2008 Buell 1125R TSBs
5 Technical Service Bulletins across 2 categories
Engine
4 bulletinsBUELL MOTORCYCLES: CERTAIN MOTORCYCLES-1125R AND 1125CR 2009-10 AND 2008 1125R HAVE BEEN REFITTED WITH A 2009 OR 2010 ENGINE.
Read full bulletin
ON THESE MODELS THE STATOR MAY OPERATE AT TEMPERATURES THAT EXCEED THE MANUFACTURER'S RECOMMENDATION WHEN THE VEHICLE IS RIDDEN IN LOWER RPM (BELOW 5,000 RPM) DUTY CYCLES. THE MODELS MAY EXPERIENCE CHARGING SYSTEM ISSUES RELATED TO EXCESSIVE STATOR HEAT. *PE UPDATED 6/11/10. *PE
BUELL MOTORCYCLE: MOTORCYCLES HAVE A FRONT BRAKE LINE WHICH MAY CONTACT THE FRONT TIRE.
Read full bulletin
THE CONDITION COULD CAUSE A HOLE TO DEVELOP IN THE FRONT BRAKE LINE, ALLOWING BRAKE FLUID TO LEAK. MODELS 1125R, XB12R, XB12SCG. *PE
BUELL MOTORCYCLES: MOTORCYCLES EQUIPPED WITH CALIFORNIA EVAPORATIVE EMISSIONS COMPONENTS DO NOT REQUIRE THE VENT LINE UPGRADE PROCEDURE.
Read full bulletin
SIDESTAND SPRING/OIL FILLER PLUG INSPECTIONS/REPLACEMENT ARE THE ONLY PROCEDURES THAT SHOULD BE PERFORMED. *PE
BUELL MOTORCYCLE: A CONDITION AFFECTING MOTOR VEHICLE SAFETY EXISTS ON CERTAIN 2008 1125R MOTORCYCLES.
Read full bulletin
MOTORCYCLE CAN EXPERIENCE 5TH GEAR GALLING ON THE CLUTCH SHAFT DUE TO LACK OF LUBRICATION. *PE
Brakes
1 bulletinSERVICE BULLETIN M1684: MARKET SPECIFIC BATTERY INTRODUCTION.
Read full bulletin
PURPOSE: Initial Release. This bulletin informs dealers of the availability of new batteries for new Original Equipment (OE) vehicle production and in the Parts and Accessories (P&A) catalog. Availability of the new Absorbed Glass Mat (AGM) batteries will vary by market and will be transitioning over the next few months. NOTE: The ring terminal screws are not compatible between Leoch and East Penn batteries. The new batteries will include new ring terminal screws, which must be used. The ring terminal screws from the old battery need to be discarded.