMENT SYSTEM NOT OPERATING AS INTENDED IN COLDER AMBIENT TEMPERATURE AREAS DUE TO CALIBRATION CONCERNS.
Tires & Wheels
1 bulletinSLIPS IN 4-WHEEL DRIVE, NOISE, VIBRATION, LEAKS, HOT ODOR.
Read full bulletin
*TT