2007 BMW 3 Series TSBs

THE REPLACING AND/OR CHECKING OF EMISSIONS MONITORING COMPONENTS TO INCREASE EMISSIONS STABILITY, HIGH PRESSURE (HP) EGR VALVE RESTRICTION OF EXCESSIVE SOOT AND IMPROVED DIESEL EXHAUST FLUID (DEF) MIXTURE INTRODUCED IN EXHAUST SYSTEM FROM SCR MIXER. MODEL 2008-2009 E70, E90. *PE UPDATED 5/10/13. *PE

*PE UPDATED 10/31/12. *PE MODELS 2010 E70, 71, 82, 88, 90, 92, 93, F07, 10, 12, 13, 25. UPDATED 1/18/13. *PE UPDATED 4/18/2013. *KB UPDATED 05/13/2013 *JS UPDATED 5/19/15. *PE

82,000 MILES, WHICHEVER COMES FIRST, NOT OTHERWISE FALLING WITHIN COVERAGE EXCLUSION. *PE

SYMPTOMS SUCH AS ERRATIC ENGINE OPERATION AND LONGER STARTING TIMES. *PE

THERE ARE TROUBLE CODES STORED FOR THE CRANKSHAFT SENSOR. NO DRIVEABILITY ISSUES. *RM

THERE MAY BE A PROBLEM WITH THE FUEL PUMP WHICH COULD NOT MEET EMISSIONS REQUIREMENTS. THERE MAY BE A LONG CRANK AND A SERVICE ENGINE SOON LIGHT. *RM

*RM UPDATED ON 11/1/2013. *KB

THERE WILL BE STORED TROUBLE CODES. *RM

THIS IS A PROGRAMMING ISSUE. *RM UPDATED 1/4/12. *PE UPDATED 4/24/12. *PE

THERE IS A WIRING/CONNECTION PROBLEM OR A FAULTY SENSOR. *RM

THE SERVICE ENGINE SOON LIGHT MAY ALSO BE ON WITH A LACK OF ENGINE POWER. *RM

WASTEGATE VALVE IS NOT COMPLETELY CLOSING AND CLANKING. *RM UPDATED 7/17/12. *PE

THIS IS AN IGNITION COIL PROBLEM. *RM

THE VEHICLE LOST POWER AND THE ENGINE CRANKS WITH NO START. *RM UPDATED 5/19/15. *PE

THIS IS DUE TO MOISTURE ACCUMULATION. *RM

THE ENGINE WILL ONLY OPERATE TO 1500 RPMS AND LACKS POWER. THERE IS A SOFTWARE APPLICATION ERROR. *RM

*RM

*RM

THERE MAY BE SIX DIFFERENT FAULT CODES. *RM

THE LIGHT COMES ON A FEW THOUSAND MILES EARLIER THAN A RECOMMENDED OIL CHANGE. *RM

FUEL TANK IS EMPTY; FAULT CODE 2A1C (FUEL LEVEL PLAUSIBILITY) IS STORED IN MSV80. RIGHT SIDE FUEL SENDING UNIT IS DISLODGED FROM ITS BRACKET DUE TO INCORRECT ASSEMBLY. NO MODEL YEARS LISTED. *PE UPDATED 4/29/11. *PE

THE SITUATION OCCURS ONLY DURING THE ENGINE WARM UP PHASE (COLD ENGINE), AND CANNOT BE REPRODUCED IN THE SPORT MODE. EGS SOFTWARE-UNFAVORABLE NIC CALIBRATION. *PE UPDATED 9/28/11. *PE

THIS SITUATION CAN OCCUR IF THE VEHICLE SITS FOR EXTENDED PERIODS OF TIME. ALTHOUGH THE BRAKE PEDAL CAN BE DEPRESSED, THE CUSTOMER MAY NOTE A CHANGE IN PEDAL FEEL. *PE

AN INTERNAL COMPONENT IN THE HIGH PRESSURE PUMP (HDP) MAY FAIL, CAUSING DRIVEABILITY SYMPTOMS SUCH AS LONGER STARTING TIMES OR ERRATIC ENGINE OPERATION. IT MAY ALSO LEAD TO A PREMATURE FAILURE OF THE HDP ON VEHICLES AT HIGHER MILEAGES.

A GRINDING OR SCRAPING NOISE MAY BE HEARD WHILE CORNERING AT VEHICLE SPEEDS UP TO 30 MPH. THE NOISE IS MORE PRONOUNCED WHILE THE VEHICLE IS IN THE WARM UP PHASE AND MAY CHANGE INTENSITY DURING LEFT AND RIGHT TURNS. THE RIGHT SIDE ENGINE SUPPORT IS MAKING CONTACT WITH THE RIGHT SIDE ENGINE MOUNT. *PE

AFTER TURNING OFF ENGINE, A SLIGHT RATTLE NOISE IS HEARD FROM THE ENGINE COMPARTMENT. THIS NOISE IS SIMILAR TO A MECHANICAL TYPEWRITER. IN ADDITION, THE COMPLAINTS OF A SLIGHT REDUCTION OF POWER SIMILAR TO AN INCREASED TURBO LAG. THE VACUUM SUPPLY TO THE WASTE GATES MAY BE RESTRICTED OR BLOCKED. NO MODEL YEARS LISTED. *PE

THIS SITUATION MAY OCCUR AFTER DRIVING FOR SOME TIME WITH THE ENGINE ALREADY AT FULL OPERATING TEMPERATURE. IF THE IGNITION IS CYCLED, THE ENGINE THEN USUALLY PERFORMS NORMALLY. *PE UPDATED 2/7/11. *PE UPDATED ON 06/09/2011. *KB UPDATED 8/10/11. *PE UPDATED 1/11/13. *PE

E82, E88, E90, E92, E93, E60, E61, AND E71. ALL MODELS WITH NAY ENGINES. NO MODEL YEARS LISTED. *PE UPDATED 09/30/11. *PE

P WHEN ENGINE IS TURNED OFF IS DISPLAYED IN THE CC WHEN THE VEHICLE DECELERATES TO A STOP. IN REALTY, THE TRANSMISSION STAYS ENGAGED IN A FIRST OR SECOND GEAR AND DOES NOT SHIFTS TO NEUTRAL, AS INDICATED BY THE INSTRUMENT CLUSTER DISPLAY. NO MODEL YEARS LISTED. E90, E92, E93 (3 SERIES) 2002-2009. *PE

SOFTWARE ERROR IN THE DME FOR THE TANK LEAK DIAGNOSTIC SYSTEM. MODELS E60, E61 (5 SERIES); E70 (X5); E71 (X6); E82, E88 (1 SERIES); E83 (X3); E90, E91, E92, E93 (3 SERIES). *PE

DME FC 2A15 MINOR LEAK AND 2A16 SUPERFINE LEAK IN EVAPORATION SYSTEM. TANK VENTILATION CORRUGATED HOSE MAY CONTACT THE LOW SIDE AIR CONDITIONING PRESSURE LINE ALUMINUM FERREL. THIS CONTACT MAY CAUSE A SMALL LEAK. *PE

OIL LEVEL COULD BE LOWER THAN WHAT IS DISPLAYED AND THE LOW OIL LEVEL WARNING IS NOT PROMPTLY SHOWN. E60, E61, E82, E90, E92 & E93 MODELS. *PE

MODELS E60 (5 SERIES), E70 (X5 SERIES), E83 (X3 SERIES), E9X (3 SERIES). *PE

MODELS E90, E92 AND E93 (3 SERIES) 335I AND 335XI; E60 AND E61 (5 SERIES) 535I AND 535XI, ALL WITH N54 ENGINE FROM THE START OF PRODUCTION TO JANUARY 17, 2008 PRODUCTION. *PE

FOR 2007 MODEL E60, E61, E90, E92, E93 WITH N54 ENGINE. *PE

VEHICLES WITH M56 ENGINE FROM START OF PRODUCTION TO THE PRESENT (SULEV VEHICLES ONLY). MODEL E46 (3 SERIES) *PE

increased to 15 years / 186,000 miles as determined from the original first in-service / delivery date.

increased to 15 years / 240,000 miles as determined from the original first in-service / delivery date.

This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle discharged battery complaints.

ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle "discharged battery" complaints. In order to properly repair the vehicle the first time in the workshop, it is very important that the diagnostic test plans are performed to completion, with all results taken into consideration. Without performing the energy diagnosis test plan, the root cause of the discharged battery cannot be identified. This increases the chances of a repeat repair.

LIMITED WARRANTY HAS BEEN EXTENDED, UP TO 15 YEARS, ON CERTAIN VEHICLES, WITHOUT MILEAGE LIMITATION FOR FRONT PASSENGER AIR BAG SEAT OCCUPANCY SENSOR (OC3) (MATERIALS AND WORKMANSHIP). MODEL 2006-2007 E60 (5 SERIES SEDAN, E61 (5 SERIES SPORTSWAGON), E85 (Z4 ROADSTER), E90 (3 SERIES), E90 (3 SERIES SPORT WAGON). *PE

THIS IS CAUSING THE BATTER TO NEED TO UNDERGO AN ENERGY DIAGNOSIS. *KB

UPDATED 03/11/2013 *JS

*PE

THE CENTRAL LOCKING SYSTEM FAILS TO OPERATE WITH THE REMOTE KEY. THE KEY CANNOT BE INSERTED INTO THE KEY SLOT. COMMUNICATION TO THE VEHICLE IS NOT POSSIBLE. THE POSITIVE BATTERY CABLE CONNECTION AT THE FRONT POWER DISTRIBUTION BOX LOSES CONNECTION. *RM

THERE MAY ALSO BE WARNING LIGHTS ON. K-CAN WIRING IN THE VEHICLE SHORTED. *RM UPDATED 10/5/11. *PE

E60/E92. *RM UPDATED 9/30/11. *PE

E91. *RM

TEILECLEARING PROCESS HAS BEEN DEVELOPED TO HELP IDENTIFY THE ROOT CAUSES OF CUSTOMER COMPLAINTS RELATING TO THE DMTL SYSTEM (E.G., EVAPORATIVE SYSTEM LEAKS, CHECK FILLER CAP MESSAGE, ETC.). THIS PROCESS CAN HELP EXPEDITE THE DEFECT ERADICATION PROCESS, ONCE THE ROOT CAUSE BEEN DETERMINED. NO MODEL YEARS LISTED. *PE UPDATED 8/3/11. *PE UPDATED 8/10/11. *PE UPDATED 4/24/12. *PE

WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS WELL. IN SOME CASES, EPC DOES NOT SHOW THAT THE REPAIR KIT IS AVAILABLE SEPARATELY IN THE ILLUSTRATION, BUT IT IS AVAILABLE IN THE PARTS DESCRIPTION. ALL MODELS. NO MODEL YEARS LISTED. *PE

THE CASE WHERE IT IS NECESSARY TO REPLACE THE RIGHT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING DOES NOT NEED TO BE REPLACED. NO MODEL YEARS LISTED. *PE

SYMPTOMS TYPICALLY INCLUDE VARIOUS WARNING LAMPS IN THE INSTRUMENT CLUSTER AND STARTING PROBLEMS. AFFECTED MAY BE THE EKP (ELECTRONICALLY CONTROLLED FUEL PUMP), AND CONTROL MODULES ON THE PT CAN OR CONNECTED TO THE 15WUP (WAKE UP) LINE. FUSE F70 MAY BE BLOWN. NO MODEL YEARS LISTED. E93 (3 SERIES CONVERTIBLE). *PE

IMPLAUSIBLE (SHOWS EMPTY); REAR WINDOWS ONE TOUCH FUNCTION IS INOPERATIVE; WINDSHIELD WIPERS ARE WORKING WITH BEING SWITCHED ON; AND VARIOUS WARNING LIGHTS ARE ILLUMINATED ON THE INSTRUMENT PANEL. MODEL YEARS UNKNOWN. *PE

WHEELS ON MODELS E90, E91, E92, AND E93 (3 SERIES). *PE

ON EARLY PRODUCTION E92S, THE SOCKET WHICH SECURES THE SEAT BACKREST RELEASE CABLE TO THE RELEASE MECHANISM COULD PULL FREE FROM THE RELEASE MECHANISM. *PE

MODEL 3 SERIES WITH OPTION 6FL (USA AUDIO INTERFACE). *NJ

THIS CAN BE A FAULT OF THE EXTENDER OR THE BELT IS CONTORTED. *RM

THE UPPER PART OF THE DRIVER'S OR PASSENGER'S FRONT SAFETY BELT DOES NOT ROLL UP FULLY OR ROLLS UP SLOWLY. THE ADJUSTMENT OF THE INERTIA REEL IS INCORRECT AT THE FASTENING POINT. THE BELT IS TOUCHING THE GUIDE FUNNEL. MODELS E90, E91 AND E92. NO MODEL YEARS LISTED. *PE

THIS CAUSES THE MANUAL AND AUTOMATIC EMERGENCY CALL AND ROADSIDE CALL (BMW ASSIST) NOT TO FUNCTION. MODELS E53, E60, E90, E83 ARE AFFECTED. *PE

DURING ASSEMBLY PROCESS, THE FRONT PROPELLER SHAFT BOLTS MAY HAVE BEEN INSUFFICIENTLY TIGHTENED. MODELS E90, E91 (3 SERIES), 328XI, 328XIT, AND 335XI. MY 2007. *PE

*JS

*RM

UNDER CERTAIN CIRCUMSTANCES, A FRACTURE IN THE STEEL BODY STRUCTURE COULD FORM IN THE AREA AROUND ONE OF THE REAR AXLE CARRIER MOUNTING POINTS. AS A RESULT, A DISTINCT CLICKING NOISE CAN BE HEARD FROM THE AREA OF THE REAR AXLE CARRIER DURING CERTAIN DRIVING CONDITIONS. MODEL E46 (3SERIES). NO MODEL YEARS LISTED. *PE

*PE UPDATED1/4/10. *PE UPDATED 5/24/10. *PE

irritating to the customer; or it is not possible to locate certain addresses, for instance:

irritating to the customer; or it is not possible to locate certain addresses, for instance:

THE BULB OUT WARNING SHOWS IN THE INSTRUMENT CLUSTER. DIAGNOSIS SHOWS A FAULT FOR THE REAR LAMP. THE BULB OUT CAN BE DISPLAYED FOR 2 POSSIBLE CAUSES: POOR FIT BETWEEN THE BULB AND BULB HOLDER; BULB FAILURE CAUSED BY VIBRATION. *PE

THE BULB OUT WARNING SHOWS IN THE INSTRUMENT CLUSTER. DIAGNOSIS SHOWS A FAULT FOR THE REAR LAMP. THE BULB OUT CAN BE DISPLAYED FOR 2 POSSIBLE CAUSES-POOR FIT BETWEEN THE BULB AND BULB HOLDER; (NEW) BULB FAILURE CAUSED BY VIBRATIONS. MODEL E92 (3 SERIES COUP). NO MODEL YEARS LISTED. *PE UPDATED 6/23/10. *PE UPDATED 2/7/11. *PE

MODELS E92, E93 (3 SERIES). *PE

WHEN TURNING A SLIP/STICK EFFECT IS CREATED ON THE LINING AND STEEL DISCS INCORPORATED IN THE DIFFERENTIAL CLUTCH CAUSES A GRINDING NOISE. *RM

*RM

*RM

FAULT CODE 4F81 (RATIO MONITORING, CLUTCH A), IN SOME CASES COMBINED WITH THE SUBSEQUENT FAULTS 507B/507C (PARKING GEAR SENSOR IMPLAUSIBLE SIGNAL) OR 507D (PARKING GEAR INCORRECTLY DISENGAGED), ARE STORED IN THE EGS CONTROL MODULE. E60, E51, E65, E66, E70, E90, E91, E92, E93. NO MODEL YEARS LISTED. *PE

DSC OFF FUNCTION HAS BEEN IMPLEMENTED IN M5 AND M6 VEHICLES EQUIPPED WITH THE OPTIONAL 6 SPEED MANUAL TRANSMISSIONS. NO MODEL YEARS LISTED. *PE

*RM

MODEL E90, E91(3 SERIES);E92, E92 (3 SERIES); E60 (5 SERIES); E60 (M5); E63, E64 (6 SERIES); E63, E64 (M6); E65, E66 (7 SERIES); E70 (X5); E83 (X3); AND E85, E86 (Z4). *PE

WATER OR CONDENSATION IN ONE OR BOTH HEADLAMPS. MODELS 5 SERIES, 6 SERIES, 7 SERIES, X5, X6, 1 SERIES, AND 3 SERIES. MODEL YEARS 2000-20008. *PE

THE BULB OUT WARNING SHOWS IN THE INSTRUMENT CLUSTER. *PE

THE SAFETY BELT EXTENDER EXTENDS BUT THE BELT SLIPS OFF. THE HAND ON THE EXTENDER FAILS. THE SAFETY BELT IS TWISTED. THE EXTENDER WILL NOT OPERATE AND MAKES NOISE WHILE EXTENDING. *RM

THE POSITION AT WHICH THE ASSISTANT COMES TO REST VARIES. E92. *RM

*RM

THE WARNING LAMPS FOR DSC, ABS AND BRAKE WARNING ILLUMINATED. THERE MAY ALSO BE A WARNING IN THE CONTROL DISPLAY FOR CHASSIS CONTROL SYSTEM FAILURE. *JS

COVERED UNDER THE TERMS OF THE BMW NEW VEHICLE/SAV LIMITED WARRANTY. *JS

*RM UPDATED ON 4/24/2013. *KB

*RM

INSUFFICIENT SEALING AT THE POINT OF CONTACT BETWEEN THE AIR CONDITIONING SYSTEM AND THE CONDENSATION DRAIN HOSE. *PE

A POTENTIAL PROBLEM THAT COULD AFFECT THE DURABILITY OF THE HIGH PRESSURE FUEL PUMP (HDP) OF CERTAIN VEHICLES. MODELS 335I/XI; 535I/XI AND 135IS; MODEL YEARS 2007-2008. *PE UPDATED 4/23/10. *PE UPDATED 11/1/10. *PE UPDATED 11/17/10. *PE

THIS SERVICE ACTION INVOLVES E90, E91, E92, E93 (3 SERIES) AND E60, E61 (5 SERIES) VEHICLES WHICH WERE PRODUCED FROM 2/1/07 TO 3/9/07. *PE