1999 Chevrolet Malibu TSBs

SOME CUSTOMERS MAY COMMENT THAT THE SERVICE ENGINE SOON LIGHT IS ON.

SUBJECT REGARDING REVISED LOWER INTAKE MANIFOLD INSTALLATION.

SUBJECT REGARDING REVISED IGNITION LOCK CYLINDER OR IGNITION SWITCH ASSEMBLY REPLACEMENT.

SOME CUSTOMERS MAY COMMENT ABOUT AN INTERMITTENT SERVICE VEHICLE SOON LIGHT AND/OR AN ELECTRONIC TRACTION CONTROL LIGHT...

INFORMATION ON INSTRUMENT PANEL COMPARTMENT LOCK CYLINDER REPLACEMENT PROCEDURE *JG

SERVICE MANUAL REVISION ON COOLING FAN MOTOR CIRCUIT.*JB

THIS BULLETIN IS BEING ISSUED TO REVISE THE FUEL GAUGE INACCURATE OR INOPERATIVE DIAGNOSTIC PROCEDURE IN THE ENGINE...

SUBJECT REGARDING POLYMER SERVICE PISTONS.

SOME OWNERS MAY COMMENT ON DRIVEABILITY SYMPTONS OF LONG OR HARD STARTS, CHUGGLE, ROUGH IDLE AND LIGHT OR INTERMITTENT...

EXPERIENCING A NO CRANK NO START, CRANK NO START, NO START OR A START DOESN'T RUN THAT MAY BE ACCOMPANIED BY A THEFT...

SOME CUSTOMES MAY COMMENT ON A ROUGH ENGINE IDLE AND / OR MISFIRE.

SUBJECT REGARDING ENGINEERING REQUEST FOR VEHICLES WITH 4T40E AND 4T45E TRANSAXLES WITH A CONDITION OF NO THIRD OR NO FOURTH GEAR.

SOME OWNERS MAY EXPERIENCE A DRIVEABILITY SYMPTOM OF LONG OR HARD STARTS, CHUGGLE, ROUGH IDLE AND LIGHT OR INTERMITTENT MISFIRE.

CUSTOMERS MAY COMPLAIN OF COOLANT LEAKS, LOW COOLANT LIGHT 'ON', OVERHEATING, NO HEAT, NO START, OR ODORS EMITTED FROM THE AIR CONDITIONING SYSTEM.

SUBJECT ON ENGINE MISFIRE - INSPECT/ REPLACE IGNITION CONTROL MODULE.

Refinishing Aluminum Wheels This bulletin updates General Motor's position on refinishing aluminum wheels.

Refinishing Aluminum Wheels This bulletin updates General Motor's position on refinishing aluminum wheels.

This Preliminary Information communication provides information to the technician about cooler line fittings that come...

INFORMATION ON 4T40-E (MN4) AND 4T45-E (MN5) FRONT WHEEL DRIVE AUTOMATIC TRANSMISSION VALVE BODY RECONDITIONING, DTC...

ENGINE STARTS AND IMMEDIATELY STALLS AND THEN CAN BE RESTARTED AND WILL RUN NORMALLY.

NEUTRAL FLARE AND/OR RPM FLARE WHILE IN DRIVE, NO 1-2 UPSHIFT, SERVICE ENGINE SOON (SES) LIGHT ILLUMINATED, DIAGNOSTIC...

ENGINE START AND STALL AFTER FUELING WITH NO DIAGNOSTIC TROUBLE CODES (DTCS).

ENGINE OIL OR COOLANT LEAK.

4T40E, 4T45E, 4T65E SURGE SLIP CONDITION UNDER LOAD IN 2ND, 3RD AND/OR 4TH.

COMPLAINTS OF INTERMITTENT VEHICLE SHUTTING OFF WHILE DRIVING WITH NO MULTIPLE CODES SET.

NEUTRAL FLARE AND/OR RPM FLARE WHILE IN DRIVE, NO 1-2 UPSHIFT, SERVICE ENGINE SOON (SES) LIGHT ILLUMINATED, DIAGNOSTIC...

ENGINE OIL OR COOLANT LEAK.

REVISED PISTON PIN REMOVAL / INSTALLATION PROCEDURE.

ENGINEERING CHANGES TO THE VALVE BODY, PRESSURE REGULATOR VALVE, 2-3 ACCUMULATOR VALVE AND BORE FOR 2002-2003 MODEL YEAR...

INFORMATION REGARDING THE BRAKE ALIGN KIT.

ADDITIONAL INFORMATION ON REPEAT BRAKE PULSATION AFTER AN INITIAL BRAKE REPAIR.

SERVICE MANUAL UPDATE REGARDING REVISED BRAKE SPECIFICATIONS.

CUSTOMERS MAY COMMENT THAT THE ANTI-LOCK BRAKE SYSTEM INDICATOR IS ILLUMINATED AND DIAGNOSTIC TROUBLE CODE 1236 STORED.

INFORMATION PERTAINING TO PROPER INSTALLATION OF FRONT BRAKE PADS WITH WEAR INDICATOR.

SOME CUSTOMERS MAY COMMENT ON A BRAKE PEDAL RATTLE OR CLUNK.

SOME OWNERS MAY COMMENT ABOUT A SQUEALING TYPE NOISE COMING FROM THE FRONT BRAKES DURING A BRAKE APPLICATION.

CUSTOMERS MAY COMPLAIN A SQUEALING NOISE COMING FROM THE FRONT BRAKES.

ABS PUMP RUNNING WHEN NOT NEEDED.

REVISED BRAKE SYSTEM SPECIFICATIONS.

BRAKE NOISE/CREAK DURING SLOW SPEED BRAKING.

THE ANTI-LOCK BRAKE SYSTEM INDICATOR IS ILLUMINATED AND DIAGNOSTIC TROUBLE CODE C1236 IS STORED.

BRAKES CALIPER NOISE ON APPLY.

VEHICLES MAY SET ANYONE OR A COMBINATION OF FRONT-WHEEL SPEED SENSOR ANTI-LOCK BRAKE SYSTEM CODES AS INTERMITTENT OR HARD FAILURES.

ANTI-LOCK BRAKING SYSTEM (ABS) FRONT WHEEL SPEED CODES - JUMPER HARNESS.

ABS FRONT WHEEL SPEED CODES - JUMPER HARNESS.

BRAKE PAD REPLACEMENT.

FRONT DISC BRAKE PULSATION.

SOME OWNERS MAY COMMENT THAT THE MOLDING ALONG THE REAR (TRUNK) COMPARTMENT OPENING AT THE STRIKER IS LOOSE OR BROKEN.

SOME ONWERS MAY COMMENT THAT THE MOLDING ALONG THE REAR (TRUNK) COMPARTMENT OPENING AT THE STRIKER IS LOOSE OR BROKEN.

WATER LEAK ISSUES. *TT

THIS BULLETIN CONTAINS INFORMATION ON VARIOUS WATER LEAK CONDITIONS.

SOME CUSTOMERS MAY COMMENT OF WATER LEAKING INTO THE CAR ON THE FRONT FLOOR.

INFORMATION ON WATER LEAK ISSUES AND HOW TO DIAGNOSE AND PROPERLY CORRECT THEM.

SOME CUSTOMERS MAY COMMENT THAT WHEN THEY CLOSE THE HOOD, THE PRIMARY LATCH DOES NOT ENGAGE.

THIS MESSAGE CONCERNS HOOD CABLE FREEZING.

INFORMATION ON REPLACING SUNROOF SUNSHADE STOPS.

SOME CUSTOMER MAY COMMENT THAT THE REAR DOORS HAVE HIGH SWING EFFORT WHEN OPENING OR CLOSING.

SOME CUSTOMERS MAY COMMENT THAT THE BLACK PLASTIC HOUSING AROUND THE OUTSIDE REAR VIEW MIRROR TURNS CHALKY OR IS DULL IN COLOR.

ADDRESSING CONCERNS OF COLD AIR ENTERING VEHICLE AROUND DOOR HANDLES.

COMMENTS THAT THE FRONT AND / OR REAR DOORS REQUIRE CONSIDERABLE EFFORT TO OPEN OR CLOSE ON VEHICLES.

CONCERNS OF DOOR HANDLES ON WHITE PAINTED VEHICLES TRUNING YELLOW.

Underbody Component Corrosion The following information may be helpful when addressing underbody component corrosion with customers.

Underbody Component Corrosion The following information may be helpful when addressing underbody component corrosion with customers.

PARTS AVAILABILITY FOR SUNROOF REPAIRS.

THIS BULLETIN CONTAINS INFORMATION ON VARIOUS WATERLEAK CONDITIONS.

SUBJECT REGARDING REVISED DIAGNOSTIC TROUBLE CODE P0140.

SUBJECT REGARDING INTERMITTENT COMMUNICATION OR SERIAL DATA DIAGNOSTIC TROUBLE CODES STORED IN HISTORY.

SOME OWNERS MAY COMMENT ON LEAKAGE OF A FEW DROPS OF COOLANT AFTER PARKING THEIR VEHICLE.

SOME OWNERS MAY COMMENT THAT THE PASSENGER RIGHT FRONT SEAT RATTLES WHEN UNOCCUPIED.

SOME VEHICLES BUILT PRIOR TO VIN BREAKPOINT 1M531582 OR 16145701 MAY EXHIBIT A CREAK / POP NOISE COMING FROM THE REAR OF THE VEHICLE.

A CONDITION MAY EXIST WHERE THE FRONT SEAT SHOULDER BELT IS SLOW TO RETRACT WHEN NOT IN USE, OR NOT LONG ENOUGH.

SOME CUSTOMERS MAY COMMENT ON UNDESIRABLE ROAD NOISE OR WATER NOISE FROM THE REAR SEAT AREA.

CUSTOMERS MAY COMMENT THAT THERE APPEARS TO BE PREMATURE WEAR OF THE LEATHER MATERIAL ON FRONT AND REAR SEATS.*TT

SUBJECT REGARDING RESCISSION OF STOP SALE OF REAR COMPARTMENT LID INTERNAL RELEASE.

SUBJECT REGARDING A STOP SALE OF REAR COMPARTMENT LID INTERNAL RELEASE.

SUBJECT REGARDING PREMATURE WEAR OF LEATHER MATERIAL ON BUCKET SEATBACK BOLSTER.

INCORRECT OUTER BACKING PLATE.

INFORMATION USED WHEN SERVICING THE DRIVE AXLE NUT.

SOME CUSTOMERS MAY COMMENT ON A SQUAWK NOISE FROM THE FRONT AND/OR REAR SUSPENSION WHILE DRIVING.

INFORMATION REGARDING SQUAWK NOISE FROM FRONT AND/OR REAR SUSPENSION.

SOME CUSTOMERS MAY COMMENT OF A SQUAWK NOISE FROM THE FRONT OR REAR SUSPENSION AREA.

INFORMATION REGARDING FRONT SUSPENSION CLUNK / RATTLE NOISE DIAGNOSIS.

SUBJECT REGARDING FRONT SUSPENSION CLUNK / RATTLE NOISE DIAGNOSIS.

CONCERNS WITH SUSPENSION NOISE.*JB

CUSTOMERS MAY COMPLAIN OF A CREAK OR POP NOISE FROM THE REAR OF THE VEHICLE, THIS MAY OCCUR ON TURNS, ON ACCELERATION OR...

VEHICLES MAY EXPERIENCE CLUNK, RATTLE NOISE FROM THE UNDERBODY OR FRONT SUSPENSION.

SUBJECT REGARDING FRONT CONTROL ARM REPLACEMENT.

SUBJECT PERTAINING TO FRONT AND / OR REAR STABILIZER SHAFT SQUAWK / SQUEAK NOISE.

SOME CUSTOMERS MAY COMMENT THAT A STOP AND / OR TAIL LAMP MAY NOT WORK CORRECTLY OR THAT THE LAMP ASSEMBLY HAS WATER IN IT.

SOME CUSTOMERS MAY COMMENT THAT A STOP AND / OR TAIL LAMP MAY NOT WORK CORRECTLY, OR THAT THE TAIL LAMP HAS WATER IN IT.

SOME CUSTOMERS MAY COMMENT OF A MALFUNCTION INDICATOR LIGHT ILLUMINATED WITH STORED DIAGNOSTIC TROUBLE CODES P0112, P0113, P1111 OR P1112.

STOP AND / OR TAIL LAMP MAY NOT WORK CORRECTLY, OR THAT THE TAIL LAMP HAS WATER IN IT.

IPC, INTERIOR LIGHTS AND/OR HEADLAMPS FLICKER.

STOP TAIL LAMP INOPERATIVE OR INTERMITTENT AND OR WATER IN LAMP.

UPCOMING SPECIAL POLICY ADJUSTMENT PROGRAM 04098.

SOME CUSTOMERS MAY WANT TO TOW THEIR VEHICLE BEHIND ANOTHER VEHICLE WITH ALL FOUR TIRES ONT HE GROUND.

SOME CUSTOMERS MAY WANT TO TOW THEIR VEHICLE BEHIND ANOTHER VEHICLE WITH ALL FOUR TIRES ONT HE GROUND.

SUBJECT REGARDING HESITATION OR STUMBLE ON THROTTLE APPLICATION AFTER COLD START (REPROGRAM PCM).

CUSTOMER MAY COMPLAIN THAT THE CHIME SOUNDS WHEN KEY IS REMOVED FROM IGNITION, INTERMITTENT OPERATION OF POWER DOOR...

Unintended Ignition Key Rotation

Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules

Unintended Ignition Key Rotation

Unintended Ignition Key Rotation

This Preliminary Information communication provides information to the technician about vehicles that have a...

FUEL GAUGE NEEDLE RESET PROCEDURE AFTER BATTERY DISCONNECT/REPLACEMENT WITH KEY IN ON POSITION.

ONWERS MAY COMMENT ON A LIGHT HESITATION OR STUMBLE AFTER A COLD START AT TEMPERATURES BELOW APPROXIMATELY 50 DEGREEES FAHRENHEIT OR TEN DEGREES C.

THIS BULLETIN IS BEING ISSUED TO REVISE THE FUEL GAUGE INACCURATE OR INOPERATIVE

SUBJECT REGARDING REVISED FUEL GAGE INACCURATE OR INOPERATIVE DIAGNOSTIC PROCEDURE.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for...

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for...

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for...

This informational bulletin provides the technician with information on what E85 fuel may due to a non E85 vehicle.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for...

SOME CUSTOMERS MAY COMPLAIN ABOUT WEAK FM RADIO RECEPTION AND / OR NO AM RADIO RECEPTION.

This informational bulletin provides information for dealers/technicians on Procedures to Unlock Delco Radio with...

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock.

Vehicle Recalls

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

This warranty administration bulletin provides policy information with the field action courtesy transportation policy.

THIS TECHNICAL BULLETIN PROVIDES A PROCEDURE TO REPROGRAM THE MEDIA DISC PLAYER WITH THE LATEST CALIBRATIONS TO CORRECT...

SDM REPROGRAM - CLASS ACTION SETTLEMENT (U.S.

REVISED TILT STEERING WHEEL AND COLUMN FASTENER TIGHTENING SPECIFICATIONS.

RELEASE OF NEW OUTER TIE ROD ENDS FOR SERVICE.

SOME CUSTOMERS MAY WANT TO TOW THEIR VEHICLE BEHIND ANOTHER VEHICLE WITH ALL FOUR TIRES ONT HE GROUND.

SOME OWNERS OF CERTAIN VEHICLES BUILT PRIOR TO NOVEMBER 1, 1999 MAY COMMENT ON A NO THIRD AND FOURTH GEAR CONDITION.

HVAC WILL CHANGE FROM RECIRC MODE TO FRESH AIR MODE WHEN DRIVING.