1996 Chevrolet Astro TSBs
51 Technical Service Bulletins across 11 categories
Categories
Engine
14 bulletinsSUBJECT REGARDING REVISED DTC P0340 CAMSHAFT POSITION (CMP) SENSOR CIRCUIT DIAGNOSITC.
Read full bulletin
NLM
THIS BULLETIN STATES THAT GENERAL MOTORS HAS DECIDED THAT CERTAIN VEHICLES FAIL TO CONFIRM TO FEDERAL/CANADA MOTOR...
Read full bulletin
VEHICLE SAFETY STANDARD 208, OCCUPANT CRASH PROTECTION, 208, OCCUPANT RESTRAIN SYSTEM IN FRONTAL IMPACT, AND ARTICLE 22-3, TRIAS 49, SEAT BELT WARNING DEVICE, SOMETIMES ON CERTAIN VEHICLES THE SEAT BELT AUDIBLE SIGNAL MAY NOT COME ON OR MAY TERMINATE IN LESS THAN FOUR SECONDS. *SLC
ENGINE NOISE (INSTALL VALVE STEM OIL SEAL).
Read full bulletin
*TW
ENGINE HARD TO START (REPLACE FUEL PUMP PULSATOR).
Read full bulletin
*TW
This preliminary informational bulletin provides information on High Oil Pressure on Startup After Engine Replacement...
Read full bulletin
Concern.
GENERAL MOTORS: ON ALL 1988-2009 FULL SIZE CHEVROLET/GMC PICKUPS, UTILITIES AND VANS, THE BRAKE PEDAL WILL MOVE DOWN OR...
Read full bulletin
SELF APPLY DURING FULL LOCK TURNS OR NEAR FULL LOCK TURNS. CHEVROLET ASTRO AND GMC SAFARI VANS; HUMMER 2 ARE INCLUDED. *PE UPDATED 5/24/11. *PE
BOOM TYPE NOISE DURING ENGINE WARM UP.
Read full bulletin
THIS SERVICE BULLETIN REPLACES 000605001A. *EH
SERVICE ENGINE SOON LIGHT AND P0300 WHEN TOWING, CRUISING UPHILL OR ON HARD ACCELERATION.
Read full bulletin
*TT
ENGINE COOLANT LEAK AT INTAKE GASKET.
Read full bulletin
* MJ
WINDOW REGULATOR MOTOR DOES NOT FIT.
Read full bulletin
*TT
CONCERNS WITH BOOM TYPE NOISE DURING ENGINE WARM-UP HEARD IN THE VEHICLE PASSENGER COMPARTMENT.
Read full bulletin
*TT
RATTLE NOISE IN ENGINE.
Read full bulletin
*TT
RATTLE NOISE IN ENGINE.
Read full bulletin
*TT
SPECIAL POLICY ADJUSTMENT - WINDSHIELD WIPER MOTOR FAILURES.
Read full bulletin
*TT
Infotainment
7 bulletinsCLN INDICATOR APPEARS ON RADIO DISPLAY AND DOES NOT TURN OFF (RESET CLN INDICATOR WITH THE EJECT BUTTON ON TAPE).
Read full bulletin
*TW
This informational bulletin provides information for dealers/technicians on Procedures to Unlock Delco Radio with...
Read full bulletin
Theftlock.
This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock.
Read full bulletin
Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code. The PI update to version D is to advise the unlock procedure is temporarily unavailable. E version update is to add administrative details.
This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock.
Read full bulletin
Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code. The PI update to version D is to advise the unlock procedure is temporarily unavailable.
This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock.
Read full bulletin
Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.
This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock.
Read full bulletin
Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.
This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock.
Read full bulletin
Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.
Transmission
6 bulletinsDIAGNOSIS OF CRACKED OR BROKEN TRANSMISSION CASE.
Read full bulletin
*TT 2006 AND PRIOR CARS AND LIGHT DUTY TRUCKS. *TT
THIS TECHNICAL SERVICE BULLETIN STATES THAT TECHNICIANS MAY EXPERIENCE DIFFICULTY IN REMOVING THE CONNECTORS FROM THE...
Read full bulletin
PARK / NEUTRAL POSITION SWITCH, USUALLY WHEN TRYING TO REMOVE THE SWITCH DURING TRANSMISSION SERVICE. *TT
AUTOMATIC TRANSMISSION 1-2 AND/OR 2-3 UPSHIFT SLIP/FLARE, NO 3RD OR 4TH GEAR, DTC P1870, LAUNCH SHUDDER (REVISE VCM WIRING).
Read full bulletin
*TW
TRANSMISSION FLUID LEAK FROM PUMP BODY (REPLACE BUSHING).
Read full bulletin
*TW
TRANSMISSION FLUID LEAK FROM PUMP BODY (REPLACE BUSHING).
Read full bulletin
*TW
DIAGNOSTIC INFORMATION FOR INTERMITTENT TRANSMISSION DOWNSHIFT, SLIP, BUSY/CYCLING TCC OR NOISY COOLING FAN.
Read full bulletin
*TT
Fuel System
5 bulletinsSOME VEHICLES MAY EXHIBIT AN EXHAUST NOISE, RATTLE NOISE AT 550 RPM.
Read full bulletin
*TT
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for...
Read full bulletin
the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for...
Read full bulletin
the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for...
Read full bulletin
the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for...
Read full bulletin
the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.
Air Bags & Safety
4 bulletinsINFORMATION REGARDING FASTEN SEAT BELT WARNING AUDIBLE SIGNAL PARTS AVAILABILITY.
Read full bulletin
*SLC
CAMPAIGN PARTS BULLETIN REGARDING FASTEN SEAT BELT WARNING AUDIBLE SIGNAL.
Read full bulletin
*TT
SUBJECT REGARDING FASTEN SEAT BELT WARNING AUDIBLE SIGNAL - PARTS INFORMATION UPDATE.
Read full bulletin
*TT
SUBJECT REGARDING CAMPAIGN 01036 - FASTEN SEAT BELT WARNING AUDIBLE SIGNAL - PARTS INFORMATION UPDATE.
Read full bulletin
*TT
Electrical
4 bulletinsELECTRICAL INTERFERENCE IN MOBILE (TWO-WAY) RADIO (REPROGRAM VCM-A).
Read full bulletin
*TW
Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules
INTERMITTENT BATTERY LIGHT COMES ON, INTERMITTENT NO CRANK.
Read full bulletin
*TT
WINDSHIELD WIPER FAILURE DUE TO CRACKED BOULDER JOINTS ON THE CONTROLLER CIRCUIT BOARD.
Read full bulletin
THIS SPECIAL POLICY COVERS THE CONDITION FOR A PERIOD OF SEVEN YEARS OR 70,000 MILES, WHICHEVER OCCURS FIRST FROM THE DATE THE VEHICLE WAS ORIGINALLY PLACED IN SERVICE REGARDLESS OF OWNERSHIP OR FOR THESE VEHICLES CURRENTLY OUTSIDE OF THIS COVERAGE UNTIL FEBRUARY 29, 2004. *TT
Pre-Delivery & Maintenance
4 bulletinsThis warranty administration bulletin provides information regarding the field action courtesy transportation policy.
This warranty administration bulletin provides information regarding the field action courtesy transportation policy.
This warranty administration bulletin provides information regarding the field action courtesy transportation policy.
This warranty administration bulletin provides policy information with the field action courtesy transportation policy.
Other
2 bulletinsTHIS MESSAGE CONCERNS 1996 THROUGH 2000 M & L VANS, CHEVROLET ASTRO AND GMC SAFARI THAT MAY EXHIBIT A LACK OF HEAT AT THE DRIVER'S SEAT.
Read full bulletin
*TT
SPECIAL POLICY FOR SAFETY BELT GUIDE COVER.
Read full bulletin
*YC
Suspension
2 bulletinsPART NUMBER 15042486 PER BULLETIN 00-03-09-001A FOR THE REAR SPRING DAMPER KIT IS CURRENTLY NOT AVAILABLE.
Read full bulletin
*MJ
PART NUMBER 15042486 LEAF SPRING DAMPER MENTIONED IN TECHNICAL SERVICE BULLETIN (TSB) 00-03-09-001A IS NOT AVAILABLE.
Read full bulletin
*MJ
Brakes
2 bulletinsANTILOCK BRAKE (ABS) ACTIVATION AT LOW SPEEDS ON VARIOUS MODELS INCLUDING THE 1995 AND 1996 ENVOY.
Read full bulletin
*TT
ANTILOCK BRAKE (ABS) ACTIVATION AT LOW SPEEDS.
Read full bulletin
*TT
Body & Paint
1 bulletinSOME CUSTOMERS MAY COMMENT THAT THE RIGHT REAR DOOR HANDLE ON THE CARGO DOOR BREAKS.
Read full bulletin
*TT