2002 BMW 1 Series TSBs

THIS IS DESIGNATED FOR E70, AND E90 MODELS WITH M57Y DIESEL ENGINES. SERVICE ENGINE SOON LAMP MAY BE ILLUMINATED. *KB

THE CABLES, EME HIGH VOLTAGE, SHOULD BE REINSTALLED IN ORIGINAL FACTORY POSITION TO AVOID CONTACT WITH EXPOSED FASTENERS IN REAR RIGHT WHEEL HOUSING AND POSSIBLE DAMAGE TO INSULATION. MODEL E82E (1SERIES). NO MODEL YEAR LISTED. *PE

THERE ARE TROUBLE CODES STORED FOR THE CRANKSHAFT SENSOR. NO DRIVEABILITY ISSUES. *RM

THERE WILL BE STORED TROUBLE CODES. *RM

THE SERVICE ENGINE SOON LIGHT MAY ALSO BE ON WITH A LACK OF ENGINE POWER. *RM

FUEL TANK IS EMPTY; FAULT CODE 2A1C (FUEL LEVEL PLAUSIBILITY) IS STORED IN MSV80. RIGHT SIDE FUEL SENDING UNIT IS DISLODGED FROM ITS BRACKET DUE TO INCORRECT ASSEMBLY. NO MODEL YEARS LISTED. *PE UPDATED 4/29/11. *PE

E82, E88, E90, E92, E93, E60, E61, AND E71. ALL MODELS WITH NAY ENGINES. NO MODEL YEARS LISTED. *PE UPDATED 09/30/11. *PE

SLEEVE S IN THE CHARGING SOCKET MAY BE MISSING. BMW MODEL E28E. *KB

CRUISE CONTROL ACTION FUNCTION CAN OCCASIONALLY ACTIVATE AND DEACTIVATE DUE TO THE ASC IMPLAUSABILITY WHEN THE DSC WARNING LAMP IS FLASHING ON THE INSTRUMENT CLUSTER. BMW. *KB

*RM

WATER OR CONDENSATION IN ONE OR BOTH HEADLAMPS. MODELS 5 SERIES, 6 SERIES, 7 SERIES, X5, X6, 1 SERIES, AND 3 SERIES. MODEL YEARS 2000-20008. *PE

MODELS E82, E88, E90, E91, E92, E93. MODEL YEARS UNKNOWN. *KB UPDATED 12/6/13. *PE

WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS WELL. IN SOME CASES, EPC DOES NOT SHOW THAT THE REPAIR KIT IS AVAILABLE SEPARATELY IN THE ILLUSTRATION, BUT IT IS AVAILABLE IN THE PARTS DESCRIPTION. ALL MODELS. NO MODEL YEARS LISTED. *PE

A PART REPLACEMENT AUTHORIZATION MUST BE OBTAINED BY SUBMITTING A TC CASE IN PUMA BEFORE ANY OF THE FOLLOWING DSC COMPONENTS ARE REPLACED UNDER WARRANTY FOR THE VEHICLES LISTED IN THE MODEL SECTION OF THIS BULLETIN: DSC CONTROL MODULE, DSC HYDRO UNIT, AND YAW RATE SENSOR. NO MODEL YEARS LISTED. *PE

SEALING, CAUSING CARPET TO BE WET IN CENTER TUNNEL AREA. *PE

*RM

*RM

THIS IS ALLOWING WATER TO LEAK IN. *RM UPDATED 1/06/12. *PE

THE MOUNTING TENSION ON THE THIRD BRAKE LIGHT LENS IS CAUSING THE LENS TO CRACK FROM THE BODY. WHEN INSTALLING OR REPLACING THE THIRD BRAKE LIGHT, P/N 63 25 7 165 978, ADDITIONAL SPACERS MUST BE ADDED TO THE MOUNTING STUDS TO REDUCE THE MOUNTING TENSION. (E82 E88). *PE

BMW F25, AND F30 MODELS. *KB

BMW MODEL F30. *KB

*RM

*RM

INSUFFICIENT SEALING AT THE POINT OF CONTACT BETWEEN THE AIR CONDITIONING SYSTEM AND THE CONDENSATION DRAIN HOSE. *PE

THIS WATER MAY BE PRESENT IN EITHER SIDE AREA, OR IN THE WHEEL WELL AREA. NO MODEL YEARS LISTED. *PE