2013 Can-Am Spyder RS TSBs
42 Technical Service Bulletins across 12 categories
Categories
Engine
12 bulletinsElectric Throttle Actuator Replacement The Electric Throttle Actuator (ETA) is now available for spare part.
Read full bulletin
In case of any ETA defect, it is not necessary anymore to replace the complete throttle body assembly.
Not shifting when engine gets warm.
Technical Service Tip (TST) addressing that on some SE5 engines a high pitched or whining noise may be heard under specific RPM only.
Read full bulletin
After investigation the cause of this noise is from a thrust washer vibrating and spinning in the HCM. Inspection of the HCM housing for wear is proposed; it may need to be replaced.
Service bulletin informing dealers that a new procedure has been developed to improve the replacement of the tandem...
Read full bulletin
master cylinder (TMC) without the necessity of bleeding the whole brake system.
Posting discussing a possible solution for the Engine coolant over temperature condition, that will be added to the TST.
Posting discussing the Technical Service Tip (TST) about a diagnostic trouble code - Engine coolant over temperature...
Read full bulletin
condition.
Technical Service Tip (TST) addressing a diagnostic trouble code - Engine coolant over temperature condition.
Posting about some units stalling at idle when coming to a stop with the drive train disengaged.
Read full bulletin
The occurrence will be reduced with time and eliminated after the performance of the 1st maintenance or as the engine brake-in is completed.
New EVAP Purge Valve Line Execution.
Read full bulletin
As an improvement to the evaporative emission system (EVAP), BRP just released a new EVAP purge valve line execution.
REVISON 1 OF WARRANTY BULLETIN 2013-9 ADRESSING 3 PROBLEMS: A) SEAL THE FRONT FUSE BOXES BECAUSE WATER MAY INFILTRATE...
Read full bulletin
EITHER OF THE FRONT FUSE BOXES; B) UPDATE ECM SOFTWARE BECAUSE CODE P1614 MAY BE TRIGGERED AND CAUSE A LIMP HOME MODE WHEN STARTING THE ENGINE; C) REPLACE UPPER BELT GUARD RETAINING SCREWS THAT MAY NOT SECURE THE BELT GUARD PROPERLY.
BOMBARDIER ROADSTER: COMPLAINT REGARDING OIL LEAK CLUTCH COVER OIL PRESSURE SENSOR THREADS.
Read full bulletin
*LJ
BRP MC: WHEN ENGINE IS AT OPERATING TEMPERATURE AND HAS DIFFICULTY OR FAILS TO SHIFT AT ALL, THE OIL PRESSURE REGULATOR...
Read full bulletin
ASSEMBLY NEEDS CHECKING OR THE STEEL SLEEVE IS NOT PRESSED IN. MODEL 2013 SE5. *PE
Brakes
6 bulletinsTechnical Service Tip (TST) informing dealers that that a very limited quantity of the vehicles identified in the letter...
Read full bulletin
may have been produced with incorrectly routed electrical wires and brake lines. A very limited quantity of vehicles may have been produced with incorrectly routed electrical wires and brake lines. Dealership has received by regular mail and by e-mail the specific instructions concerning the inspection, repair and warranty procedures for this situation.
Letter to dealers informing them that a very limited quantity of the vehicles identified in the letter may have been...
Read full bulletin
produced with incorrectly routed electrical wires and brake lines. Instruction are provided.
Warranty bulletin addressing a possible front shocks dampening issue.
Read full bulletin
Some vehicles may have been produced with shock absorbers without enough dampening. The proposed solution is to replace both front shocks if problem is encountered.
Warranty bulletin addressing a possible front shocks dampening issue.
Read full bulletin
Some vehicles may have been produced with shock absorbers without enough dampening. The proposed solution is to replace both front shocks if problem is encountered.
Technical Service Tip (TST): A very limited quantity of vehicles may have been produced with incorrectly routed electrical wires and brake lines.
Read full bulletin
Dealerships has received the specific instructions concerning the inspection, repair and warranty procedures for this situation. Letter to dealers sent on December 3, 2012 is attached.
BRP MC: WHEN BRAKE PEDAL IS RESTING ON HUMP STOP, THE BRAKE LIGHT REMAINS ON, CAUSING DRAINAGE TO THE BATTERY.
Read full bulletin
MODEL 2013 ROADSTER. *PE
Electrical
5 bulletinsTrailer module may fail.
RT-622 Trailers may experience electrical issues due to trailer light module failure.
Technical Service Tip (TST) (revision): Customer may complain of excessive heat felt on the lateral panels in certain riding conditions.
Read full bulletin
Steps to install panels. Make sure the unit has the 2013-9 Warranty Campaign ECM update perform prior to the installation of these panels.
TECHNICAL SERVICE TIP (TST): CUSTOMER MAY COMPLAIN OF EXCESSIVE HEAT FELT ON THE LATERAL PANELS IN CERTAIN RIDING CONDITIONS.
Read full bulletin
SOLUTION IS TO INSTALL THE AIR SCOOP PANEL KIT. MAKE SURE THE UNIT HAS THE 2013-9 WARRANTY CAMPAIGN ECM UPDATE PERFORM PRIOR TO THE INSTALLATION OF THESE PANELS.
TECHNICAL SERVICE TIP (TST):INSTRUCTION TO BE FOLLOWED IF A CUSTOMER COMPLAINS OF EXCESSIVE HEAT FELT ON THE LATERAL...
Read full bulletin
PANELS IN CERTAIN RIDING CONDITIONS. THE SOLUTION IS TO MAKE SURE THE UNIT HAS THE 2013-9 WARRANTY CAMPAIGN ECM UPDATE PERFORM PRIOR TO THE INSTALLATION OF THESE PANEL AND THE INSTALLATION THE AIR SCOOP PANEL KIT.
Suspension
4 bulletinsRevision #1 of warranty bulletin 2013-6 addressing the issue that some vehicles have been produced with weak stabilizer bar link rods.
Read full bulletin
Remove and inspect each link rod to find their production number. Replace if production number shows a "4", as CCVI 4 WITHOUT a painted dot.
Revision #1 of warranty bulletin 2013-6 addressing the issue that some vehicles have been produced with weak stabilizer bar link rods.
Read full bulletin
Remove and inspect each link rod to find their production number. Replace if production number shows a "4", as CCVI 4 WITHOUT a painted dot.
Technical Service Tip (TST) addressing that in order to properly investigate a Soft suspension complaint, provide the...
Read full bulletin
information listed to the BRP technical support team.
WARRANTY BULLETIN ADDRESSING THE PROBLEM THAT SOME VEHICLES HAVE BEEN PRODUCED USING FRONT SUSPENSION LOWER ARM BALL...
Read full bulletin
JOINTS WITH TOO HIGH FRICTION THAT MAY AFFECT THE DYNAMIC DRIVING PERFORMANCE AND THE CUSTOMER SATISFACTION. THE PROPOSED SOLUTION IS TO REPLACE SUSPENSION LOWER ARM BALL JOINTS (BOTH SIDES).
Software & Calibration
4 bulletinsPosting and updates regarding the issue of handling behaviors on some 2013 models.
Read full bulletin
Specific instructions is given by BRP to dealers.
POSTING AND UPDATES REGARDING THE ISSUE OF HANDLING BEHAVIORS ON SOME 2013 MODELS.
Read full bulletin
SPECIFIC INSTRUCTIONS IS GIVEN BY BRP TO DEALERS.
POSTING AND UPDATES REGARDING THE ISSUE OF HANDLING BEHAVIORS ON SOME 2013 MODELS.
Read full bulletin
SPECIFIC INSTRUCTIONS IS GIVEN BY BRP TO DEALERS.
POSTING AND UPDATES REGARDING THE ISSUE OF HANDLING BEHAVIORS ON SOME 2013 MODELS.
Pre-Delivery & Maintenance
3 bulletinsWarranty campaign explanation.
Posting informing the community that BRP has been investigating multiple issues with 2013 units and it has come up with a number of solutions.
Read full bulletin
Technical service tips (TST) has been made to assist with diagnostics. TST also goes over numerous campaigns and bulletins.
Posting informing the community that BRP has been investigating multiple issues with 2013 units and it has come up with a number of solutions.
Read full bulletin
Technical service tips (TST) has been made to assist with diagnostics. TST also goes over numerous campaigns and bulletins.
Other
2 bulletinsAir scoop retrofit kits.
Special repair needed at PDI.
Transmission
2 bulletinsThis older dealer posting regarding SE5 clutch chatter at take off will now have a reference to the revised version of...
Read full bulletin
Article 68498.
Technical Service Tip (TST) related to clutch engagement which could chatter or shutter.
Infotainment
1 bulletinIf a customer wants to change the radio pre-set channel number and is unable to do so, here is the reason this is...
Read full bulletin
happening.
Fuel System
1 bulletinPosting informing the community that a solution has been found for issue regarding the cluster fuel level indicator.
Read full bulletin
B.U.D.S. Has an update for this model and a bulletin will be released in a near future.
Tires & Wheels
1 bulletinWarranty bulletin addressing the problem that some units left the factory with the wheel alignment out of the specification.
Read full bulletin
The solution is to verify the wheel alignment and, if necessary, adjust it according to the improved procedure.
Lighting
1 bulletinPOSTING ADDRESSING THE PROBLEM THAT SOME 2013 UNITS MAY HAVE BEEN DELIVERED WITH AN "OUT OF SPECIFICATION" ALIGNMENT.
Read full bulletin
IF THE DEALER FINDS THAT THE UNIT IS AFFECTED, THEY NEED TO FOLLOW THE LINK TO TST AND FOLLOW THE DETAILED INSTRUCTIONS