2010 Can-Am Spyder RS TSBs
15 Technical Service Bulletins across 7 categories
Engine
5 bulletinsTechnical Service Tip (TST) addressing that on some SE5 engines a high pitched or whining noise may be heard under specific RPM only.
Read full bulletin
After investigation the cause of this noise is from a thrust washer vibrating and spinning in the HCM. Inspection of the HCM housing for wear is proposed; it may need to be replaced.
Article discussing the safety campaign 2010-12 - Fuel Vapor Canister Vent hose inspection/replacement.
Read full bulletin
In some circumstances, fuel vapors may exit the fuel vapor canister vent hose in the enclosed engine compartment. Fuel vapors in the presence of an ignition source could result in a fire. The proposed solution is to inspect the fuel vapor canister vent hose to determine if the proper hose is installed. replace and re-route the fuel vapor canister vent hose if required.
Service bulletin informing dealers that a new procedure has been developed to improve the replacement of the tandem...
Read full bulletin
master cylinder (TMC) without the necessity of bleeding the whole brake system.
BRP: SOME ENGINES (SE5) HAVE A HIGH PITCHED OR WHINING NOISE, LEFT HAND SIDE, CAN BE HEARD UNDER SPECIFIC RPM.
Read full bulletin
MODEL ROADSTER. NO YEARS. *PE
BRP: THE SHIFT UP AND DOWN PADDLE FAILS TO WORK AND ADJUSTMENT IS NEEDED THAT MIGHT IMPROVE THE SITUATION ON CERTAIN MODEL MOTORCYCLES.
Read full bulletin
MODEL SPYDER GS/RS. NO MODEL YEARS LISTED. *PE
Electrical
4 bulletinsTrailer module may fail.
Article informing dealers of Safety Campaign 2012-13 - Fuel Cap replacement.
Read full bulletin
The fuel cap may not seal properly the fuel tank filler neck. Fuel vapors in the presence of an ignition source could result in a fire.
TECHNICAL SERVICE TIP (TST) ADDRESSING THE DETAILS OF THE RECALL FUEL CAP REPLACEMENT, WHERE THE FUEL CAP MAY NOT SEAL...
Read full bulletin
PROPERLY ONTO THE FUEL TANK FILTER NECK. FUEL VAPORS IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE. BRP IS SENDING OUT REPLACEMENT FUEL CAPS TO ALL CANADIAN AND USA REGISTERED OWNERS.
BRP: ON THE CAN-AM ROADSTER, THE FUEL CAP FAILS TO SEAL PROPERLY, ON FUEL TANK FILLER NECK, CAUSING FUEL VAPORS AND IN...
Read full bulletin
PRESENCE OF AN IGNITION SOURCE, MIGHT RESULT IN A FIRE AND NEEDS REPLACING. MODELS 2008-2012 CAN-AM SPYDER GS, RS, AND RT. *PE
Other
2 bulletinsAir scoop retrofit kits.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
Infotainment
1 bulletinIf a customer wants to change the radio pre-set channel number and is unable to do so, here is the reason this is...
Read full bulletin
happening.
Pre-Delivery & Maintenance
1 bulletinPosting informing the community that some of them may have seen an alert from Transport Canada regarding a recall on certain Spyder models.
Read full bulletin
(recall 2012-13)
Steering
1 bulletinRevision #1 of Warranty bulletin 2010-7 dated September 7, 2010.
Read full bulletin
This safety recall addressed the problem that a situation may occur where you may need to exert a force greater than expected to initiate the turning of the steering handlebar of your vehicle in order to correct its trajectory. At this increased level of force the handlebar may be turned more than you had intended. If this occurs you may steer your vehicle out of lane which increases the possibility of a crash with other traffic or of a drive off the road. As of April 2, 2013, the return procedure has been updated.
Fuel System
1 bulletinPOSTING DISCUSSING THE TWO RECALLS POSTED ON TRANSPORT CANADA AND NHTSA CONCERNING THE FUEL VAPOR CANISTER VENT HOSE TO...
Read full bulletin
BE REPLACE OR RE-ROUTE AND FUEL CAP REPLACEMENT BECAUSE THE FUEL CAP MAY NOT FIT ONTO THE FUEL TANK FILTER NECK.