2003 BMW X5 TSBs

There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the DME: 032B43 - Low fuel pressure system, electric fuel pump: pressure value too low CDA594 - Message (- 0x33E) missing, receiver DME, transmitter TFE

when placing the key against the steering column.

A low coolant warning might also be displayed (CC Message ID166).

when placing the key against the steering column. Note: Opening, closing and starting via the BMW Digital Key or the Digital Key Card are not affected.

The customer of an affected vehicle may fail to pass an I/M test due to a non-compliant 17digit vehicle identification number (VIN) stored in the DME (Digital Motor Electronic). The VIN read out and displayed on the state test printout does not match the actual VIN of the vehicle. If the DME was reprogrammed using the previously available BMW service equipment (e.g., Progman, GT1), it is possible that only the last 7 digits of the VIN were entered into the DME, and positions 4 through10 may only contain default characters. For example: The state I/M tester or OBD scan tool may read out WBAAA00000A123456 instead of the correct full 17-digit VIN, WBAZZ03492A123456.

The Anti-lock Brakes (ABS), Brakes and Dynamic Stability Control (DSC) warnings are on and there may also be a ""Drivetrain Malfunction"" warning on in the Control Display. There is also an audible clicking noise coming from the transfer case actuator when cycling the ignition. The following fault codes may be stored: (DSC) 5F3A - Clutch gearbox-ECU: clutch is open - rear-wheel drive! (VTG) 5463 - Break mechanics (VTG) 5462 - Error actuator or increased power requirements for clutch (VTG) 5461 - Error actuator control Internal wear to the plastic gears of the transfer case actuator."

THIS IS DESIGNATED FOR E70, AND E90 MODELS WITH M57Y DIESEL ENGINES. SERVICE ENGINE SOON LAMP MAY BE ILLUMINATED. *KB

N52K ENGINE DMTL PUMP: EMISSIONS WARRANTY EXTENSIONS TO 10 YEARS/120,000 MILES. BMW HAS BECOME AWARE OF A POTENTIAL PROBLEM WITH THE DURABILITY OF THE TANK LEAK DIAGNOSTIC MODULE (DMTL) PUMP ON MY 2007,2008, AND 2009.*JS

THERE ARE TROUBLE CODES STORED FOR THE CRANKSHAFT SENSOR. NO DRIVEABILITY ISSUES. *RM

THIS IS DUE TO MOISTURE ACCUMULATION. *RM

THE ENGINE WILL ONLY OPERATE TO 1500 RPMS AND LACKS POWER. THERE IS A SOFTWARE APPLICATION ERROR. *RM

*RM

THERE MAY BE SIX DIFFERENT FAULT CODES. *RM

THE LIGHT COMES ON A FEW THOUSAND MILES EARLIER THAN A RECOMMENDED OIL CHANGE. *RM

COMPLAINTS THAT THE SERVICE ENGINE SOON LAMP IS ILLUMINATED. FAULT CODE 2EF4 CHARACTERISTIC MAP THERMOSTAT IS STORED IN DME FAULT MEMORY. DME SOFTWARE CALIBRATION RELATED TO HIGH HEATING REQUIREMENTS DURING SUBZERO DRIVING CONDITIONS. REPROGRAM VEHICLE WITH V27.1 (I LEVEL E070-07-09-520) OR HIGHER. *PE

THE CUSTOMER MAY COMPLAIN OF INTERMITTENT DRIVEABILITY PROBLEMS, DESCRIBED AS-ENGINE IS LACKING POWER WHEN ACCELERATING UPHILL; TRANSMISSION WILL NOT UPSHIFT UNDER HEAVY ACCELERATION; DISTINCT HESITATION WHEN ACCELERATING FROM 30-45MPH. NO MODEL YEARS LISTED. *PE

THE SERVICE ENGINE SOON LAMP IS ILLUMINATED (A FUEL PUMP MALFUCTION MESSAGE IS DISPLAYED IN THE CC), AND A COMBINATION OF THE FOLLOWING FAULT CODES MAY BE STORED IN THE DDE CONTROL MODULE: 4BED/4BDD FUEL PRESSURE CONTROL, CONTROL DEVIATION (PRESSURE TOO HIGH/TOO LOW); 4BDB FUEL PRE SUPPLY PRESSURE CONTROL, CONTROL DEVIATION/NEGATIVE AND 6292 CONTROL VOLTAGE TOO LOW, IMPLAUSIBLE SIGNAL CURRENTLY PRESENT. *PE

SERVICE ENGINE SOON LAMP IS ILLUMINATED (A FUEL PUMP MALFUNCTION MESSAGE IS DISPLAYED IN THE CC) AND A COMBINATION OF THE FOLLOWING FAULT CODES MAY BE STORED IN THE DDE CONTROL MODULE. MODEL YEARS UNKNOWN. *PE

TO COMPLETE ENGINE FAILURE IN EXTREMELY COLD CLIMATE CONDITIONS. MOISTURE ACCUMULATING IN ENGINE CRANKCASE VENTILATION VALVE OR HOSES CAN FREEZE DUE TO LOW AMBIENT TEMPERATURES. *PE

E53 (X5) WITH M54 ENGINE AND GM5 TRANSMISSION PRODUCED 9/3003 - 10/2004. *PE

Visible stitching on first row sport seat. Third seat row backrest Bowden cable routing and length change.

In the Instrument cluster, the red air bag warning light lights up permanently. One of the following fault codes stored in the ACSM (air bag control unit): 930949 - Knee airbag, driver: short circuit to negative terminal; 93094F - Knee airbag, front passenger: short circuit to negative terminal.

CUSTOMER SUPPORT PROGRAM. FRONT DRIVER SIDE AIRBAG MODULES.

Customer Support Program as outlined in the Takata Settlement Customer Support Program Overview attachment. This ?component-specific? customer support program applies only if there is a defect in materials or workmanship of the Takata driver?s side airbag module in a listed vehicle.

DUE TO HIGH PROPORTION OF ETHANOL IN THE FUEL, THE INTERNAL MECHANISMS OF THE FUEL LEVEL SENSORS MAY SWELL. THIS MAY INHIBIT THE MOVEMENT OF ONE OR BOTH OF THE FUEL LEVEL SENSORS. *JS

THE REAR TAILGATE MAY NOT OPERATE IN EITHER DIRECTION DUE TO WIRING DAMAGE. *RM

*RM

ON THE VEHICLE, VARIOUS ELECTRICAL PROBLEMS ARE POSSIBLE. WARNING LAMPS ILLUMINATED IN THE INSTRUMENT CLUSTER; CHECK CONTROL MESSAGES; SYSTEMS INOPERATIVE; FUSE BLOWN; WIPERS IN DEFAULT MODE (PERMANENTLY ON); AND FAULT CODES FFFF AND F-CAN FAULTS IN ARS AND DSC. SHORT CIRCUIT OF THE WIRING HARNESS TO SHARP SHEET METAL IMMEDIATELY BEHIND THE GLOVE COMPARTMENT. NO MODEL YEARS LISTED. *PE

WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS WELL. IN SOME CASES, EPC DOES NOT SHOW THAT THE REPAIR KIT IS AVAILABLE SEPARATELY IN THE ILLUSTRATION, BUT IT IS AVAILABLE IN THE PARTS DESCRIPTION. ALL MODELS. NO MODEL YEARS LISTED. *PE

THE ELECTRONIC MALFUNCTION CHECK CONTROL MESSAGE MAY BE DISPLAYED; THE SOUNDS SYSTEM EMITS A STATIC NOISE FROM THE SPEAKERS; THE RFK (REAR VIEW CAMERA) DOES NOT PAN; THE AIRBAG WARNING LIGHT MAY BE ILLUMINATED; KCAN COMMUNICATION, KCAN LINE AND KCAN WIRE FAULTS ARE STORED IN VARIOUS CONTROL MODULES. SHORTED WIRING AT THE LEFT OR RIGHT SUBWOOFER SPEAKER MOUNTED UNDER THE FRONT SEATS. NO MODEL YEARS LISTED. *PE

VEHICLE WILL NOT START. INSTRUMENT CLUSTER OR DISPLAYS ARE FLICKERING. REMOTE CONTROL WILL NOT UNLOCK VEHICLE. VARIOUS CONTROL MODULES CANNOT BE ACCESSED USING THE DIAGNOSIS SYSTEM. THE CLIP(1) ON THE POWER SUPPLY TERMINAL(2) (X16825 INTHE REAR POWER DISTRIBUTION BOX, OR X16824 INTHE FRONT JBE [JUNCTION BOX ELECTRONICS]), IS EITHER LOOSE OR MISSING. *PE

CLUSTER; CHECK CONTROL MESSAGES; SYSTEMS INOPERATIVE; FUSE BLOWN; WIPERS IN DEFAULT MODE (PERMANENTLY ON); AND FAULT CODES FFFF AND F-CAN FAULTS IN ARS AND DSC. SHORT CIRCUIT OF THE WIRING HARNESS TO SHARP SHEET METAL IMMEDIATELY BEHIND THE GLOVE COMPARTMENT. MODEL E70 (X5) NO MODEL YEARS LISTED. *PE UPDATED 11/17/10. *PE

*NJ

DOFF DURING DRIVING AND THE CONTROL CHECK MESSAGE IS INDICATING DEFECTIVE DRIVING LIGHT OR PARKING LIGHT. *PE

THE ROOT CAUSE IS NOT POSSIBLE TO BE IDENTIFY. *PE

*PE

*RM

MODEL E90, E91(3 SERIES);E92, E92 (3 SERIES); E60 (5 SERIES); E60 (M5); E63, E64 (6 SERIES); E63, E64 (M6); E65, E66 (7 SERIES); E70 (X5); E83 (X3); AND E85, E86 (Z4). *PE

THE DSC (DYNAMIC STABILITY CONTROL) WARNING LAMP IS ILLUMINATED AND SOME OR ALL OF THE FOLLOWING FAULT CODES ARE STORED: 6E58; 6E04; 53BA; D36F; 55C3; 6ECA; AND THE WIPERS MAY ALSO BE OPERATING IN DEFAULT MODE. *PE

WATER OR CONDENSATION IN ONE OR BOTH HEADLAMPS. MODELS 5 SERIES, 6 SERIES, 7 SERIES, X5, X6, 1 SERIES, AND 3 SERIES. MODEL YEARS 2000-20008. *PE

E70 (X5) VEHICLES PRODUCED UP TO JANUARY 28, 2007. *PE UPDATED 9/10/08. *PE

Depending on the vehicles equipment and settings, no acoustic or optical confirmation (folding the mirrors/blinking confirmation) is noticeable. Additionally, the red anti-theft alarm LED in the interior mirror does not briefly flash every 2 seconds, indicating the alarm is armed.

INFORMATION Sunroof Repair Instructions: The panoramic sunroof contains several ""mechanism sets"" which can be repaired and/or replaced independently in the event of a mechanical failure. When performing such a repair to any of these sets, the TIS/ISTA Repair Instructions (REP) should always be consulted. Due to the complex nature of these repairs, a set of complementary instructions with additional detail, explanation, and photos has been developed. The attached Repair Instructions should always be used in conjunction with the TIS/ISTA REP. "

INFORMATION Sunroof Repair Instructions: The panoramic sunroof contains several ""mechanism sets"" which can be repaired and/or replaced independently in the event of a mechanical failure. When performing such a repair to any of these sets, the TIS/ISTA Repair Instructions (REP) should always be consulted. Due to the complex nature of these repairs, a set of complementary instructions with additional detail, explanation, and photos has been developed. The attached Repair Instructions should always be used in conjunction with the TIS/ISTA REP. Refer to the following repair attachments: Front Glass Mechanism repair E53, E61, E70, E83, E91.pdf Rear Glass Mechanism repair E53, E61, E70, E83, E91.pdf Wind Deflector Mechanism repair E53, E61, E70, E83, E91.pdf Sunshade Mechanism repair E53, E61, E83.pdf Sunshade Mechanism repair E70, E91.pdf All panoramic roofs for the above-listed models are conceptually similar and utilize similar repairs. NOTE: An E83 (X3) sunroof cassette is used for demonstration of the repairs. Some differences may exist between this and other models. The following prerequisite work is required in order to replace the following kits (in addition to removing the cassette from the car and glass from the cassette): Front Glass Mechanism - None. Rear Glass Mechanism - Remove the front glass mechanism. Wind Deflector Mechanism - Remove the front glass mechanism; remove the rear glass mechanism. Sun shades and Shade Mechanism - None Sunroof Mechanical 3D Animation: A 3D animation has been developed in order to clarify how the sunroof mechanism operates, as well as how it is assembled and disassembled. To view this animation, open Interactive Career Pathways (ICP) and select ""Replace Front and Rear Glass Panel Mechanic"" from the Technical Service Information section of the home page. This animation allows you to: * Operate the mechanism and view from any angle; * Add or remove parts and then cycle the sunroof; * S

*PE

*KB

*EH

Wind noise 2. Excess water entry

Alternatively, it will only operate when constant downward hand pressure is maintained.

side (inner rail).

THIS IS CAUSED ON SHORT TRIPS (LESS THAN 3 MILES) OR WHEN THE TELEPHONE OR ENTERTAINMENT SYSTEM IS USED FOR UP TO 30 MINUTES WHILE VEHICLE IS STATIONARY. MODELS X5, X6 ALL MODEL YEARS AFFECTED. *KB

*RM

COMPLAINTS OF CLICKING OR GRINDING NOISES COMING FROM THE FRONT AXLE AREA WHEN MAKING A TURN. THE FRONT OUTER CONSTANT VELOCITY JOINT BOOT IS SPLIT OPEN AND THE JOINT IS ALREADY DAMAGED. *PE

bulletin supersedes SI B01 31 18 dated October 2018.

bulletin supersedes SI B01 31 18 dated October 2018.

Ultimate Rewards platform to include a new Recall Support page. This page will allow IRFs to check their customers VINs for open Takata recalls; and get rewarded for helping us with completing repairs.

*TA

*RM

THE AIRBAG WARNING LAMP (AWL) IS ILLUMINATED, TOGETHER WITH THE PASSENGER AIRBAG STATUS LAMP (POL). THE PROBLEM MAY BE INTERMITTENT. MICROCRACKS IN THE OC3 SEAT MAT. *PE UPDATED 9/30/11. *PE

*RM UPDATED ON 4/25/2013. *KB

FOR MODEL E70 (X5). *PE

THIS SERVICE MEASURE SUPERSEDES SMM1220404 DATED 04/07/2004. *EH

*TT

*RM

E70 (X5) WITH SPORT PACKAGE OPTION CODE ZSP. *PE

*SC X5 FROM 10/03 UP TO 04/05. *TT