2010 BMW 3 Series TSBs

*

*PE

VEHICLE MAY HAVE REDUCED POWER OUTPUT. FAULT CODE MAY NOT CLEAR FROM DME FAULT MEMORY. *KB UPDATED ON 11/8/2013. *KB UPDATED 2/21/2014 *JS UPDATED 3/11/14. *PE

*KB UPDATED 11/1/13. *PE UPDATED 05/05/2014 *JS

SPECIFIC SITUATION OF UNDERVOLTAGE DURING ENGINE START UP. MODEL 2010-2012 F30 (3 SERIES). *PE

*PE UPDATED 10/31/12. *PE MODELS 2010 E70, 71, 82, 88, 90, 92, 93, F07, 10, 12, 13, 25. UPDATED 1/18/13. *PE UPDATED 4/18/2013. *KB UPDATED 05/13/2013 *JS UPDATED 5/19/15. *PE

82,000 MILES, WHICHEVER COMES FIRST, NOT OTHERWISE FALLING WITHIN COVERAGE EXCLUSION. *PE

SYMPTOMS SUCH AS ERRATIC ENGINE OPERATION AND LONGER STARTING TIMES. *PE

*RM UPDATED ON 4/24/2013. *KB

INTERNAL DMTL PUMP FAILURE.*RM

*RM

THERE ARE TROUBLE CODES STORED FOR THE CRANKSHAFT SENSOR. NO DRIVEABILITY ISSUES. *RM

IN THE SEIZING OF THE TURBOCHARGER ASSEMBLY. *RM UPDATED 7/09/13. *PE UPDATED 9/25/15. *PE

THERE MAY BE A PROBLEM WITH THE FUEL PUMP WHICH COULD NOT MEET EMISSIONS REQUIREMENTS. THERE MAY BE A LONG CRANK AND A SERVICE ENGINE SOON LIGHT. *RM

*RM

THERE WILL BE STORED TROUBLE CODES. *RM

THIS IS A PROGRAMMING ISSUE. *RM UPDATED 1/4/12. *PE UPDATED 4/24/12. *PE

THERE IS A WIRING/CONNECTION PROBLEM OR A FAULTY SENSOR. *RM

*RM

THIS IS CAUSED BY MULTIPLE SHORT START-UPS WITHOUT THE ENGINE PROPERLY GOING THROUGH A WARM-UP PHASE. *RM

THE SERVICE ENGINE SOON LIGHT MAY ALSO BE ON WITH A LACK OF ENGINE POWER. *RM

WASTEGATE VALVE IS NOT COMPLETELY CLOSING AND CLANKING. *RM UPDATED 7/17/12. *PE

THIS IS AN IGNITION COIL PROBLEM. *RM

THE VEHICLE LOST POWER AND THE ENGINE CRANKS WITH NO START. *RM UPDATED 5/19/15. *PE

*RM

ENGINE SPEED ONLY INCREASES WHILE IN NEUTRAL OR PARK. *RM UPDATED ON 5/1/2012. *KB

*RM

*RM

*RM

THIS IS DUE TO MOISTURE ACCUMULATION. *RM

THE ENGINE WILL ONLY OPERATE TO 1500 RPMS AND LACKS POWER. THERE IS A SOFTWARE APPLICATION ERROR. *RM

*RM

*RM

THERE MAY BE SIX DIFFERENT FAULT CODES. *RM

THE LIGHT COMES ON A FEW THOUSAND MILES EARLIER THAN A RECOMMENDED OIL CHANGE. *RM

SERVICE ENGINE SOON (MIL) LAMP MAY COME ON DUE TO A DIAGNOSTIC ERROR. TO DETERMINE WHETHER A SPECIFIC VEHICLE HAS HAD THIS SERVICE COMPLETED OR IS AFFECTED BY THIS SERVICE, FIRST CHECK THE B PILLAR LAB EL FOR CODE NUMBER 577. IF CODE NUMBER BEEN PUNCHED OUT, WAS ALREADY PERFORMED. IF NOT PUNCHED OUT, ITS NECESSARY TO UTILIZE KEY READER. PROGRAM THE VEHICLE USING ISTA/P 2.39.2 OR LATER. *PE

AN ENHANCED TECHNICAL SUPPORT (TEILECLEARING) PROCESS HAS BEEN DEVELOPED TO HELP IDENTIFY THE ROOT CAUSES OF COMPLAINTS RELATING TO THE DRIVABILITY AND FUEL SYSTEM (E.G., LONG CRANK, LOSS OF POWER, SES LAMP ON, ETC.). THIS PROCESS CAN ALSO HELP EXPEDITE THE DEFECT ERADICATION PROCESS, ONCE THE ROOT CAUSE HAS BEEN DETERMINED. MODELS E60, 61 (5 SERIES), E70 (X5 SPORTS), E71 (X6 SPORTS), E82, E88 (1 SERIES), E89 (Z4), E90, 92, 93 (3 SERIES), F01, F02 (7 SERIES), F07 (GRAN TURISMO 5 SERIES), AND F10 (5 SERIES). NO MODEL YEARS ARE LISTED. *PE UPDATED 2/7/11. *PE UPDATED 6/10/11. *PE

SERVICE ENGINE SOON LAMP IS ILLUMINATED, AND ONE OF THE FOLLOWING DRIVABILITY CONCERNS HAS OCCURRED-ENGINE CRANKS BUT WILL NOT START; LOSS OF POWER; ENGINE HAS POOR THROTTLE RESPONSE (REDUCED POWER MODE IS DISPLAYED). NO MODEL YEARS LISTED. *PE UPDATED 2/7/11. *PE

SITUATION (1) SERVICE ENGINE SOON LAMP IS ILLUMINATED WITH VARIOUS MISFIRE FAULT CODES (E.G., 29CC, 29D2, 29D1, 29D0, 29C0, 29CF) STORED IN DME CONTROL MODULE. DO NOT FOLLOW THE RECOMMENDATION OF THE TEST PLAN TO REPLACE A COMPLETE SET OF THE INJECTORS. SITUATION (2) SERVICE ENGINE SOON LAMP IS ILLUMINATED AND A SINGLE, INDIVIDUAL CYLINDER MISFIRE FAULT IS STORE IN THE DME. SWAP THE AFFECTED INJECTOR WITH ONE FROM ANOTHER BANK. NO MODELS OR MODEL YEARS ARE LISTED. *PE

THE MODELS UTILIZE A SINGLE SERPENTINE DRIVE BELT FOR THE POWER STEERING PUMP, ALTERNATOR, AND AIR CONDITIONER COMPRESSOR. DURING NORMAL DRIVING, THE FRONT ENGINE MOUNTS ALLOW THE ENGINE TO MOVE SLIGHTLY ON THE FRONT AXLE CARRIER. HOWEVER, UNDER EXTREME CONDITIONS, SUCH AS DRIVING AT HIGH RATES OF SPEED OVER CURBS OR SPEED BUMPS, THE ENGINE MOVEMENT CAN RESULT IN THE SERPENTINE BELT OR POWER STEERING PUMP PULLEY CONTACTING THE FRONT ENGINE CARRIER. IF THIS OCCURS, THE BELT AND/OR PUMP PULLEY COULD BE DAMAGED. NO MODEL YEARS LISTED. *PE

CERTAIN AREAS OF THE US EXPERIENCE EXTREMELY COLD CLIMATE CONDITIONS DURING THE WINTER MONTHS. A SMALL NUMBER OF VEHICLES HAVE EXPERIENCED PROBLEMS RANGING FROM LEAKING OR BROKEN VALVE COVERS TO COMPLETE ENGINE FAILURE. INCLUDE MODELS E39, 46, 53, 60, 83, AND E85. NO MODEL YEARS LISTED. *PE

VEHICLES WITH M57Y DIESEL ENGINE. SERVICE ENGINE SOON LAMP (MIL) IS ILLUMINATED ERRONEOUSLY. DDE SOFTWARE ERROR. *PE

REPLACE CHARGE AIR TEMPERATURE SENSOR. REPROGRAM CONTROL UNITS (DDE). REFER TO SI B130410 AND SI B130310. AFFECTS E70 AND E90 VEHICLES. NO MODEL YEARS LISTED. *PE

FUEL TANK IS EMPTY; FAULT CODE 2A1C (FUEL LEVEL PLAUSIBILITY) IS STORED IN MSV80. RIGHT SIDE FUEL SENDING UNIT IS DISLODGED FROM ITS BRACKET DUE TO INCORRECT ASSEMBLY. NO MODEL YEARS LISTED. *PE UPDATED 4/29/11. *PE

AFTER TURNING OFF ENGINE, A SLIGHT RATTLE NOISE IS HEARD FROM THE ENGINE COMPARTMENT. THIS NOISE IS SIMILAR TO A MECHANICAL TYPEWRITER. IN ADDITION, THE COMPLAINTS OF A SLIGHT REDUCTION OF POWER SIMILAR TO AN INCREASED TURBO LAG. THE VACUUM SUPPLY TO THE WASTE GATES MAY BE RESTRICTED OR BLOCKED. NO MODEL YEARS LISTED. *PE

THIS SITUATION MAY OCCUR AFTER DRIVING FOR SOME TIME WITH THE ENGINE ALREADY AT FULL OPERATING TEMPERATURE. IF THE IGNITION IS CYCLED, THE ENGINE THEN USUALLY PERFORMS NORMALLY. *PE UPDATED 2/7/11. *PE UPDATED ON 06/09/2011. *KB UPDATED 8/10/11. *PE UPDATED 1/11/13. *PE

increased to 15 years / 186,000 miles as determined from the original first in-service / delivery date.

increased to 15 years / 240,000 miles as determined from the original first in-service / delivery date.

This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle discharged battery complaints.

"track day" cars some of which may be used on both track and highway. SB 23-01 adresses proper installation torque of cap bolt fasteners attaching SPL's aftermarket lower control arms, recurring inspection and confirmation of torque setting and removal and replacement of damaged or under torqued fasteners to reduce risk of premature failure and accident. SB-23-01 was mailed, emailed and posted on SPL website to known resellers, race teams and users of the affected parts and is being submitted here as required by part 579.5. Vehicle Applications include: BMW series 1,2,3,& 4, 2008-2023; Chevrolet Camaro 26-2023, Cadillac ATS, CTS 2016-2019; Ford Mustang 2015-2023; Toyota Supra 2020-2023.

ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle "discharged battery" complaints. In order to properly repair the vehicle the first time in the workshop, it is very important that the diagnostic test plans are performed to completion, with all results taken into consideration. Without performing the energy diagnosis test plan, the root cause of the discharged battery cannot be identified. This increases the chances of a repeat repair.

MODEL 2008-14 F01, F02, F06, F07, F10, F12, F13, F25. *PE

THIS IS CAUSING THE BATTER TO NEED TO UNDERGO AN ENERGY DIAGNOSIS. *KB

UPDATED 03/11/2013 *JS

MODELS 2011-2012 3 SERIES. *PE UPDATED 7/10/13. *PE

*PE

THE CENTRAL LOCKING SYSTEM FAILS TO OPERATE WITH THE REMOTE KEY. THE KEY CANNOT BE INSERTED INTO THE KEY SLOT. COMMUNICATION TO THE VEHICLE IS NOT POSSIBLE. THE POSITIVE BATTERY CABLE CONNECTION AT THE FRONT POWER DISTRIBUTION BOX LOSES CONNECTION. *RM

THERE MAY ALSO BE WARNING LIGHTS ON. K-CAN WIRING IN THE VEHICLE SHORTED. *RM UPDATED 10/5/11. *PE

*RM

E60/E92. *RM UPDATED 9/30/11. *PE

*RM

5-10 SECONDS BECAUSE OF A VOLTAGE LEVEL DIP. *RM

TEILECLEARING PROCESS HAS BEEN DEVELOPED TO HELP IDENTIFY THE ROOT CAUSES OF CUSTOMER COMPLAINTS RELATING TO THE DMTL SYSTEM (E.G., EVAPORATIVE SYSTEM LEAKS, CHECK FILLER CAP MESSAGE, ETC.). THIS PROCESS CAN HELP EXPEDITE THE DEFECT ERADICATION PROCESS, ONCE THE ROOT CAUSE BEEN DETERMINED. NO MODEL YEARS LISTED. *PE UPDATED 8/3/11. *PE UPDATED 8/10/11. *PE UPDATED 4/24/12. *PE

THERE IS A SOFTWARE ERROR IN THE JBBFE-3R CONTROL MODULE. VERY INTERMITTENTLY, THE JBBFE-3R WAKES UP IN BOOTLOADER ODE INSTEAD OF APPLICATION MODE. PERFORM DIAGNOSTICS WITH ISTA AND WORK THROUGH ANY RELATED TEST MODULES. *PE

WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS WELL. IN SOME CASES, EPC DOES NOT SHOW THAT THE REPAIR KIT IS AVAILABLE SEPARATELY IN THE ILLUSTRATION, BUT IT IS AVAILABLE IN THE PARTS DESCRIPTION. ALL MODELS. NO MODEL YEARS LISTED. *PE

THE CASE WHERE IT IS NECESSARY TO REPLACE THE RIGHT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING DOES NOT NEED TO BE REPLACED. NO MODEL YEARS LISTED. *PE

IT AFFECTS THE ILLUMINATION OF THE SPEEDOMETER, BUT NOT THE FUNCTION. *RM

*RM

*RM

THIS CAN BE A FAULT OF THE EXTENDER OR THE BELT IS CONTORTED. *RM

THERE IS A PROCEDURE FOR CHECKING AND FIXING THE PROBLEM. *RM

THE UPPER PART OF THE DRIVER'S OR PASSENGER'S FRONT SAFETY BELT DOES NOT ROLL UP FULLY OR ROLLS UP SLOWLY. THE ADJUSTMENT OF THE INERTIA REEL IS INCORRECT AT THE FASTENING POINT. THE BELT IS TOUCHING THE GUIDE FUNNEL. MODELS E90, E91 AND E92. NO MODEL YEARS LISTED. *PE

CAUSING UNFAVORABLE COOLING LINE CONNECTION TOLERANCES TO DAMAGE O RINGS. MODEL E84 (X1), E89 (Z4), F22 & 23 (2 SERIES), F30 & 31 (3 SERIES), F32 & 33 (4 SERIES), F34 (GRAN TURISMO), F36 (GRAN COUPE). *PE

WHEN TURNING A SLIP/STICK EFFECT IS CREATED ON THE LINING AND STEEL DISCS INCORPORATED IN THE DIFFERENTIAL CLUTCH CAUSES A GRINDING NOISE. *RM

*RM

THIS IS A SOFTWARE PROBLEM. *RM

*RM

DATA CAN'T BE READ FROM THE MODULE'S MEMORY. *RM UPDATED 8/10/11. *PE

*RM

FAULT CODE 4F81 (RATIO MONITORING, CLUTCH A), IN SOME CASES COMBINED WITH THE SUBSEQUENT FAULTS 507B/507C (PARKING GEAR SENSOR IMPLAUSIBLE SIGNAL) OR 507D (PARKING GEAR INCORRECTLY DISENGAGED), ARE STORED IN THE EGS CONTROL MODULE. E60, E51, E65, E66, E70, E90, E91, E92, E93. NO MODEL YEARS LISTED. *PE

DSC OFF FUNCTION HAS BEEN IMPLEMENTED IN M5 AND M6 VEHICLES EQUIPPED WITH THE OPTIONAL 6 SPEED MANUAL TRANSMISSIONS. NO MODEL YEARS LISTED. *PE

*JS

THERE IS CONNECTION CORROSION IN THE TAIL LAMP. *RM

LUBRICATION OF THE DOOR CAN CAUSE DEFECTS. *RM

*RM

*RM

*RM

UNDER CERTAIN CIRCUMSTANCES, A FRACTURE IN THE STEEL BODY STRUCTURE COULD FORM IN THE AREA AROUND ONE OF THE REAR AXLE CARRIER MOUNTING POINTS. AS A RESULT, A DISTINCT CLICKING NOISE CAN BE HEARD FROM THE AREA OF THE REAR AXLE CARRIER DURING CERTAIN DRIVING CONDITIONS. MODEL E46 (3SERIES). NO MODEL YEARS LISTED. *PE

*MA

*PE UPDATED 1/18/13. *PE

*RM

E70 AND E90 MODELS. *RM

*TA

THE SAFETY BELT EXTENDER EXTENDS BUT THE BELT SLIPS OFF. THE HAND ON THE EXTENDER FAILS. THE SAFETY BELT IS TWISTED. THE EXTENDER WILL NOT OPERATE AND MAKES NOISE WHILE EXTENDING. *RM

*RM

*RM

MODELS 2012 F25, 30, 01, 02, 07, 10, 12, 13, E70, 71, 84. *PE

THE WARNING LAMPS FOR DSC, ABS AND BRAKE WARNING ILLUMINATED. THERE MAY ALSO BE A WARNING IN THE CONTROL DISPLAY FOR CHASSIS CONTROL SYSTEM FAILURE. *JS

*PE MODELS 2009-2012 E70, E71, E72, E82, E88, E90, E91, E92, E93, F01, F02, F04, F07, F10, F12, F13, F25. UPDATED 11/2/12. *PE

THE BULB OUT WARNING SHOWS IN THE INSTRUMENT CLUSTER. DIAGNOSIS SHOWS A FAULT FOR THE REAR LAMP. THE BULB OUT CAN BE DISPLAYED FOR 2 POSSIBLE CAUSES: POOR FIT BETWEEN THE BULB AND BULB HOLDER; BULB FAILURE CAUSED BY VIBRATION. *PE

THE LEDS (LIGHT EMITTING DIODES) IN THE OUTER LEFT OR OUTER RIGHT REAR LAMP ARE INOPERATIVE. AFFECTED ARE THE LEDS FOR THE PARKING LAMP/TAIL LAMP OR THE TURN SIGNALS. NO CHECK CONTROL MESSAGE IS DISPLAYED. CORROSION OF AN INTERNAL CONNECTION WITH THE TAIL LAMP IS CAUSED. *PE UPDATED 9/26/11. *PE

*RM

*RM

MODEL E90, E91(3 SERIES);E92, E92 (3 SERIES); E60 (5 SERIES); E60 (M5); E63, E64 (6 SERIES); E63, E64 (M6); E65, E66 (7 SERIES); E70 (X5); E83 (X3); AND E85, E86 (Z4). *PE

*PE

*RM

INCOMPLETE, DUE TO THE VARIANTS AND SOFTWARE USED. MODEL 2008-2014.

*RM UPDATED ON 4/24/2013. *KB

COVERED UNDER THE TERMS OF THE BMW NEW VEHICLE/SAV LIMITED WARRANTY. *JS

*RM'