2012 Can-Am Spyder RS TSBs
17 Technical Service Bulletins across 8 categories
Categories
Electrical
5 bulletinsTrailer module may fail.
RT-622 Trailers may experience electrical issues due to trailer light module failure.
Article informing dealers of Safety Campaign 2012-13 - Fuel Cap replacement.
Read full bulletin
The fuel cap may not seal properly the fuel tank filler neck. Fuel vapors in the presence of an ignition source could result in a fire.
TECHNICAL SERVICE TIP (TST) ADDRESSING THE DETAILS OF THE RECALL FUEL CAP REPLACEMENT, WHERE THE FUEL CAP MAY NOT SEAL...
Read full bulletin
PROPERLY ONTO THE FUEL TANK FILTER NECK. FUEL VAPORS IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE. BRP IS SENDING OUT REPLACEMENT FUEL CAPS TO ALL CANADIAN AND USA REGISTERED OWNERS.
BRP: ON THE CAN-AM ROADSTER, THE FUEL CAP FAILS TO SEAL PROPERLY, ON FUEL TANK FILLER NECK, CAUSING FUEL VAPORS AND IN...
Read full bulletin
PRESENCE OF AN IGNITION SOURCE, MIGHT RESULT IN A FIRE AND NEEDS REPLACING. MODELS 2008-2012 CAN-AM SPYDER GS, RS, AND RT. *PE
Engine
5 bulletinsTechnical Service Tip (TST) addressing that on some SE5 engines a high pitched or whining noise may be heard under specific RPM only.
Read full bulletin
After investigation the cause of this noise is from a thrust washer vibrating and spinning in the HCM. Inspection of the HCM housing for wear is proposed; it may need to be replaced.
Service bulletin informing dealers that a new procedure has been developed to improve the replacement of the tandem...
Read full bulletin
master cylinder (TMC) without the necessity of bleeding the whole brake system.
BRP: POSSIBLE CONSEQUENCES AT LOW SPEED, ENGINE COMPARTMENT TEMPERATURE WILL RISE AND INCREASE BURN SKIN OR VEHICLE...
Read full bulletin
FIRE DURING AMBIENT HOT CONDITIONS. MODEL 2013 ROADSTER. *PE
BRP: ON SOME MOTORCYCLES, NEED TO HAVE THE FRONT FUSE BOX COVERS REPLACED WITH AN IMPROVED COVER IN PRODUCTION AND...
Read full bulletin
ALSO, UPDATE ECM SOFTWARE (P1614, HI TEMP LAMPS, LIMP HOME MODE). *PE
BRP: THE SHIFT UP AND DOWN PADDLE FAILS TO WORK AND ADJUSTMENT IS NEEDED THAT MIGHT IMPROVE THE SITUATION ON CERTAIN MODEL MOTORCYCLES.
Read full bulletin
MODEL SPYDER GS/RS. NO MODEL YEARS LISTED. *PE
Other
2 bulletinsAir scoop retrofit kits.
Posting stating that it has come to BRP's attention that water pump mechanical failure has risen in recent weeks.
Read full bulletin
In the event you have a Spyder with a leak from the weep hole, please send information to BRP.
Infotainment
1 bulletinIf a customer wants to change the radio pre-set channel number and is unable to do so, here is the reason this is...
Read full bulletin
happening.
Body & Paint
1 bulletinTechnical service Tip (TST) informing the community that it has come to BRP's attention that water pump mechanical seal...
Read full bulletin
failures have risen in recent weeks. In the event that dealers have a Spyder leak from the weep hole (oil or coolant), BRP would like to have more information.
Pre-Delivery & Maintenance
1 bulletinPosting informing the community that some of them may have seen an alert from Transport Canada regarding a recall on certain Spyder models.
Read full bulletin
(recall 2012-13)
Transmission
1 bulletinPosting informing the community that after investigation, the conclusion is that some 2012 units were produced with...
Read full bulletin
water pumps mechanical seals installed slightly crocked in the clutch cover. This cause the seal to develop a leak on the side of the seal that had less pressure. Replacement parts should be installed using the revised procedure of the 2013 shop manual. TST is enclosed for the replacement procedure.
Fuel System
1 bulletinPOSTING DISCUSSING THE TWO RECALLS POSTED ON TRANSPORT CANADA AND NHTSA CONCERNING THE FUEL VAPOR CANISTER VENT HOSE TO...
Read full bulletin
BE REPLACE OR RE-ROUTE AND FUEL CAP REPLACEMENT BECAUSE THE FUEL CAP MAY NOT FIT ONTO THE FUEL TANK FILTER NECK.